Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Recall 10V436 - Rear Suspension Trailing Arm Bracket
- Overview
- Condition One : Apply Noxudol 300
- Condition Two: Apply Noxudol 700 and Noxudol 300
- Condition Three: Reinforcement Bracket Type "A" Installation
- Condition Four: Reinforcement Bracket Type "B" Installation
- Owner Notification Letter - Vehicles More Than 10 Years Old
- Owner Notification Letter - Vehicles Less Than 10 Years Old
- Owner Second Notification Letter - Vehicles More Than 10 Years Old
- Owner Second Notification Letter - Vehicles Less Than 10 Years Old
- Recall 97V206001: Floor Mat Interferes with Accelerator
- Recall 01I002000: Timing Belt and Tensioner
- Recall - 00V058 Rear Axle Lower Trailing Link
- Recall - ABS Coil Integrated Module Update
- Recall 00V058000: Rear Axle Lower Link Joint Nut, Bolt
- Recall - 98V170 Engine Ground Wire Harness Replacement
- Recall - Engine Ground Point Addendum
- Recall 98V170000: Ground Connection Terminal Defect
- Recall 98V170001: Ground Connection Terminal Defect
- Recall 97V206000: Driver's Side Optional Floor Mat
- Recall - Accessory Rubber Floor Mat
- Recall 10V436000: Rear Lower Control Arm Bracket
- Recall 10V436 - Rear Suspension Trailing Arm Bracket
- Customer Interest
- A/C - Unpleasent Odors When In Use
- Steering - Steering Wheel Vibration/Shimmy
- Steering, Suspension - Vibration/Shimmy
- Remote Starter Kits - Causes MIL ON (P0705) set
- Disc Brakes - Squeal
- A/C - Compressor Emits Medium Pitched Moaning Sound
- Rear Bumper Assembly - Paint Staining
- Body - Door Weatherstrips Loose/Out of Position
- Air Bags - Rubbing Noise When Turning Steering Wheel
- A/T Torque Converter - MIL ON DTC P1870
- A/T - 4L30E MIL ON/DTC P1870 Stored in PCM
- Engine - MIL ON/High Erratic Idle/Noise
- Rear Brakes - Squeal
- DTCs 53/63/65 (ABS Wheel Sensor) Set
- Emissions - Misfire DTC's/Catalytic Converter Damage
- Audio System - Inoperative/Speaker Noise
- Tailgate glass - Breakage After Tint Film Installation
- Fuel Guage - Inaccuracy
- Ignition Switch - Won't Turn to The Lock Position
- Accessory Side Step - Anti Skid Strip Replacement
- A/T - MIL ON/DTC P1870 Stored in Memory
- Speakers - Whining Noises
- Front Door/Fender - Ice Buildup and Damage
- Hood Protector - Rattle
- Windshield Washer Tank - Leaks Fluid
- Door Mirror - Wind Noise
- Mud Flap - Rubbing Sound When Turning
- Rear Cup Holder - Replacement.
