Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall R1110 - Left Front Strut Housing (NON - SALT STATES)
- Overview
- Table of Contents
- Repair Overview
- Service Procedure
- Steering Shaft Replacement
- Example Photos Perforation and Scab Corrosion
- Required Special Tools
- Parts Information
- Claims Information
- Owner Letter
- Non Repairable Report/Morley Information
- Recall R1109 - Left Front Strut Housing (SALT STATES)
- Overview
- Table of Contents
- Repair Overview
- Required Special Tools
- Service Procedure
- Steering Shaft Replacement
- Example Photos (Perforation and Scab Corrosion)
- Parts Information
- Claims Information
- Owner Letter
- Non Repairable Report
- Recall R1102 - Front Strut Housing Corrosion Inspection
- Recall 11V221000: Front Strut Housing Corrosion
- Recall 00V410000: Ignition Lock/Steering Defect
- Recall - Rear Hatch Strut Bracket Replacement
- Recall 00V40000: Defective Ignition Lock Assembly
- Recall 07V435000: Fuel Filler Tube Replacement
- Recall R0707 and R0708 - Fuel Filler Tube Replacement
- Recall R1110 - Left Front Strut Housing (NON - SALT STATES)
- Customer Interest
- Steering/Suspension - Drift/Steering Wheel Off Center
- Paint - Paint Swells/Discolored Under Paint Guard Film
- Engine Vacuum System - MIL ON Condition
- Power Steering Pump - Leakage at Fitting
- Brakes - Front Brake Judder
- Shock Absorber (R/H rear) - Squeak/Creak Noise
- Steering Column - Rubbing/Wheezing Noise on Turns
- ECM/O2 Sensor - MIL ON/DTC's Set
- MIL ON - DTC P1441 Stored in Self Diagnosis
- Engine Controls - MIL ON/DTC's P0420/P0430
- A/T - 1st to 2nd Or 2nd to 3rd Gear Shift Flare
- Driver's Seat - Will Not Move Forward or Back
- Tachometer - Needle on Wrong Side of Stop Pin
- EVAP System - MIL ON/DTC P1491 Stored
- 4WD System - 4WD Warning Lamp ON Intermittently
- Seat Belt - Slow Retraction
- Cooling System - Leaks/Overheating
- Interior - Sunglass Holder Lid Won't Open/Close Properly
- Navigation System - Multiple Symptoms
- Navigation System - Multiple Malfunctions
- Drivetrain - Transfer Case Oil Leak
- Dashboard - Squeak/Rattle From Right Hand Side
- Hatch Latch (Rear) - Moves To Secondary Position
- Roof Console Temperature Display - Inaccurate
- Brakes - Judder/Noise/Pedal Feel Diagnostics/Repair
- A/C - Refrigerant Leaks At Connections
- Restraints - Seat Belts Retract Slowly
- Body - Removing Foreign Material From The Windshield
- Superceded Bulletins
- 00-031A - 10/19/10
- 04-021A - 06/01/06
- 04-021 - 06/01/04
- 99-043D - 06/01/08
- 99-043C - 01/01/08
- 99-037M - 06/01/08
- 99-037L - 01/01/08
- 08-024 - 07/01/08
- 03-051B - 06/01/08
- 99-043A - 12/01/05
- 00-005C - 05/01/07
- 00-005B - 04/01/07
- 03-051 - 01/01/07
- 99-037H - 03/01/06
- 99-037E - 09/12/04
- 99-037D - 09/01/04
- 03-061 - 10/21/03
- 02-007 - 03/11/02
- 01-056 - 09/21/01
- 01-051 - 09/04/01
- 01-013 - 03/21/01
- 00-058 - 12/05/00
- 00-045 - 08/30/00
- 00-038B - 04/01/04
- 00-038 - 08/30/00
- 03-051C - 07/21/08
- Lighting - Exterior Lamp Fogging Inspection
- Lighting - Exterior Lamps Fogging Information
- Lighting - Exterior Lamp Fogging Information
- Paint - Discoloration/Swelling Under Paint Guard Film
- Paint - Swelling/Discoloration Under Paint Guard Film
- Audio - CD and DVD Player Concerns
- Audio - CD and DVD Player Concerns
- Security System - (IVIS/NATS) Key Registration
- Restraints - Seat Belts Slow to Retract
- 08-024A - 07/21/08
