Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Speedometer - Inoperative
- Instrument Harness - Chafing at Steering Reinforcement
- A/C - Unpleasent Odors When In Use
- Disc Brakes - Squeal
- HVAC Blower Motor - Noisy or Inoperative
- Heater Core - Coolant Leakage
- Rear Door - Will Not Open From the Inside or Outside
- M/T - Noise From The Bell Housing Area
- A/T - 4L30E MIL ON/DTC P1870 Stored in PCM
- Front Hub (2WD) - Grease Leakage
- Key - Difficult to Remove From Ignition Switch
- Emissions - Misfire DTC's/Catalytic Converter Damage
- Base Clarion Radio Clock - Display Inoperative
- Tailgate glass - Breakage After Tint Film Installation
- Body/Frame - Passenger Side Floor Clunking Noise
- A/T - MIL ON/DTC P1870 Stored in Memory
- Front Door/Fender - Ice Buildup and Damage
- Center Console Stay - Breakage
- Door Locks - Front/Rear Doors Will Not Lock
- LR Door Lock - Not Fully Unlocking w/Front Power Lock.
- 4WD Indicator - Remains Lit in 2WD Mode
- Roof Rack - Whistling/Fluttering Noise
- HVAC System - Unpleasant Odors When In Use
- A/T - (4L30E) Delayed Gear Engagement
- Crankshaft - Front Oil Seal Retainer Leakage
- Rear Brakes - Squeal/Shudder While Backing Up
- Brakes - Squeal Upon Light Application
- A/T - Oil Pan Drain Plug Leak
- Generals
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Warranty Parts - Return Shipping Revisions
- Sealers/Adhesives - Cross Reference Chart
- Electrical Troubleshooting - Manual Update
- Speedometer - Inoperative
- Instrument Harness - Chafing at Steering Reinforcement
- Electrical - Inspect Connectors for Various Malfunctions
- A/C - Unpleasent Odors When In Use
- A/C - Refrigerant System Sealer/Leak Detection
- Vehicle - Fluid Leakage/Seepage Information
- Drivetrain - Driveline 'Clunk' Explanation
- Disc Brakes - Squeal
- Maintenance - Spark Plug Type Revised
- HVAC Blower Motor - Noisy or Inoperative
- Heater Core - Coolant Leakage
- A/C - Receiver Dryer Replacement Recommendations
- Exhaust Manifold - Stud Nut Removal/Installation
- Radial Tire - Sidewall Indentations
- Wheel Lug - Torque Stick Now Used for Installation
- Rear Door - Will Not Open From the Inside or Outside
- M/T - Noise From The Bell Housing Area
- A/T - 4L30E MIL ON/DTC P1870 Stored in PCM
- PCM - Reprogramming
- PCM - Available Programming for Aftermarket Purchases
- Engine Controls - ECM Reprogramming Recommendations
- Front Hub (2WD) - Grease Leakage
- Voltmeter - Needle Drop During Hard/Quick Acceleration
- Key - Difficult to Remove From Ignition Switch
- DTC 32 (EGR Circuit) Diagnostic Procedure Revised
- Emissions - Misfire DTC's/Catalytic Converter Damage
- A/T - (4L30E) Control Module Identification
- Base Clarion Radio Clock - Display Inoperative
- Tailgate glass - Breakage After Tint Film Installation
- Seat Belt Extender - Availability/Installation Procedure
- Oil Filter - Precaution During Installation
- Manual Revision: 96-97 Rodeo, ABS DTC 31
- Campaign - 96SL01 Height Control Arm
- Body/Frame - Passenger Side Floor Clunking Noise
- Dual Air Bags - New Safety Warning Labels
- DTC P0102 Revised Diagnostic Page
- Tools - Enhanced EVAP System Special Tools
- Exhaust System - Sulfur/Rotten Egg Smell
- Scan Tool - Introducing Powerlink Diagnostics
- Tools - Powerlink Diagnostics Interface Module
- A/T - MIL ON/DTC P1870 Stored in Memory
- Front Door/Fender - Ice Buildup and Damage
- Child Safety Seats - Supplement Booklet For Installing
- Safety Glass - Identification and Maintenance
- Campaign - 96S001 Brush/Grille Guard Separation
- Campaign - Brush/Grille Guard
- Radiator Grilles - Painting of Primered Replacement
- Engine Coolant - Propylene Glycol Acceptable for Use
- Center Console Stay - Breakage
- CD Player - Compatible Compact Discs
- Drive Belt - Adjustment Procedure Correction
- A/T - Fluid Requirements
- Electrical Wiring - Repair Terminal Kit Availability
- Fuel System - Electrical Test, Manual Corrections
- Wheels/Tires - Tire Balancer Adapter Plate Usage
- Door Locks - Front/Rear Doors Will Not Lock
- LR Door Lock - Not Fully Unlocking w/Front Power Lock.
- 4WD Indicator - Remains Lit in 2WD Mode
- MIL ON DTC P1860 Set
- MIL ON DTC P1870 (A/T Component Slipping) Set
- Roof Rack - New Installation Tool Available
- Roof Rack - Whistling/Fluttering Noise
- Paint - Colors and Codes
- Rear Axle - Service Procedures Revised
- HVAC System - Unpleasant Odors When In Use
- A/T - (4L30E) Delayed Gear Engagement
- Crankshaft - Front Oil Seal Retainer Leakage
- Rear Brakes - Squeal/Shudder While Backing Up
- Brakes - Squeal Upon Light Application
- Front End Alignment - Inspection (Manual Revision)
- Airbag - On/Off Switch Kit Availability
- Child Seat Tether Anchor Kit - Availability
- A/T - Oil Pan Drain Plug Leak
- Tires - Proper Inflation Pressure Information
- Fuel System - Top Tier Detergent Gasoline Information
- A/C - Contaminated R134A Refrigerant Precautions
- Engine - Oil Usage Testing and Reporting
- A/C - SAE J2788 Refrigerant Recovery Standard
- Fuel System - Fuel Mileage Do's and Don'ts