Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 03V164000: Propeller Shaft Bolt Replacement
- Recall - Propeller Shaft Bolt Replacement
- Recall 03V476000: Front Caliper Mounting Bolt Torque
- Recall - Brake Caliper Bolt Torque
- Recall 05V555000: Fuel Filler Hose Replacement
- Recall - Fuel Filler Hose Replacement
- Recall 06V328000: Headlamp Replacement
- Recall R0607 - Rear Combination Lamp
- Recall R0608 - Headlamp Replacement
- Recall 13V136000: Passenger Front Air Bag Defect
- Customer Interest
- Body - Exterior Door Sash Moldings Discolored/Streaked
- Body - Front End Pop/Click/Creak Noises on Bumps
- Steering/Suspension - Drift/Steering Wheel Off Center
- Paint - Paint Swells/Discolored Under Paint Guard Film
- Brakes - Rear Brake Squeal/Squeak When Cold
- Brakes - Steering Wheel Shake/Pedal Pulsation
- Engine - Oil Leaks From Oil Cooler Oil Seal
- Body - Front Door Glass Ticking/Popping Noises
- Steering - Column Has 2-3 mm Up/Down Play
- Electrical - MIL ON/DTC's U1010 or U1000 Set
- Emissions/Engine Controls - MIL ON/DTC's P0442/P0456
- Interior - Driver's Seat Noisy/Rocks Back and Forth
- Navigation System - Screen Stuck in 'PLEASE WAIT' Mode
- Instruments - Fuel Gauge Won't Read Completely Full
- Body/Frame - Rear Floor Popping/Creaking Noise
- Alarm System - Incorrect Horn Chirp/Lamp Flash
- Engine Controls - Idle Speed 25 RPM Too High
- Interior - Front Door Finisher Pocket Hinge Broken
- Cooling System - Leaks/Overheating
- Keyless Entry - 'Intelligent Key'(R) Malfunctions
- Navigation System - Intermittently Inoperative
- Sunroof - Won't Open/Close Automatically
- Fuel System - Fuel Tank Difficult to Refuel
- Starting System - No Crank In Extreme Cold Conditions
- Fuel System - Ticking/Thumping Noise at Idle
- Instruments - Clock Won't Illuminate With Lights ON
- Brakes - Judder/Noise/Pedal Feel Diagnostics/Repair
- Instruments - Outside Door Mirror Inoperative
- A/C - Refrigerant Leaks At Connections
- Body - Wind Noise From The Sunroof Area
- Restraints - Seat Belts Retract Slowly
- Ignition System - Misfire DTC's/Ignition Coils Blistered
- Body - Removing Foreign Material From The Windshield
- Superceded Bulletins
- 00-031A - 10/19/10
- 11-003A - 05/01/11
- 04-021A - 06/01/06
- 04-021 - 06/01/04
- 99-043D - 06/01/08
- 99-043C - 01/01/08
- 99-037M - 06/01/08
- 99-037L - 01/01/08
- 08-024 - 07/01/08
- 03-051B - 06/01/08
- 99-043A - 12/01/05
- 00-005C - 05/01/07
- 00-005B - 04/01/07
- 03-051 - 01/01/07
- 02-063A - 11/21/03
- 99-037H - 03/01/06
- 06-006 - 02/08/06
- 05-018 - 02/08/05
- 04-043 - 10/19/04
- 03-065 - 06/01/05
- 99-037E - 09/12/04
- 99-037D - 09/01/04
- 04-009 - 02/23/04
- 04-001 - 01/27/04
- 03/058A - 10/15/03
- 03/058 - 10/15/03
- 00-038B - 04/01/04
- Recall R0608 - Headlamp Assembly
- 03-051C - 07/21/08
- Lighting - Exterior Lamp Fogging Inspection
- Lighting - Exterior Lamps Fogging Information
- Lighting - Exterior Lamp Fogging Information
- Instruments - Clock Light Bulb Inoperative
- Interior - Driver's Seat Feels Loose
- Interior - Driver's Seat Squeaking/Creaking Noises
- Paint - Discoloration/Swelling Under Paint Guard Film
- Paint - Swelling/Discoloration Under Paint Guard Film
- Instruments - Door Mirror Inoperative
- Campaign - Rear Hatch Separation
- Campaign - Rear Hatch Panel Separation
- Computers/Controls - No Start in Cold Conditions
- Navigation System - Map Data Update Matrix Info.
