Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall - Combination Light Switch/Headlamp Wiring Repair
- Recall - Headlamp Low Beams Are Inoperative
- Recall - Driver's Air Bag Over-Pressurization
- Recall - Replacement Driver Air Bag Over-Pressurization
- Recall 11V260000: Potential Replacement Air Bag Defect
- Recall 01V329000: Air Cleaner Box Inspection/Replacement
- Recall 04V086000: Headlamp Switch/Connector Defect
- Recall 10V041000: Air Bag Inflator Replacement
- Recall 13V132000: Passenger Air Bag Defect
- Customer Interest
- A/T, Engine Controls - MIL ON/No Movement In Drive/P0730
- Engine Controls - MIL ON/DTC P0128 Is Stored In Memory
- Body/Suspension - Creaking/Ticking Noises
- Suspension - Rear Suspension Squeaking Noises
- Body - Front Bumper Spoiler Loose/Detached
- M/T - Clutch Pedal Squeak/Twang or Notchy Feel
- Engine Controls - MIL ON with 'Unknown' DTC Set
- Engine Controls - Occasional Stalling When Stopping
- Fuel System - Air Cleaner Case Cracked
- Antitheft System - Alarm Will Not Arm/Arms By Itself
- Interior - Seat Belts Slow to Retract
- Body - Water Leaking Into Trunk
- Electrical - DTC P1298 Stored in ECM/PCM
- Body - Trunk Lid Hard to Close
- Body - Trunk Release Handle Inoperative
- Interior - A-Pillar Trim Rattles
- Interior - Right Hand Dashboard Creaking Noise
- M/T - Clicking Noise Driving in 2nd Gear
- M/T - Shift Lever Difficult to Move/Hard Shifting
- Body - Moonroof Seal Squeaks
- Emissions - MIL ON With DTC P1457 (EVAP) Set
- Restraint System - SRS Indicator ON/DTC's Set
- Restraint System - 'SIDE AIRBAG OFF' Indicator is ON
- Restraints - Child Seat Anchor Locating Button Missing
- Emissions - MIL ON/DTC P1457 Set
- Body - Windshield Moulding Warped/Deformed
- Steering/Suspension - Vehicle Pulls Left/Right
- Factory Modifications
- Recommended Repairs
- Superceded Bulletins
- 04-036 - 07/26/11
- 03-002 - 01/21/03
- 90-011 - 05/02/09
- 89-022 - 06/18/04
- Campaign - Extension of The Vehicle Warranty
- 99-018 - 04/20/06
- Campaign - Vehicle Warranty Extension
- 02-025 - 11/12/2002
- 98-019 - 05/13/05
- 06-001 - 01/16/06
- 98-011 - 02/05/02
- 04-036 - 09/24/04
- 03-010 - 02/04/03
- 03-009 - 02/04/03
- 02-083 - 12/23/02
- 02-061 - 10/29/02
- 02-054 - 09/10/02
- 02-045 - 08/13/02
- 02-034 - 07/16/02
- 02-026 - 04/16/02
- 01-023 - 09/01/02
- 00-088 - 04/03/01
- 00-088 - 08/14/02
- 12-056 - 08/31/12
- Campaign - Warranty Extension For Odometer Inaccuracy
- Body - Recommended Repair Materials
- Body - Recommended Sealers And Adhesives
- Body - Recommended Sealers/Repair materials
- Body - Front Spoiler Loose/Detached
- Body - Deformed Windshield Moulding
- Body - Deformed Windshield Molding
- Body - Windshield Molding is Deformed
- Body - Windshield Moulding is Deformed or Warped
- Body - Water Leaks Into Trunk
- Body - Trunk Lid Difficult to Close
- Body - Trunk Lid is Hard to Close
- Body - Trunk Lid is Difficult to Close
- Audio/Navigation/RES - Warr. Exchange/Non-Warr. Repair
- Audio/Navigation/RES Unit - Warranty Exchange/Repair
- Audio/Entertainment/Navigation - Service/Warranty Info.
- Audio/Navigation/RES - Warr. Exchange/Non-Warr Repair
- Audio/Entertainment/Navigation - Service/Exchange
- 12-070 - 03/21/13
- Antitheft System - Immobilizer System (Type 3)
- Antitheft System - Type 3 System Operation/Programming
- Keyless Entry - Remote Transmitter Information
- Antitheft System - Won't Arm or Arms By Itself
- Audio/Navigation/RES/iMID(R) - Warr Exchange/Non Warr Repair
- Restraints - Occupant Detection Initialization
- Campaign - OPDS Unit/Sensor Warranty Extension
- SRS - Indicator Lamp ON/Multiple DTC's Set
- Restraint System - 'SIDE AIRBAG OFF' Indicator ON
- Restraint System - Occupant Detection Initialization
- Campaign - OPDS Unit Warranty Extension
- Campaign - OPDS Sensor/Unit Warranty Extension
- Restraints - Passenger Air Bag Replacement
- Recall - Driver's Air Bag Over-Pressurization
- 10-039 - 12/08/11
- 08-093 - 12/08/11
- Recall -Driver Air Bag Inflator Can Be Over-Pressurized
- 10-039 - 05/17/11
- Recall - Driver's Air Bag Replacement
- Recall - Driver's Air Bag Inflator Defects
- Recall - Driver's Side Air Bag Inflator Defect
- 08-093 - 08/12/09
- 07-030 - 06/15/07
- Front Subframe - Removal Adapter
- Suspension - Squeak From Rear Suspension
- Suspension - Rear Suspension Squeaking Noise
- Recall - Combination Light Switch Replacement
- Electrical - GR8 Battery Diagnostic Station Update Info.
