Removal and Installation

TRANSMISSION REPLACEMENT

Remove or Disconnect










Tool Required:
J-1126, Transmission Guide Pin (4 speed)

- Raise the vehicle
1. Transmission oil.
2. Shift control and rods if used, (3 speed/4 speed O.D.).
- Shift lever, (4 speed).
3. Propeller shaft. Service and Repair
4. Transfer case if used. Service and Repair
5. Parking brake and controls if used.
6. Speedometer cable (112) and the seal (113).
7. Wiring harnesses as used.
8. Exhaust pipes.
- Support the transmission with a jack.
9. Any parts if needed for clearance.
10. Crossmember.
11. Screws (101) and the spring washers (100).
- Remove the top two first and install guide pins J-1126 (4 speed).
12. Transmission (104).

Important
- Do not let the transmission hang from the clutch.
- Pull the transmission straight back on the clutch hub spines.
- Support the clutch release bearing.

13. Plugs (114), if they are loose or damaged.
- Note the location of the plugs before removing.

Install or Connect










Tool Required:
J-1126, Transmission Guide Pin (4 speed)

1. New plugs (114) if needed.
- Put a thin coat of high temperature grease on the main drive gear splines.
2. Transmission (104).
- Shift the transmission into high gear before installing.
- Install guide pins J-1126 in the top two holes (4 speed).
- Remove the clutch release bearing support.

Important
- Do not force the transmission into the clutch.
- Do not let the transmission hang from the clutch, leave the jack under the transmission to support it.

3. New spring washers (100) and the screws (101).
- Install the two bottom screws before removing the guide pins (4 speed).
4. Crossmember.
- Remove the jack.
5. Any parts that were removed for clearance.
6. Exhaust pipes.
7. Wiring harnesses as used.
8. New seal (113) and the speedometer cable (112).
9. Parking brake lever and controls if used.
10. Transfer case if used. Service and Repair
11. Propeller shaft. Service and Repair
12. Shift control and rods if used, (3 speed/4speed O.D.).
- Shift lever (4 speed).
- Adjust the shift linkage.
13. New transmission oil.
- Lower the vehicle.