Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Engine - Vibration At Idle
- A/C - Compressor Leaking/Inoperative
- A/C - Water in Blower Motor Case
- Suspension - Creak, Crunch, Grinding or Rattle Noise
- Body - Trunk/Liftgate Area Water Leaks
- Emissions - MIL ON/DTC's P0402/P0403/Runs Rough
- Brakes - Rear Drum Brake Squealing Noises
- Engine Controls - Hard Start/Driveability Issues
- Emissions - Stall/MIL ON/DTC P2195 Set
- Exhaust System - Catalytic Converter Bracket Broken
- Electrical - Horn Inoperative
- Wipers/Washers - Loss of Intermittent or Park Functions
- Body, A/C - Water Leaks to Vehicle Interior
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Exhaust System - Catalytic Converter Heat Shield Loose
- Body - Hood Latch Difficult/Unable to Open
- Suspension - Rear Tire Inner Edge Wear
- Lighting - Turn Signal Lamps Won't Self-Cancel
- Interior - Carpet Pulling Away From R/H Kick Panel
- M/T - Hard to Shift Gears
- M/T - Difficult or Unable to Shift Into 5th Gear
- Ignition System - Cannot Remove/Turn Key/Chime ON
- Body - Power Door Locks Cycling/Self-Locking
- A/C - Heater Core Electrolysis/Leakage
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Interior - Console Arm Rest Pivot Loose
- Brakes - Rear Drum Brake Squealing Noise
- M/T - Clutch Pedal Squeaks/Excessive Free Play
- Superceded Bulletins
- 07-12-4 -06/25/07
- 04B16 - 08/31/04
- Rear Window Defroster - Inoperative
- Interior - Carpet Pulling Away From Kick Panel
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Suspension - Front Suspension Creaking/Crunching
- Suspension - Creaking/Grinding on Turns/Bumps
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Electrical - Wiring Harness Replacement Tips
- Electrical - Wire Harness Replacement Service Tips
- Electrical - Wiring Harness Replacement Guidelines/Tips
- Battery - Service/Charging Tips
- Brakes - Rear Drum Brake Squealing Upon Application
- M/T - Clutch Pedal Squeak/Excessive Free Play
- Ignition - Key Hard to Turn/Remove from Ignition Lock
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON/EVAP System DTC's Set
- Engine - Cylinder Head Straightedge Flatness Check
- Engine - Excessive Vibration At Idle
- Engine - Vibrates At Idle
- Engine - Excessive Idle Vibration
- Engine - Vibrates at Idle
- Engine - Vibration At Idle
- Engine - Vibration at Idle
- Engine - Excessive Vibration at Idle
- Engine - Crankshaft Pulley Bolt Removal Precaution
- Battery - Battery EYE Function/Charging Service Tips
- M/T - Rattling Noise at Idle With Clutch Pedal Released
- M/T - Noise at Idle with Clutch Released
- Body/Interior - Water Leaks on Passenger Floor Area
- Cooling System - 'Premium Gold Coolant' Service Tips
- Ignition System - Engine Misfire Diagnostics Tips
- All Technical Service Bulletins
- Engine - Vibration At Idle
- A/C System - Diagnosis and Service Tips
- A/C - Compressor Leaking/Inoperative
- A/C - Water in Blower Motor Case
- Suspension - Creak, Crunch, Grinding or Rattle Noise
- Engine - Cylinder Head Straightedge Surface Check
- Campaign - Coil Spring Corrosion Warranty Extension
- Body - Trunk/Liftgate Area Water Leaks
- Recall - Rear Door Latch Corrosion/Won't Latch Correctly
- A/T - Cooler Flushing Service Tips
- Emissions - MIL ON/DTC's P0402/P0403/Runs Rough
- Brakes - Rear Drum Brake Squealing Noises
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - Hard Start/Driveability Issues
- Engine Controls - General PCM Programming Procedures
- Engine Controls - Incomplete I/M Readiness Status
- Emissions - Stall/MIL ON/DTC P2195 Set
- Exhaust System - Catalytic Converter Bracket Broken
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Engine - Oil Level Indicator Markings
- Electrical - Horn Inoperative
- Wipers/Washers - Loss of Intermittent or Park Functions
- Body, A/C - Water Leaks to Vehicle Interior
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Exhaust System - Catalytic Converter Heat Shield Loose
- Engine Controls - MIL ON/Lean DTC Service Tips
- Body - Hood Latch Difficult/Unable to Open
- Body - Exterior Mirror Glass/Motor Service Tips
- Cooling System - Premium Gold Coolant Service Info
- Drivetrain - Intermediate Axle Shaft Bearing Replacement
- Suspension - Rear Tire Inner Edge Wear
- Lighting - Turn Signal Lamps Won't Self-Cancel
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Interior - Carpet Pulling Away From R/H Kick Panel
- Paint - New Polishing Products and Procedures
- Paint - Approved Paint Materials
- Paint - Plastic Bumper/Fascia Service Tips
- Campaign - Seat Heater Element Replacement
- M/T - Hard to Shift Gears
- M/T - Difficult or Unable to Shift Into 5th Gear
- Ignition System - Cannot Remove/Turn Key/Chime ON
- Body - Power Door Locks Cycling/Self-Locking
- A/C - Heater Core Electrolysis/Leakage
- Keyless Entry - Keypad Diagnostics
- Clutch - MTX-75 Premature Clutch Failure
- Emissions - Revised EGR Tube Service Procedure
- Steering - Mercon V(R) Fluid Usage
- Electrical - Wiring Harness Replacement Guidelines
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Interior - Console Arm Rest Pivot Loose
- Steering/Frame - Vehicle Pulling or Drifting
- Brakes - Rear Drum Brake Squealing Noise
- M/T - Clutch Pedal Squeaks/Excessive Free Play