- Electrical - GR8 Battery Diagnostic Station Update
- Electrical - Battery Testing And Replacement
- Electrical - GR8(R) Battery Diagnostic Station Update
- Electrical - ED-18 Battery Analyzer Update Information
- Electrical - Battery Testing and Replacement
- Electrical - Battery Test Procedure/Equipment
- Battery - Testing Procedures
- Battery - Testing Procedure
- Disc Brake System - Brake Disc Refinishing Guidelines
- Brakes - Brake Disc Refinishing Guideline
- Brakes - Brake Disc Refinishing Guidelines
- Brake Discs - Refinishing Guidelines
- M/T - Clicking Noise While Driving in 2nd Gear
- M/T - Clutch Pedal Squeak Upon Application
- M/T - Squeak/Twang At Clutch Pedal
- M/T - Clutch Pedal Noise/Notchy Feel
- Computers/Controls - Updating Control Units/Modules
- Computers/Controls - Module/Control Unit Updating
- Engine Controls - Updating ECM/PCM Software
- A/T - Vehicle Won't Move/MIL ON/DTC P0730
- Computers/Controls - HIM Module Updating
- Engine Controls - Control Module Programming Procedure
- Restraint System - SRS Indicator ON/Multiple DTC's Set
- Engine Controls/Emissions - OBD II DTC's and Monitors
- Engine Controls - DTC P1298 Stored in Memory
- Engine Controls - MIL ON/DTC P0128 Stored
- Computers/Controls - Updating Modules/Control Units
- Computers/Controls - Updating Control Units And Modules
- Computers/Controls - Control Unit/Module Reprogramming
- Computers/Controls - Updating Modules/Control Units
- Engine Controls - Control Module Programming Procedure
- Vehicle - Recommended Materials
- Vehicle - Recommended Service Materials
- Steering/Suspension - Vehicle Pulls Right/Left
- Steering/Suspension - Vehicle Pulls/Drifts To One Side
- Steering/Suspension - Vehicle Pull/Drift To One Side
- Steering - Vehicle Pulls/Drifts to the Left/Right
- All Technical Service Bulletins
- A/T - New ATF DW-1 Available
- Recall - Combination Light Switch/Headlamp Wiring Repair
- Recall - Headlamp Low Beams Are Inoperative
- Campaign - OPDS Unit Warranty Extension
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Lighting - Headlamp Switch Inspection BULLETIN CANCELLED
- Recall - Driver's Air Bag Over-Pressurization
- Recall - Replacement Driver Air Bag Over-Pressurization
- A/T, Engine Controls - MIL ON/No Movement In Drive/P0730
- Engine Controls - MIL ON/DTC P0128 Is Stored In Memory
- Keyless Entry - Keyless Remote Transmitter Information
- Recall 11V260000: Potential Replacement Air Bag Defect
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- Brakes - Front Squeal, Moan or Grind
- ABS DTC 51 Or 53 - Diagnostic Tip
- ABS - Grunts When Doing A Self-Check
- Gauges - Eratic Gauges Or Odd Odometer Display
- Maintenance Required Indicator Doesn't Reset
- Fuel Gauge and Low Fuel Indicator Accuracy Check
- A/C - System Performance Testing
- A/C - Poor Cooling During Hard Acceleration
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Power Steering Whines or Whistles
- Engine Cranking Or Starting Problems After Fill-up
- Engine Won't Start - Check Alternator Bolts
- Engine Controls - PCM Software Can Cause DTC P0128/P1486
- Gas Tank - Fuel Pump/Sending Unit Installation Tip
- A/C - New Grease for Compressor Thermal Protector
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- Body/Suspension - Creaking/Ticking Noises
- Suspension - Rear Suspension Squeaking Noises
- Suspension - Lower Ball Joint Replacement
- Body - Front Bumper Spoiler Loose/Detached
- A/T - Leak From Cooler Line Banjo Bolt
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- A/T - Do Not Remove Torque Converter From Mainshaft
- M/T - Clutch Pedal Squeak/Twang or Notchy Feel
- Engine Controls - Replace ECM/PCM For DTC P1607
- Drivetrain - Revised CV Joint Boot Band/Installation
- Engine Controls - MIL ON with 'Unknown' DTC Set
- Engine Controls - Occasional Stalling When Stopping
- Recall 01V329000: Air Cleaner Box Inspection/Replacement
- Fuel System - Air Cleaner Case Cracked
- Catalytic Converter - Rotten Egg Smell
- Exhaust System - Catalytic Converter Noise
- Key Beeper, Light Chime and Ceiling Light Don't Work
- Antitheft System - Alarm Will Not Arm/Arms By Itself
