Repair and Diagnosis: Technical Service Bulletins

• How to Find Technical Service Bulletins by Category/Symptom
• Recalls
  • Generals
    • Campaign - Water Leak in Passenger Compartment
  • Safety
    • Recall - Intermediate Steering Shaft Separation
      • Overview
      • Owner Letter
    • Recall 11V339000: Steering Shaft Separation
    • Recall - Rear Axle Cross Pin Fracture
      • Overview
      • Owner Letter
• Customer Interest
  • Interior - Eliminating Unwanted Odors in Vehicles
  • Engine Controls - MIL ON, DTC P2135, Reduced Engine Power
  • Engine Controls - MIL ON/DTC P2135 Set
  • Suspension/Steering - Pop,Click,Or Clunk Noise At Low Speeds
  • Body - LH/RH Outside Rearview Mirror Glass Shake/Flutter
  • Body - Rear Door Handle, Latch, Lock Inoperative, Won't Open
  • Interior - Third Row Seat Won't Release From Floor
    • Overview
    • Condition/Cause/Correction # 1
    • Condition/Cause/Correction # 2
    • Condition/Cause/Correction # 3
    • Condition/Cause/Correction # 4
    • Condition/Cause/Correction # 5
    • Condition/Cause/Correction # 6
  • Engine/Engine Controls - MIL ON, Engine Running Rough/DTC P0300
  • Door Locks - Loss of Power Door Lock Function
  • Body - Broken Rear Window Defogger Grid Detection
  • Engine - Valve Lifter Tick Noise At Start Up
  • Audio System - Noise When Using Portable Playback Unit
  • Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
  • Steering - Power Steering Leaking Fluid
  • Restraint System - Repeat DTC's/Air Bag Warning Lamp On
  • Power Steering - Fluid Leaks Due to Extreme Low Temps
  • Interior - 2nd Row Seat Rattles/Hard To Latch/Unlatch
  • Lighting - Low Beam Headlamp(s) Inoperative
  • Restraints - Seat Belt Latching Issues/Warning Lights
  • Exhaust System - Exhaust Leak/Rattle/Rumble/Noise
  • Restraints - Air Bag Lamp ON/Multiple DTCs
  • Tires/Wheels - Tire Slowly Goes Flat/Warning Light ON
  • Engine - Oil Leak At Oil Cooler Hose/Pipe Assembly
  • A/C - Musty Odors Emitted From (HVAC) System
  • Body/Glass - Windshield Wiper Chatter/Noise/Streaking
  • A/C - Excessive Cabin Moisture/Reduced Window Clearing
  • Engine - MIL ON P0116/P1400 Set In Very Cold Temps
  • Suspension - Multiple Noises From Front Of Vehicle
  • Electrical - Electrical Malfunction/Multiple DTCs
    • Overview
    • Correction
      • Part 1
      • Part 2
      • Part 3
      • Part 4
  • Interior, A/C - Air Vent Deflector Knob Missing/Loose
  • Air Conditioning - A/C Blows Warm Air Intermittently
  • Body - Chrome Outside Door Handle Loose/Cracked
  • Interior - Sun Visor Fails to Stay In Up Position
  • Body - Colored Side Mouldings Dull/Discolored/Stained
  • Body - Sticking/Binding Door Mounted Seat Switches
  • Body - Front Door Window Regulator Squeak Noise
  • Tires/Wheels - Rattle Noise from Wheel Or Hub Cap
  • Body/Frame - Underbody Pop/Clunk When Turning
  • A/C - Window Defroster Contact/Tab Repair Information
  • Interior - Passenger Air Bag Is Not Flush With Dash
  • Interior - Front Seat Cushion Cover Becomes Detached
  • Exhaust - Muffler Heat Shield Buzz During Operation
  • Electrical - MIL ON/DTC's Set By Various Control Modules
  • OnStar(R) - Number Incorrect/Incorrectly Assigned
  • Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
  • Engine - Oil Leaks From Rear Cover
  • Wheels/Tires - Module Programming For 20/22 Inch Wheels
  • Electrical - Intermittent MIL/DTC P2138/Reduced Power
  • Audio - Buzz Noise When Using Bluetooth(R)
  • Keyless Entry - Intermittent/Inoperative Remote
  • Body - Side Door Body Mounted Weatherstrip Replacement
  • Body - Front/Rear Fender Liners Warped/Wavy
  • Body - Tapping/Clicking/Ticking Noise at Windshield Area
  • Engine - Oil Consumption on Aluminum/Iron Block Engines
  • Steering - Fluid Leak at Hose Connection to Rack
  • OnStar(R) - Gen 9 Module Inop, Bluetooth Inop, Battery Discharg
• Recommended Repairs
  • A/C - Musty Odors Emitted From (HVAC) System
• Superceded Bulletins
  • 10-00-89-010A - 10/19/12
  • 12-06-01-008 - 09/01/12
  • 04-06-01-029F - 09/01/12
  • PIP5014 - 07/22/2012
  • 05-06-04-022H - 07/18/12
  • 04-06-04-047J - 07/18/12
