Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Speedometer - Inoperative
- Instrument Harness - Chafing at Steering Reinforcement
- A/C - Unpleasent Odors When In Use
- Disc Brakes - Squeal
- Spark Plug Tube - Oil Accumulation
- HVAC Blower Motor - Noisy or Inoperative
- Heater Core - Coolant Leakage
- Engine Valve Train - Ticking Noise
- Rear Door - Will Not Open From the Inside or Outside
- Engine - Prolonged Crank Time After Hot Soak
- Front Hub (2WD) - Grease Leakage
- Base Clarion Radio Clock - Display Inoperative
- Radio/Speakers - Inoperative/Popping Noises
- Security System - Unintentional Activation
- Body/Frame - Passenger Side Floor Clunking Noise
- MIL ON Erroneous DTCs 33/43 Trans in Backup Mode
- Rear Hatchgate - Glass Difficult To Latch
- Front Door/Fender - Ice Buildup and Damage
- Center Console Stay - Breakage
- Clutch Shift Fork - Noise/Squeak
- Door Locks - Front/Rear Doors Will Not Lock
- LR Door Lock - Not Fully Unlocking w/Front Power Lock.
- Roof Rack - Cross Slats Bow Excessively
- Roof Rack - Whistling/Fluttering Noise
- HVAC System - Unpleasant Odors When In Use
- A/T - (4L30E) Delayed Gear Engagement
- Rear Brakes - Squeal/Shudder While Backing Up
- Brakes - Squeal Upon Light Application
- Generals
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Warranty Parts - Return Shipping Revisions
- Sealers/Adhesives - Cross Reference Chart
- Workshop Manual - Revisions and Updates
- Speedometer - Inoperative
- Instrument Harness - Chafing at Steering Reinforcement
- Electrical - Inspect Connectors for Various Malfunctions
- A/C - Unpleasent Odors When In Use
- A/C - Refrigerant System Sealer/Leak Detection
- Drivetrain - Driveline 'Clunk' Explanation
- Trooper(UX), Rodeo(UC) SOHC Hydraulic Valve Lifter Pr..
- Engine - Servicing Procedure Revision
- Disc Brakes - Squeal
- Spark Plug Tube - Replacement
- Spark Plug Tube - Oil Accumulation
- Spark Plug Tube - Replacement Procedure
- HVAC Blower Motor - Noisy or Inoperative
- Heater Core - Coolant Leakage
- Engine Valve Train - Ticking Noise
- Cylinder Head Cover - Installation Precautions
- Water Pump - Installation (Manual Revision)
- A/C - Receiver Dryer Replacement Recommendations
- Oil Cooler - Center Bolt Torque Value Correction
- Radial Tire - Sidewall Indentations
- Wheel Lug - Torque Stick Now Used for Installation
- Rear Door - Will Not Open From the Inside or Outside
- Engine - Prolonged Crank Time After Hot Soak
- Front Hub (2WD) - Grease Leakage
- Battery - Testing and Inspection
- Recall - 97V034 Alternator/Regulator
- Recall - 97V034 Battery Terminal Stud Bushing
- Recall 97V034001: Alternator/Regulator Defect
- Recall 97V034000: Alternator/Voltage Regulator Defect
- DTC 32 (EGR Circuit) Diagnostic Procedure Revised
- A/T - (4L30E) Control Module Identification
- Base Clarion Radio Clock - Display Inoperative
- Radio/Speakers - Inoperative/Popping Noises
- Seat Belt Extender - Availability/Installation Procedure
- Oil Filter - Precaution During Installation
- Security System - Unintentional Activation
- Body/Frame - Passenger Side Floor Clunking Noise
- Dual Air Bags - New Safety Warning Labels
- MIL ON Erroneous DTCs 33/43 Trans in Backup Mode
- TCM/MEM CAL Unit - Updated Replacement Procedures
- Scan Tool - Introducing Powerlink Diagnostics
- A/T - Flash Code 61
- A/T - Check Trans Lamp ON/Flash Code 37
- Rear Hatchgate - Glass Difficult To Latch
- Front Door/Fender - Ice Buildup and Damage
- Child Safety Seats - Supplement Booklet For Installing
- Safety Glass - Identification and Maintenance
- Campaign - 96S001 Brush/Grille Guard Separation
- Campaign - Brush/Grille Guard
- Radiator Grilles - Painting of Primered Replacement
- Coolant - Propylene Glycol Not Approved by Isuzu
- Engine Coolant - Propylene Glycol Acceptable for Use
- Center Console Stay - Breakage
- A/T - (4L30E) Diagnostic Procedure Revision
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- M/T - Shop Manual Corrections
- CD Player - Compatible Compact Discs
- Low Fuel Indicator Light - Operation
- Dexron-IIE Fluid - Recommended Usage
- Spark Plug Tube - Oil Seepage
- Camshaft Pulley - Service Procedures
- Electrical Wiring - Repair Terminal Kit Availability
- Clutch Shift Fork - Noise/Squeak
- Door Locks - Front/Rear Doors Will Not Lock
- LR Door Lock - Not Fully Unlocking w/Front Power Lock.
- Campaign - Incorrect Seat Belt Warning Label
- Roof Rack - Cross Slats Bow Excessively
- Roof Rack - New Installation Tool Available
- Roof Rack - Whistling/Fluttering Noise
- Paint - Color Codes and Cross References
- Paint - Colors and Codes
- HVAC System - Unpleasant Odors When In Use
- A/T - (4L30E) Delayed Gear Engagement
- Rear Brakes - Squeal/Shudder While Backing Up
- Brakes - Squeal Upon Light Application
- Front End Alignment - Inspection (Manual Revision)
- Airbag - On/Off Switch Kit Availability
- Child Seat Tether Anchor Kit - Availability
- Tires - Proper Inflation Pressure Information
- Fuel System - Top Tier Detergent Gasoline Information
- A/C - Contaminated R134A Refrigerant Precautions
- Engine - Oil Usage Testing and Reporting
- A/C - SAE J2788 Refrigerant Recovery Standard
- Fuel System - Fuel Mileage Do's and Don'ts