- Side Airbags - Modification/Tampering Warnings
- Suspension - Rear Suspension Bottoms Out
- Recall R1109 - L/H Front Strut Housing (SALT STATES)
- Recall - L/H Front Strut Housing Corrosion (Non-Salt)
- Recall - L/H Front Strut Housing Corrosion (Salt States)
- Recall R1109 - L/H Front Strut Housing (Salt States)
- Recall R1110 - L/H Front Strut Housing (Non Salt States)
- 11-041 - 08/11/11
- Recall R1110 - L/H Front Strut Housing NON - SALT STATES
- Recall R1109 - L/H Front Strut Housing Corrosion
- Recall R1102 - Front Strut Housing Corrosion
- Starting/Charging System - Test Procedures/Tester
- Electrical - Battery/Starting/Charging System - Testing
- Electrical - Battery Testing Equipment/Procedures
- Electrical - Battery Testing Procedures and Equipment
- Battery - Testing Procedures/Testing Tool
- Battery - Replacement and Testing
- Battery - Replacement/Testing Procedures
- Brakes - Noise/Judder/Pedal Feel Diagnosis/Repair
- Brakes - Judder/Noise/Pedal Feel Diagnosis/Repair
- Brakes - Judder/Pedal Feel Diagnosis and Repair
- Brakes - Judder/Noise/Abnormal Pedal Feel
- Brakes - Judder/Noise/Pedal Feel Diagnosis and Repair
- Vehicle - Flat Towing Guidelines
- Vehicle - Flat Towing Guidelines/Limitations
- A/T - 1st to 2nd Gear Shift Flare on Hard Acceleration
- Emissions - OBD System Readiness Test Drive Patterns
- Emissions - EVAP System Leak DTC Diagnosis
- Emissions - DTC P0440/P0442/P0455/P0456/P1440/P1456
- Engine Controls - MIL ON/DTC P0240/P0430 Set
- 11-049 - 08/02/11
- ECM - Reprogramming Procedure
- ECM - Replacement Procedures/Programmable ECM
- Engine/Transmission - Replacement Precautions
- Engine - MIL ON/Variable Valve Timing DTC's Set
- Steering/Suspension - Vehicle Pull/Drift Diagnostics
- Tires - Inflation Pressure Information
- Steering/Suspension - Vehicle Pulls/Drifts Left/Right
- Tires - Tire Pressure Information
- Steering/Suspension - Vehicle Pulls Or Drifts
- Vehicle - VIN Plate/Certification Label Replacement
- Steering/Suspension Wheel Alignment Information
- Steering/Suspension - Wheel Alignment Info.
- Steering/Tires - Pull/Drift/Steering Wheel Off-Center
- Wheels/Tires - Wheel Balancing Using Hunter GSP9700(R)
- 11-039 - 07/14/11
- Steering/Suspension Drift/Steering Wheel Off Center
- Vehicle - Flat Towing Guidelines/Precautions
- All Technical Service Bulletins
- Emissions - System Readiness Test (SRT) Drive Patterns
- Computers/Controls - CONSULT III PLUS(R) Saved Data List
- Body Controls - Configurable BCM Replacement Information
- Wheels/Tires - Wheel/Tire Balancing Information
- Recall R1110 - Left Front Strut Housing (NON - SALT STATES)
- Overview
- Table of Contents
- Repair Overview
- Service Procedure
- Steering Shaft Replacement
- Example Photos Perforation and Scab Corrosion
- Required Special Tools
- Parts Information
- Claims Information
- Owner Letter
- Non Repairable Report/Morley Information
- Recall R1109 - Left Front Strut Housing (SALT STATES)
- Overview
- Table of Contents
- Repair Overview
- Required Special Tools
- Service Procedure
- Steering Shaft Replacement
- Example Photos (Perforation and Scab Corrosion)
- Parts Information
- Claims Information
- Owner Letter
- Non Repairable Report
- Vehicle - Vibration Diagnostic Worksheet
- Lighting - Exterior Lamp Fogging
- Steering/Suspension - Drift/Steering Wheel Off Center
- Keyless Systems/TPMS - SIGNAL TECH II(R) Diag. Tool
- Interior/Restraints - Front Seat Trim Material Info.