  • 00-03-10-006G - 07/17/12
  • 03-03-10-007F - 07/12/12
  • 12-04-21-001 - 04/27/12
  • 07-02-32-002K - 01/01/12
  • 10426C - 01/01/2011
  • 10426A - 01/01/11
  • 10426 - 12/30/10
  • 09-08-64-012B - 11/01/2010
  • 01-08-51-003A - 11/01/2010
  • 01-08-51-003 - 01/01/2010
  • 08-07-30-035A - 01/01/2010
  • 02-03-10-001D - 01/01/10
  • 05-06-04-022F - 10/01/10
  • Glass/Body - Windshield Wiper Performance
  • Lighting - Headlamp Polycarbonate Lens Damage Prevention
  • Lighting - Lamp Polycarbonate Lens Damage Prevention
  • Instruments - IPC Odometer Programming Method
  • Instruments - IPC Odometer Programming Reference Guide
  • Instruments - IPC Odometer Programming Reference Guide
  • Body - Paint-Less Dent Repair Recommendations
  • Body - Application of Anti-Corrosion Materials
  • Body - Metal Body Panel Corrosion Protection
  • Body - Hem Flange Sealer For Corrosion Protection
  • Interior - Third Row Seat Won't Release From Floor
  • Interior - Third Row Seat Hard To Remove And Install
  • Interior - Third Row Seat Hard To Remove And Install
  • Interior - Front Seat Cushion Cover Becomes Detached
  • Interior - Front Seat Cushion Cover Becomes Detached
  • Body - LH/RH Outside Rearview Mirror Glass Shake/Flutter
  • Body - Roof Panel Flutters/Rattle Noise When Doors Close
  • Interior - Cleaning Interior Surfaces of Vehicle
  • Interior - Cleaning Interior Surfaces of Vehicle
  • Interior - Cleaning Interior Surfaces of Vehicle
  • Body - Tapping/Clicking/Ticking Noise at Windshield Area
  • Body - Tapping/Clicking/Ticking Noise at Windshield Area
  • Keyless Entry - Intermittent/Inoperative Remote
  • Navigation - Report Missing/Inaccurate Nav. Map Info
  • Audio System - USB/Multimedia Interface Information
  • Restraints - Seat Belt Warning Lamp On/Buckling Issues
  • Restraint System - Normal Safety Belt Locking Conditions
  • Restraints - Driver/Passenger Seat Head Rest Information
  • Restraints - Passenger Presence System Information
  • Restraint System - Repeat DTC's/Air Bag Warning Lamp On
  • Interior - Passenger Air Bag Is Not Flush With Dash
  • A/C - Broken Rear Window Defogger Grid Detection
  • Interior - Elimination Of Unwanted Odors
  • A/C - Excessive Cabin Moisture/Reduced Window Clearing
  • A/C - Excessive Cabin Moisture/Reduced Window Clearing
  • Suspension - Multiple Noises From Front Of Vehicle
  • Suspension - Shock Absorber/Strut Fluid Leak Information
  • Recall - Intermediate Steering Shaft Separation
  • Steering/Suspension - Diagnosing Power Steering Concerns
  • Restraint System - Air Bag Warning Lamp On Repeat DTC's
  • Restraint System - Air Bag Warning Lamp On Repeat DTC's
  • Lighting - Low Beam Headlamp(s) Inoperative
  • Lighting - Low Beam Headlamp(s) Inoperative
  • Electrical - Information For Electrical Ground Repair
  • Electrical - Information For Electrical Ground Repair
  • Navigation - Gen 9 OnStar(R) Modules Inop/ Battery Drain
  • Accessories - Aftermarket Trailer Brake Controller
  • Accessories - Aftermarket Trailer Brake Controller
  • Drivetrain - Clunk Noise Shifting From PARK Into Gear
  • Manual Transmission - M/T Operating Characteristics
  • Campaign - Rear Axle Grinding Noise/Vibration
  • 10426B - 01/03/11
  • Recall - Rear Axle Cross Pin Fracture
  • Recall - Rear Axle Cross Pin Fracture
  • A/T - Fluid Oil Cooler Flush
  • Engine Controls - Aftermarket Accessory Usage
  • Engine Controls - Aftermarket Interface Devices Cause Issues
  • Engine Controls - Identifying Non-GM ECM/TCM Calibrations
  • Engine Controls - Identifying Non-GM ECM/TCM Calibrations
  • Engine Controls - MIL ON/Reduced Engine Power/DTC P2135
  • Engine Controls - MIL ON/Reduced Engine Power/DTC P2135
  • Engine Controls - Aftermarket Accessory Usage
  • Engine Controls - Aftermarket Accessory Usage
  • Exhaust - Muffler Heat Shield Buzz During Operation
  • Exhaust System - Exhaust Leak/Rattle/Rumble/Noises
  • Exhaust System - Exhaust Leak/Rattle/Rumble/Noises
  • Engine/Transmission - Aftermarket Calibrations for V8 Engines
  • Engine/Transmission - Aftermarket Calibrations
  • Vehicle - Engine Crankcase and Subsystems Flushing Info.