- Interior - Seat Belts Slow to Retract
- Driver's Air Bag - Replace Torx Bolts Properly
- Recall 04V086000: Headlamp Switch/Connector Defect
- Engine - Crankshaft Pulley Service Manual Revision
- Suspension - Drifting and Pulling At Highway Speeds
- Body - Water Leaking Into Trunk
- Interior - Center Lower Cover Removal, Manual Revision
- Interior and Exterior Trim - Tool To Make Removal A Snap
- Dashboard Center Lower Cover Sticks Out
- Air Fresheners - Bad News For Paint Or Plastic
- Nose Mask Installation Tips
- Water Leak From Door. Check Rain Protector
- Wind Noise - Simple Way To Replicate
- Audio Unit - Electronically Retrieving Serial Numbers
- Audio Unit - Models Which Are Electronically Retrieval
- DTC P1456 - Evap System Diagnostic Aid
- Fuel Filler Cap Adapter Available For Testing Emissions
- Clearing DTCs and Setting ECM/PCM With The HDS
- Electrical - DTC P1298 Stored in ECM/PCM
- Engine Controls - DTC P0171 Set
- Engine Controls - DTC P0172
- Engine Controls - Clearing DTC's
- Body - Trunk Lid Hard to Close
- Windshield Washer Nozzle Troubleshooting
- Windshield Wipers - Blade Care and Replacement
- Engine - Oil Recommendation GF-4 Standard
- Brake Pedal - Click Or Pop When Depressed
- A/T - In-Warranty Exchange Program
- A/T - Don't Test Drive With The MIL Or D Indicator On
- M/T Mainshaft Reassembly Manual Revision
- M/T - Grinds Shifting To 3rd Gear
- SRS - Indicator ON with No SRS DTC Set
- M/T - Hard To Shift Into 1st Gear, Grinds Into Reverse
- Power Windows Slow - Check Run Channel Friction
- Body - Trunk Release Handle Inoperative
- Interior - A-Pillar Trim Rattles
- Audio System - Never Play CD's With Adhesive Labels
- Paint - 2002 Paint Codes
- Body/Frame - Universal Subframe Removal Adapter
- Interior - Right Hand Dashboard Creaking Noise
- Ignition Keys Gets Warm While Driving
- M/T - Clicking Noise Driving in 2nd Gear
- M/T - Shift Lever Difficult to Move/Hard Shifting
- Body - Moonroof Seal Squeaks
- Emissions - MIL ON With DTC P1457 (EVAP) Set
- Restraint System - SRS Indicator ON/DTC's Set
- Restraint System - 'SIDE AIRBAG OFF' Indicator is ON
- Restraints - Child Seat Anchor Locating Button Missing
- Body - Plastic Body Clip Removal Tips
- Tires - Tubless Tire Repair Information
- Emissions - EVAP Testing Using The PGM Tester
- Paint - Industrial Fallout Paint Damage
- Body - Unibody Repair Guidelines
- Music Link(R) - System Information/Diagnostics
- A/C - Refrigerant Leak Detection
- Emissions - MIL ON/DTC P1457 Set
- Campaign - Vehicle Warranty Mileage Extension
- Body - Windshield Moulding Warped/Deformed
- Steering/Suspension - Vehicle Pulls Left/Right
- Electrical - Battery Testing and Replacement Information
- A/C - Heater Blows Cool Air At Idle
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- A/T - ATF Cooler Cleaner Information
- Emissions - OBD II DTC's And Associated Monitors
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Recall 10V041000: Air Bag Inflator Replacement
- Starting System - Unable To Key In Ignition Switch
- Computers/Controls - Initialization Procedure Info.
- Fuel System - FTP Sensor Diagnostics/DTC P0497
- Engine Controls - Test Drive Precautions
- Audio System - CD/DVD Precautions
- Interior - Fabric Upholstery Wrinkle Information
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- A/T - Cooler Flushing Equipment Information
- Electrical - GR8 Battery Diagnostic Station Update Information
- Restraints - Pass. Air Bag Replacement BULLETIN CANCELLATION
- Recall 13V132000: Passenger Air Bag Defect
- Antitheft - Immobilizer System (Type 3) Information
- Overview
- Immobilizer System Components
- ECM/PCM
- Adding Programmed Ignition Keys
- Replacing All Programmed Ignition Keys
- Clearing Transponder Codes of Lost Programmed Ignition Keys
- Starting The Engine Without A Programmed Ignition Key
- Replacing The Immobilizer Control Unit Receiver
- Replacing the ECM/PCM
- Customer Situation and Required Items Chart
- Computers/Controls - Updating Control Units/Modules
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair
- Cell Phone - Programmable HFL (HFT) Unit Update Info.