- Computers/Controls - Reprogramming Utilizing CONSULT(R)
- Vehicle - Certification Label/VIN Plate Replacement
- Recall R1102 - Front Strut Housing Corrosion Inspection
- Wheels Tires - Hunter GSP9700(R) Set Up Information
- Recall 11V221000: Front Strut Housing Corrosion
- Tires - Mounting Information/Precautions
- Paint - Paint Swells/Discolored Under Paint Guard Film
- Engine Vacuum System - MIL ON Condition
- Engine - Cold Weather Starting Procedures
- Engine/Transmission - Precautions During Replacement
- Engine Coolant - Refill Procedure and Tool
- Power Steering Pump - Leakage at Fitting
- Brakes - Front Brake Judder
- Steering - Pull Diagnosis, Repair
- Steering/Body - Vibration/Diagnosis and Repair
- Steering Rack - Essential Tools
- Shock Absorber (R/H rear) - Squeak/Creak Noise
- Body - Paint Staining Due to 'Tire Dressing'
- Body - Window Regulator/Motor Service
- Steering Column - Rubbing/Wheezing Noise on Turns
- Transfer Case - Clunk Noise Diagnostics
- CONSULT II - ECM Reprogramming Software
- Engine Controls - ECM Replacement Procedures
- ECM/O2 Sensor - MIL ON/DTC's Set
- Battery - Maintenance
- MIL ON - DTC P1441 Stored in Self Diagnosis
- Engine Controls - MIL ON/DTC's P0420/P0430
- A/T - 1st to 2nd Or 2nd to 3rd Gear Shift Flare
- TCM - Reprogramming Procedure
- Driver's Seat - Will Not Move Forward or Back
- Antitheft System - IVIS/NATS Key Registration Procedure
- Brakes - On-Car Brake Rotor Resurfacing
- Tachometer - Needle on Wrong Side of Stop Pin
- Headlight Connector - Replacement
- Recall 00V410000: Ignition Lock/Steering Defect
- EVAP System - Cleaning Procedure
- EVAP System - Vent Control Valve Diagnostics
- EVAP - Canister/Vent Control Valve, Application
- EVAP System - MIL ON/DTC P1491 Stored
- CONSULT II - Diagnostic Software Update
- Tools - New Consult-II Diagnostic Card
- 4WD System - 4WD Warning Lamp ON Intermittently
- Recall - Rear Hatch Strut Bracket Replacement
- Seat Belt - Slow Retraction
- Interior - Seat Belt Latch Plate Retaining Button Gone
- Cooling System - Leaks/Overheating
- Interior - Sunglass Holder Lid Won't Open/Close Properly
- Axle Bearing (Rear) - Removal Kit/Service Procedure
- Audio System - CD Care and Usage Guidelines
- Entertainment System - Introduction/Diagnosis
- Overview
- Mobile Entertainment System Function Test
- Mobile Entertaining System Diagnostic Flow Charts
- Removal and Replacement of the VCR/Checking the VCR
- Mobile Entertainment System Fuse Check Procedure
- Interface Box Power Cable/Harness Connections Check Procedure
- Over Head Monitor (Ohm) Harness Connection Check Procedure
- Navigation System - Multiple Symptoms
- Navigation System - Multiple Malfunctions
- Paint - Codes/Cross References/Applications
- Paint - Removal Of Enviornmental Iron Particles
- Interior - Rubber Floormat Installation Precaution
- Recall 00V40000: Defective Ignition Lock Assembly
- Tools - Remote Keyless Entry Tester
- Drivetrain - Transfer Case Oil Leak
- Dashboard - Squeak/Rattle From Right Hand Side
- Hatch Latch (Rear) - Moves To Secondary Position
- Roof Console Temperature Display - Inaccurate
- Maintenance - Revised Procedures
- Special Tool - Fuel Pressure Gauge Kit
- Entertainment System - Introduction/System Diagnostics
- Wheels - Chrome Wheel Handling When Mounting Tires
- M/T - Required Oil for Warranty Repairs
- Engine Controls - ECM Reprogramming Information
- Recall 07V435000: Fuel Filler Tube Replacement
- Brakes - Judder/Noise/Pedal Feel Diagnostics/Repair
- Recall R0707 and R0708 - Fuel Filler Tube Replacement
- Engine - MIL ON/Multiple DTC's Set
- Electrical - Battery/Starting/Charging System Testing
- Vehicle - Flat Towing Guideline
- Restraints - SRS Service Precaution
- Electrical - Electronic Component Damage Prevention
- Wheels/Tires - Accessory Wheel Lock Installation/Removal
- A/T, CVT - Terminology Update To SAE JJ1930 and J2012
- A/C - Refrigerant Leaks At Connections
- Engine Controls - CONSULT-III(R) ECM Programming
- Body - Windshield Cracking Information
- Engine - Reman Engine Start Up Lubrication Information
- Engine - Drive Belt Noise Diagnostics
- Engine Controls - Seized O2 Sensor Removal Procedure
- Restraints - Seat Belts Retract Slowly
- Emissions - EVAP Canister Vent Control Valve Replacement
- Electrical - JIS/CCA Battery Testing Information
- Electrical - Battery/Starting/Charging Sys. Testing
- Engine Controls - ECM Programming Interruption Recovery
- Steering/Suspension - Wheel Bearing Collision Damage
- Steering/Suspension - Wheel Alignment Information
- Suspension - Strut And Shock Absorber Replacement Guidelines
- Body - Removing Foreign Material From The Windshield
- Entertainment Systems - CD And DVD Player Concerns