  • Engine - Oil Leak At Oil Cooler Hose/Pipe Assembly
  • Engine - Aluminum Block/Iron Block Engine Oil Consumption
  • Engine - Engine Oil Consumption On Higher Mileage Vehicles
  • Engine - Engine Oil Consumption On Higher Mileage Vehicles
  • Engine - New Service Cam Bearings For Gen IV V8 Engines
  • Wheels/Tires - Use of Nitrogen Gas in Tires
  • Steering/Suspension - Power Steering Fluid Leaking
  • 07-02-32-002I - 01/01/2010
  • Wheels/Tires - Tire Radial Force Variation (RFV)
  • Engine - Valve Lifter Tick Noise At Start Up
  • Engine - Valve Lifter Tick Noise At Start Up
  • Engine - GM Dexos 1(R) and Dexos 2(R) Oil Specifications
  • Tires/Wheels - Tire Slowly Goes Flat/Warning Light ON
  • Ignition System - MIL On,Engine Running Rough/DTC P0300
  • Steering/Suspension - Power Steering Leaking Fluid
  • Steering - Leak at Hose Connection to Steering Rack
  • Ignition/Engine - MIL ON, Engine Running Rough/DTC P0300
  • Engine - Oil Consumption On Engines With Aluminum Blocks
  • Tires/Wheels - Information on Tire Radial Force Variation (RFV)
  • Electrical - Accessory Power Outlet Fuse Replacement
• All Technical Service Bulletins
  • Wheels/Tires - Proper Wheel Installation/Wheel Torque Technique
  • Electrical - Aftermarket Devices May Interfere With OnStar(R)
  • Interior - Eliminating Unwanted Odors in Vehicles
  • Engine Controls - MIL ON, DTC P2135, Reduced Engine Power
  • Locks - Key Code Security Rules, Key Code Look Up
  • Engine Controls - MIL ON/DTC P2135 Set
  • Vehicle - Engine And Sub Systems Flushing Info. (CANADA)
  • Vehicle - Engine And Sub-Systems Flushing Recommendations
  • Wheels/Tires - Use Of Nitrogen Gas In Tires
  • Instruments - IPC Odometer Programming Method
  • Tires - Information On Proper Tire Pressure
  • 06-08-50-006H - BULLETIN NOTIFICATION CANCELATION
  • Suspension/Steering - Pop,Click,Or Clunk Noise At Low Speeds
  • Body - LH/RH Outside Rearview Mirror Glass Shake/Flutter
  • Engine - THIS BULLETIN HAS BEEN CANCELED
  • A/T - Normal Maintenance or Warranty on 4T40, 4T45, 4T65, 4L60
  • Fuel System - TOP TIER Detergent Gasoline Information (Canada)
  • Fuel System - TOP TIER Detergent Gasoline
  • Tires/Wheels - OE Tire Shake/Vibration Information
  • Body - Rear Door Handle, Latch, Lock Inoperative, Won't Open
  • Audio System - USB/Multimedia Interface Information
  • Interior - Third Row Seat Won't Release From Floor
    • Overview
    • Condition/Cause/Correction # 1
    • Condition/Cause/Correction # 2
    • Condition/Cause/Correction # 3
    • Condition/Cause/Correction # 4
    • Condition/Cause/Correction # 5
    • Condition/Cause/Correction # 6
  • Engine/Engine Controls - MIL ON, Engine Running Rough/DTC P0300
  • Suspension - Shock Absorber/Strut Fluid Leak Information
  • M/T - Operating Characteristics Information
  • Brakes - Resurfacing Park Brake Portion of Rear Brake Rotor
  • Door Locks - Loss of Power Door Lock Function
  • Tires - Slight/Mild Edge Feathering Information
  • Body - Hem Flange Sealer For Corrosion Protection
  • Engine - Intake Manifold Inspection/Replacement
  • Body - Metal Body Panel Corrosion Protection
  • Fuel System - GM Fuel System Treatment PLUS(R) Info.