- Rear Cup Holder - Revised Strike Plate Latches
- Intake Manifold Gasket - MIL ON/DTC's Set
- Engine Harness - Electrical Short/No Start/Driveability
- Roof Rack - Whistling/Fluttering Noise
- HVAC System - Unpleasant Odors When In Use
- A/T - (4L30E) Delayed Gear Engagement
- Tailgate Glass - Rattles/Squeaks
- Brakes - Squeal Upon Light Application
- Tailgate Lock - Key Does Not Unlock the Cylinder
- A/C - Insufficient Cooling During Maximum A/C Operation
- A/T - Oil Pan Drain Plug Leak
- Interior - Rear Storage Compartment Lid Lock Knob Broken
- Rear Axle Seal - Leakage
- Factory Modifications
- Recommended Repairs
- Superceded Bulletins
- SB98-13-L005 - 01/01/98
- SB98-09-L002 - 01/01/98
- SB03-09-S001B - 06/01/03
- SB03-05-S001 - 05/01/03
- SB00-10-S001 - 04/01/01
- SB00-05-S002 - 06/01/00
- Instrument Panel - Fuel Gauge Reads Inaccurately
- Airbags - Installation of On/Off Switches
- A/C Compressor - Moaning Sound
- Recall - Rear Trailing Link Bracket Corrosion
- Recall - Brake Coil Integrated Module Replacement
- DTC P1441 (EVAP System) Diagnosis
- Engine - Oil Consumption Usage Testing/Reporting
- All Technical Service Bulletins
- Recall 10V436 - Rear Suspension Trailing Arm Bracket
- Overview
- Condition One : Apply Noxudol 300
- Condition Two: Apply Noxudol 700 and Noxudol 300
- Condition Three: Reinforcement Bracket Type "A" Installation
- Condition Four: Reinforcement Bracket Type "B" Installation
- Owner Notification Letter - Vehicles More Than 10 Years Old
- Owner Notification Letter - Vehicles Less Than 10 Years Old
- Owner Second Notification Letter - Vehicles More Than 10 Years Old
- Owner Second Notification Letter - Vehicles Less Than 10 Years Old
- Warranty Parts - Return Shipping Revisions
- Sealers/Adhesives - Cross Reference Chart
- Recall 97V206001: Floor Mat Interferes with Accelerator
- Electrical - Inspect Connectors for Various Malfunctions
- A/C - Unpleasent Odors When In Use
- A/C - Refrigerant System Sealer/Leak Detection
- Steering Wheel - Vibration, Shimmy or Nibble
- Steering - Steering Wheel Vibration/Shimmy
- Steering, Suspension - Vibration/Shimmy
- Vehicle - Fluid Leakage/Seepage Information
- Drivetrain - Driveline 'Clunk' Explanation
- Engine - Service Procedures Revision
- Engine - Workshop Manual Revision
- Engine/Cooling - System Diagnostic Revisions
- Remote Starter Kits - Causes MIL ON (P0705) set
- Disc Brakes - Squeal
- A/C - Compressor Emits Medium Pitched Moaning Sound
- Timing Belt - Installation
- Maintenance - Timing Belt/Valve Clearance
- Recall 01I002000: Timing Belt and Tensioner
- Cooling System - Fan Clutch Replacement Procedure
- Cooling Fan Assembly - Torque Specifications Revised
- Engine - Piston Rings, Installation Procedure Update
- A/C - Receiver Dryer Replacement Recommendations
- Engine - Intake Manifold Bolt Torque Revision
- Recall - 00V058 Rear Axle Lower Trailing Link
- Tire Pressure - Manual Revisions
- Tires - Replacement Program Terminated
- Wheel Lug - Torque Stick Now Used for Installation
- Rear Bumper Assembly - Paint Staining
- Instrument Panel/Seats - R and R and Torque Spec Revised
- Body - Door Weatherstrips Loose/Out of Position
- Air Bags - Rubbing Noise When Turning Steering Wheel
- A/T Torque Converter - MIL ON DTC P1870
- A/T - 4L30E MIL ON/DTC P1870 Stored in PCM
- M/T - Speedometer Gear Bushing Mounting Position Update
- PCM - Reprogramming
- PCM - Available Programming for Aftermarket Purchases
- PCM - Alternate Reprogramming Procedure
- Engine - MIL ON/High Erratic Idle/Noise
- Engine Controls - ECM Reprogramming Recommendations
- Rear Brakes - Squeal
- Drum Brakes - Adjustment Procedure
- ABS - Rear Speed Sensor Resistance Value Revision
- DTCs 53/63/65 (ABS Wheel Sensor) Set
- Recall - ABS Coil Integrated Module Update
- Campaign - 9804L2 Battery Discharge Service
- Fuel System - Throttle Body Bolt Torque Revision
- Emissions - Misfire DTC's/Catalytic Converter Damage