- Navigation System - Map Data Update Matrix
- Audio - CD and DVD Player Concerns
- Audio - CD and DVD Player Concerns
- Antitheft Systems - Information and Service
- Antitheft Systems - Information/Service
- Keyless Entry - Remote Transmitter Parts Availability
- Keyless Entry - Remote Fob Parts Replacement
- Restraints - Seat Belts Slow to Retract
- 08-024A - 07/21/08
- Starting/Charging System - Test Procedures/Tester
- Electrical - Battery/Starting/Charging System - Testing
- Electrical - Battery Testing Equipment/Procedures
- Electrical - Battery Testing Procedures and Equipment
- Battery - Testing Procedures/Testing Tool
- Battery - Replacement and Testing
- Battery - Replacement/Testing Procedures
- Brakes - Noise/Judder/Pedal Feel Diagnosis/Repair
- Brakes - Judder/Noise/Pedal Feel Diagnosis/Repair
- Brakes - Front Brake Vibration/Pedal Pulsation
- Brakes - Judder/Noise/Abnormal Pedal Feel
- Brakes - Judder/Noise/Pedal Feel Diagnosis and Repair
- Vehicle - Flat Towing Guidelines/Limitations
- Recall - Fuel Filler Hose Defect
- Emissions - OBD System Readiness Test Drive Patterns
- Emissions - EVAP System Leak DTC Diagnosis
- A/T - DTC P1754/P1759/P1764/P1769/P1774 Diagnostics
- Emissions - DTC P0440/P0442/P0455/P0456/P1440/P1456
- 11-049 - 08/02/11
- Engine Controls - MIL ON/DTC U1000 or U1010 In ECM
- Engine/Transmission - Replacement Precautions
- Engine - MIL ON/Variable Valve Timing DTC's Set
- M/T - Required Gear Oil
- Steering/Suspension - Vehicle Pull/Drift Diagnostics
- Tires - Inflation Pressure Information
- Steering/Suspension - Vehicle Pulls/Drifts Left/Right
- Tires - Tire Pressure Information
- Steering/Suspension - Vehicle Pulls Or Drifts
- Vehicle - VIN Plate/Certification Label Replacement
- Steering/Suspension Wheel Alignment Information
- Steering/Suspension - Wheel Alignment Info.
- Steering/Tires - Pull/Drift/Steering Wheel Off-Center
- Wheels/Tires - Wheel Balancing Using Hunter GSP9700(R)
- Steering/Suspension Drift/Steering Wheel Off Center
- Vehicle - Flat Towing Guidelines/Precautions
- All Technical Service Bulletins
- Body - Exterior Door Sash Moldings Discolored/Streaked
- Body - Front End Pop/Click/Creak Noises on Bumps
- Emissions - System Readiness Test (SRT) Drive Patterns
- Computers/Controls - CONSULT III PLUS(R) Saved Data List
- Body Controls - Configurable BCM Replacement Information
- Wheels/Tires - Wheel/Tire Balancing Information
- Vehicle - Vibration Diagnostic Worksheet
- Lighting - Exterior Lamp Fogging
- Steering/Suspension - Drift/Steering Wheel Off Center
- Keyless Systems/TPMS - SIGNAL TECH II(R) Diag. Tool
- Interior/Restraints - Front Seat Trim Material Info.