  • Body - Broken Rear Window Defogger Grid Detection
  • Fuel System - Fuel Injector Maintenance Cleaning
  • Engine - Valve Lifter Tick Noise At Start Up
  • Audio - Inadvertent Steering Wheel Button Activation
  • Audio System - Noise When Using Portable Playback Unit
  • Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
  • Instruments - Hourmeter Reading Not Transferred To IPC
  • Steering - Power Steering Leaking Fluid
  • A/T - Fluid Oil Cooler Flow Test
  • OnStar(R) - Language Change Information (U.S. and Canada Only)
  • Restraint System - Repeat DTC's/Air Bag Warning Lamp On
  • Power Steering - Fluid Leaks Due to Extreme Low Temps
  • Interior - 2nd Row Seat Rattles/Hard To Latch/Unlatch
  • Audio - Personal Audio Link (PAL) Charging of iPod
  • Restraints - Passenger Presence System Information
  • Lighting - Lamp Polycarbonate Lens Damage Prevention
  • Lighting - Low Beam Headlamp(s) Inoperative
  • Accessories - Aftermarket Trailer Brake Controller
  • Restraints - Seat Belt Latching Issues/Warning Lights
  • Exhaust System - Exhaust Leak/Rattle/Rumble/Noise
  • Restraints - Air Bag Lamp ON/Multiple DTCs
  • A/T Controls - Snapshot Data With Tech2(R) Information
  • Body - Side Window Chipping Information
  • Restraints - Driver/Passenger Seat Head Rest Information
  • Tires/Wheels - Tire Slowly Goes Flat/Warning Light ON
  • Restraint System - Normal Safety Belt Locking Conditions
  • Engine - Use of 'Surface Conditioning Disks'
  • Navigation - Report Missing/Inaccurate Nav. Map Info
  • A/T - Shift Stabilization/Tow Haul Mode Features
  • Engine - Sound Change In 3 or 4 Cylinder Mode
  • Body - Application of Anti-Corrosion Materials
  • A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
  • Engine - Oil Leak At Oil Cooler Hose/Pipe Assembly
  • Body Controls - Body Control Module (BCM) Grounds
  • A/C - Musty Odors Emitted From (HVAC) System
  • Body/Glass - Windshield Wiper Chatter/Noise/Streaking
  • Interior - Removal and Installation Of Roof Console
  • Recall - Intermediate Steering Shaft Separation
    • Overview
    • Owner Letter
  • A/C - Excessive Cabin Moisture/Reduced Window Clearing
  • Recall 11V339000: Steering Shaft Separation
  • Engine - MIL ON P0116/P1400 Set In Very Cold Temps
  • Suspension - Multiple Noises From Front Of Vehicle
  • Navigation Radio - Problems After Radio/Battery Service
  • Electrical - Electrical Malfunction/Multiple DTCs
    • Overview
    • Correction
      • Part 1
      • Part 2
      • Part 3
      • Part 4
  • Interior, A/C - Air Vent Deflector Knob Missing/Loose
  • A/T - Slight Vehicle Movement In Park At Start Up
  • Air Conditioning - A/C Blows Warm Air Intermittently
  • Body - Chrome Outside Door Handle Loose/Cracked
  • Interior - Sun Visor Fails to Stay In Up Position
  • Recall - Rear Axle Cross Pin Fracture
    • Overview
    • Owner Letter
  • Tire Pressure Monitor - TPM System Message/Service Tips
  • Body - Colored Side Mouldings Dull/Discolored/Stained
  • Body - Sticking/Binding Door Mounted Seat Switches
  • Electrical - Installation Of Aftermarket Accessories
  • Body - Front Door Window Regulator Squeak Noise
  • Tires/Wheels - Rattle Noise from Wheel Or Hub Cap
  • Body/Frame - Underbody Pop/Clunk When Turning
  • A/C - Window Defroster Contact/Tab Repair Information
  • Interior - Passenger Air Bag Is Not Flush With Dash
  • Interior - Front Seat Cushion Cover Becomes Detached