- Antitheft - Alarm Sounds Intermit., Dome Lamp Flickers
- Anti Theft Controller - Ordering W/Correct Part Numbers
- Audio System - Inoperative/Speaker Noise
- Tailgate glass - Breakage After Tint Film Installation
- Seat Belt Extender - Availability/Installation Procedure
- Oil Filter - Precaution During Installation
- Fuel Guage - Inaccuracy
- DTC P1441 EVAP/Fuel Sender Calibration Revised
- ABS - Manual Clearing of DTCs, Revised
- Campaign - 9809L2 ABS Coil Integrated Module Revised
- Recall 00V058000: Rear Axle Lower Link Joint Nut, Bolt
- Ignition Switch - Won't Turn to The Lock Position
- Suspension - Proper Ride Height Adjustment Suppliment
- Accessory Side Step - Anti Skid Strip Replacement
- Kent-Moore Essential Tools Update: New SRS Tool Adapters
- Keyless Entry System - Reprogramming
- DTC P0102 Revised Diagnostic Page
- DTC P1441 (EVAP) Diagnostic Procedures Revised
- Recall - 99ES01 Evap Hose Emissions
- Exhaust System - Sulfur/Rotten Egg Smell
- Scan Tool - Introducing Powerlink Diagnostics
- Recall - 98V170 Engine Ground Wire Harness Replacement
- Tools - Powerlink Diagnostics Interface Module
- Service Manual - DTC P1640/P1650 Correction
- Recall - Engine Ground Point Addendum
- A/T - MIL ON/DTC P1870 Stored in Memory
- Speakers - Whining Noises
- Front Door/Fender - Ice Buildup and Damage
- Hood Protector - Part Number Replacement
- Hood Protector - Rattle
- Child Restraint - Top Tether Seat Anchor Bracket Kit
- Safety Glass - Identification and Maintenance
- Windshield Washer Tank - Leaks Fluid
- Door Mirror - Wind Noise
- Door Mirror - Cracked/Replacement Kit Installation
- Hood Protector - Grille Paint Damage
- Radiator Grilles - Painting of Primered Replacement
- Mud Flap - Rubbing Sound When Turning
- Rear Cup Holder - Replacement.
- Rear Cup Holder - Revised Strike Plate Latches
- Engine Coolant - Propylene Glycol Acceptable for Use
- Intake Manifold Gasket - MIL ON/DTC's Set
- CD Player - Compatible Compact Discs
- A/T - Fluid Requirements
- A/t - Select Lever/Cable Adjustment Revisions
- Body - Wind Noise/Turbulence
- Dome Light Fuse - Removal During Vehicle Storage
- Recall 98V170000: Ground Connection Terminal Defect
- Recall 98V170001: Ground Connection Terminal Defect
- Charging System - Revised Manual Text and Art
- Engine Harness - Electrical Short/No Start/Driveability
- Electrical Wiring - Repair Terminal Kit Availability
- Electrical System/Harness - Failure Report
- Fuel System - Electrical Test, Manual Corrections
- Cruise Control - DTCs 1-1/1-2/1-4 Diagnosis Revised
- Wheels/Tires - Tire Balancer Adapter Plate Usage
- Recall 97V206000: Driver's Side Optional Floor Mat
- Roof Rack - Whistling/Fluttering Noise
- Paint - Color Codes and Cross References
- Recall - Accessory Rubber Floor Mat
- A/T - Shift Lock Solenoid Replacement
- HVAC System - Unpleasant Odors When In Use
- A/T - (4L30E) Delayed Gear Engagement
- Campaign - 9813L6 Trailer Hitch Wiring Sub Harness
- Tailgate Glass - Rattles/Squeaks
- Fuel Hose Connector - Quick Release Procedure
- Brakes - Squeal Upon Light Application
- Tailgate Lock - Key Does Not Unlock the Cylinder
- Front End Alignment - Inspection (Manual Revision)
- Alignment - Toe In Specification Change
- Airbag - On/Off Switch Kit Availability
- A/C - Insufficient Cooling During Maximum A/C Operation
- A/T - Oil Pan Drain Plug Leak
- Interior - Rear Storage Compartment Lid Lock Knob Broken
- Rear Axle Seal - Leakage
- Tires - Proper Inflation Pressure Information
- Fuel System - Top Tier Detergent Gasoline Information
- A/C - Contaminated R134A Refrigerant Precautions
- Engine - Oil Usage Testing and Reporting
- A/C - SAE J2788 Refrigerant Recovery Standard
- Brakes - Rear Brake Rotor Part Number Update
- Fuel System - Fuel Mileage Do's and Don'ts
- Recall 10V436000: Rear Lower Control Arm Bracket
- Recall 10V436 - Rear Suspension Trailing Arm Bracket