- Computers/Controls - Reprogramming Utilizing CONSULT(R)
- Vehicle - Certification Label/VIN Plate Replacement
- Wheels Tires - Hunter GSP9700(R) Set Up Information
- Tires - Mounting Information/Precautions
- Paint - Paint Swells/Discolored Under Paint Guard Film
- Campaign P3132 - Rear Hatch Replacement
- Engine/Transmission - Precautions During Replacement
- Brakes - Rear Brake Squeal/Squeak When Cold
- Brakes - Steering Wheel Shake/Pedal Pulsation
- Engine - Oil Leaks From Oil Cooler Oil Seal
- Body - Paint Staining Due to 'Tire Dressing'
- Body - Front Door Glass Ticking/Popping Noises
- Body - Window Regulator/Motor Service
- Steering - Column Has 2-3 mm Up/Down Play
- Recall 03V164000: Propeller Shaft Bolt Replacement
- Recall - Propeller Shaft Bolt Replacement
- Engine Controls - ECM Replacement Procedures
- Electrical - MIL ON/DTC's U1010 or U1000 Set
- Recall 03V476000: Front Caliper Mounting Bolt Torque
- Recall - Brake Caliper Bolt Torque
- Emissions/Engine Controls - MIL ON/DTC's P0442/P0456
- Interior - Driver's Seat Noisy/Rocks Back and Forth
- Vehicle - Systems Operation/Service
- Instruments - Auto Dimming Mirror/Compass Service
- Navigation System - Screen Stuck in 'PLEASE WAIT' Mode
- Campaign - Air Bag Module Programming
- Brakes - On-Car Brake Rotor Resurfacing
- Instruments - Fuel Gauge Won't Read Completely Full
- Body/Frame - Rear Floor Popping/Creaking Noise
- Alarm System - Incorrect Horn Chirp/Lamp Flash
- Antitheft System - Registration Procedures
- Engine Controls - Idle Speed 25 RPM Too High
- Interior - Front Door Finisher Pocket Hinge Broken
- Interior - Seat Belt Latch Plate Retaining Button Gone
- Cooling System - Leaks/Overheating
- Audio - Satellite Radio Antenna Installation Tips
- Audio System - Satellite Radio Diagnostics
- Keyless Entry - 'Intelligent Key'(R) Malfunctions
- Cruise Control - Maintenance Tips
- Navigation System - DVD Application Chart
- Navigation System - Intermittently Inoperative
- Navigation System - DVD Version Identification
- Paint - Removal Of Enviornmental Iron Particles
- Paint - 2003 Paint Codes
- Recall 05V555000: Fuel Filler Hose Replacement
- Recall - Fuel Filler Hose Replacement
- Interior - Rubber Floormat Installation Precaution
- Sunroof - Won't Open/Close Automatically
- Keyless Entry - Transmitter Replacement Parts
- A/C - Charcoal Cabin Filter Availability/Installation
- Fuel System - Fuel Tank Difficult to Refuel
- Tire Pressure Monitor - Service Guidelines
- Starting System - No Crank In Extreme Cold Conditions
- Wheels - Chrome Wheel Handling When Mounting Tires
- Fuel System - Ticking/Thumping Noise at Idle
- Recall 06V328000: Headlamp Replacement
- Instruments - Clock Won't Illuminate With Lights ON
- Tire Pressure Monitor - Waring Light Flashing or On
- Recall R0607 - Rear Combination Lamp
- M/T - Required Oil for Warranty Repairs
- Engine Controls - ECM Reprogramming Information
- Brakes - Judder/Noise/Pedal Feel Diagnostics/Repair
- Instruments - Outside Door Mirror Inoperative
- Recall R0608 - Headlamp Replacement
- Engine - MIL ON/Multiple DTC's Set
- Electrical - Battery/Starting/Charging System Testing
- Vehicle - Flat Towing Guideline
- Restraints - SRS Service Precaution
- Electrical - Electronic Component Damage Prevention
- Wheels/Tires - Accessory Wheel Lock Installation/Removal
- A/T, CVT - Terminology Update To SAE JJ1930 and J2012
- A/C - Refrigerant Leaks At Connections
- Body - Wind Noise From The Sunroof Area
- Engine Controls - CONSULT-III(R) ECM Programming
- Body - Windshield Cracking Information
- Engine - Reman Engine Start Up Lubrication Information
- Engine - Drive Belt Noise Diagnostics
- Engine Controls - Seized O2 Sensor Removal Procedure
- Restraints - Seat Belts Retract Slowly
- Emissions - EVAP Canister Vent Control Valve Replacement
- Electrical - JIS/CCA Battery Testing Information
- Electrical - Battery/Starting/Charging Sys. Testing
- A/T - 5 Speed A/T DTC Diagnostics
- Engine Controls - ECM Programming Interruption Recovery
- Electrical - MIL ON/DTC P0128 Due To Remote Start Sys.
- Steering/Suspension - Wheel Bearing Collision Damage
- Body - Rear Side Door Replacement Information
- Ignition System - Misfire DTC's/Ignition Coils Blistered
- Steering/Suspension - Wheel Alignment Information
- Suspension - Strut And Shock Absorber Replacement Guidelines
- Recall 13V136000: Passenger Front Air Bag Defect
- Body - Removing Foreign Material From The Windshield
- Entertainment Systems - CD And DVD Player Concerns
- Keyless Systems - MIL ON, DTC B2190 Information
- Navigation System - Map Data Update Matrix