  • Engine, A/T - Identification Information
  • Exhaust - Muffler Heat Shield Buzz During Operation
  • Wheels/Tires - Refinishing Aluminum Wheels
  • Navigation Radio - Various Noises Explained
  • Lighting - Exterior Lamp Condensation and Replacement
  • Campaign - Water Leak in Passenger Compartment
  • Fuel - GM's Position On Use Of E 15, 2007 Newer Vehicles
  • Electrical - MIL ON/DTC's Set By Various Control Modules
  • OnStar(R) - Number Incorrect/Incorrectly Assigned
  • Steering/Suspension - Wheel Alignment Specifications
  • Vehicle - 2011 Model Year VIN Code changes
  • Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
  • Tires/Wheels - Tire Puncture Repair Procedures
  • Interior - Proper Use of Floor Mats
  • Tire Pressure Monitor - TPM System Overview
    • Overview
    • TMP Frequently Asked Questions (FAQs)
  • Engine - Oil Leaks From Rear Cover
  • TPMS System - Service And Re-Learning Sensor IDs
  • Body - Squeeze Type Resistance Spot Welding/Equipment
  • Wheels/Tires - Module Programming For 20/22 Inch Wheels
  • Battery - Battery Cable Bolts/Clamps/Nuts Inspection
  • Body - Initialization Of The Articulating Running Boards
  • Electrical - Intermittent MIL/DTC P2138/Reduced Power
  • Instruments - Outside Mirror Adjustment Information
  • Restraints - Extender Availability For Seat Belt
  • Brakes - Aftermarket Trailer Brake Controllers
  • Steering/Suspension - Pitman Arm Shaft Seal Service Kit
  • Interior - Seat Cover Wrinkle/Crease/Burn Info
  • Tire/Wheel - Spare Tire Is Non-Matching To Other Tires
  • A/T - Water Or Coolant Contamination Information
  • Audio - Buzz Noise When Using Bluetooth(R)
  • Body - Drilling High Strength Steel Using CryoCobalt(R)
  • Body - Vehicle Glass Distortion Information
  • Fuel System - TOP TIER Detergent Gasoline (Canada)
  • Keyless Entry - Intermittent/Inoperative Remote
  • Body - Side Door Body Mounted Weatherstrip Replacement
  • Body - Front/Rear Fender Liners Warped/Wavy
  • Tires/Wheels - Information on Tire Radial Force Variation (RFV)
  • Body - Tapping/Clicking/Ticking Noise at Windshield Area
  • Engine - GM Dexos 1(R) And 2(R) Oil Specifications
  • Engine - GM dexos 1(R) and dexos 2(R) Oil Specifications/Info.
  • Wheels/Tires - Vibration Issue Diagnostic Tips
  • Body - Pre-Painting/Cleaning Process For TPO Plastic Fascias
  • Drivetrain - Information on Driveline Clunk Noise
  • Engine - Oil Consumption on Aluminum/Iron Block Engines
  • Steering - Fluid Leak at Hose Connection to Rack
  • Engine - New Service Cam Bearings
  • Wheels - Chromed Aluminum Wheel Staining/Pitting/Corrosion
  • Engine Controls - Non-GM Engine/Transmission Calibration ID
    • Overview
    • Table of Contents
    • Sections
      • Section 1
      • Section 2
      • Section 3
      • Section 4
      • Section 5
      • Section 6
      • Section 7
      • Section 8
      • Section 9
      • Section 10
      • Section 11
      • Section 12 - Waranty Information
  • Navigation System - DVD Navigation Update Program
  • OnStar(R) - Gen 9 Module Inop, Bluetooth Inop, Battery Discharg
  • Body - Paint-less Dent Repair Process
  • Electrical - Power Outlet and Trailer Lighting Fuse Replacement
  • Electrical - Aftermarket Interface Devices Causing Issues
  • Wipers/Washers - Windshield Wiper Performance Information
  • Electrical - Ground Repair Information
  • Interior - Cleaning Instrument Panel, Interior Trim