Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 10V436 - Rear Suspension Trailing Arm Bracket
- Overview
- Condition One : Apply Noxudol 300
- Condition Two: Apply Noxudol 700 and Noxudol 300
- Condition Three: Reinforcement Bracket Type "A" Installation
- Condition Four: Reinforcement Bracket Type "B" Installation
- Owner Notification Letter - Vehicles More Than 10 Years Old
- Owner Notification Letter - Vehicles Less Than 10 Years Old
- Owner Second Notification Letter - Vehicles More Than 10 Years Old
- Owner Second Notification Letter - Vehicles Less Than 10 Years Old
- Recall 01I002000: Timing Belt and Tensioner
- Recall - 00V058 Rear Axle Lower Trailing Link
- Recall - Head Impact Protection
- Recall - ABS Coil Integrated Module Replacement
- Recall - ABS Coil Integrated Module Update
- Recall 00V058000: Rear Axle Lower Link Joint Nut, Bolt
- Recall 00V121001: Interior Modifications
- Recall 10V436000: Rear Lower Control Arm Bracket
- Recall 10V436 - Rear Suspension Trailing Arm Bracket
- Customer Interest
- A/C - Unpleasent Odors When In Use
- Steering - Steering Wheel Vibration/Shimmy
- Steering, Suspension - Vibration/Shimmy
- Remote Starter Kits - Causes MIL ON (P0705) set
- Disc Brakes - Squeal
- Body - Vibrations
- Body - Door Weatherstrips Loose/Out of Position
- A/T Torque Converter - MIL ON DTC P1870
- A/T - 4L30E MIL ON/DTC P1870 Stored in PCM
- DTCs 53/63/65 (ABS Wheel Sensor) Set
- ABS Pump - Runs Continuously/Possible ABS Light ON
- Starter - Engine No Crank/No Start Condition
- PCM - MIL ON/DTC P0502 Set
- Emissions - Misfire DTC's/Catalytic Converter Damage
- Tailgate glass - Breakage After Tint Film Installation
- Ignition Switch - Won't Turn to The Lock Position
- A/T - MIL ON/DTC P1870 Stored in Memory
- Windshield Washer Tank - Leaks Fluid
- Mud Flap - Rubbing Sound When Turning
- Interior - Rear Cup Holder Swing Arm Loose
- Roof Rack - Whistling/Fluttering Noise
- HVAC System - Unpleasant Odors When In Use
- A/T - (4L30E) Delayed Gear Engagement
- Tailgate Glass - Rattles/Squeaks
- Brakes - Squeal Upon Light Application
- Tailgate Lock - Key Does Not Unlock the Cylinder
- A/C - Insufficient Cooling During Maximum A/C Operation
- A/T - Oil Pan Drain Plug Leak
- Interior - Rear Storage Compartment Lid Lock Knob Broken
- Rear Axle Seal - Leakage
- Recommended Repairs
- Superceded Bulletins
- SB03-09-S001B - 06/01/03
- SB03-05-S001 - 05/01/03
- SB00-10-S001 - 04/01/01
- SB00-05-S002 - 06/01/00
- Airbags - Installation of On/Off Switches
- Recall - Rear Trailing Link Bracket Corrosion
- Recall - Brake Coil Integrated Module Replacement
- Engine - Oil Consumption Usage Testing/Reporting
- Body - Vibration
- Rear Wheels - Vibration at Highway Speeds
- All Technical Service Bulletins
- Recall 10V436 - Rear Suspension Trailing Arm Bracket
- Overview
- Condition One : Apply Noxudol 300
- Condition Two: Apply Noxudol 700 and Noxudol 300
- Condition Three: Reinforcement Bracket Type "A" Installation
- Condition Four: Reinforcement Bracket Type "B" Installation
- Owner Notification Letter - Vehicles More Than 10 Years Old
- Owner Notification Letter - Vehicles Less Than 10 Years Old
- Owner Second Notification Letter - Vehicles More Than 10 Years Old
- Owner Second Notification Letter - Vehicles Less Than 10 Years Old
- SB01-01-S001 - 06/01/2001
- Sealers/Adhesives - Cross Reference Chart
- Electrical - Inspect Connectors for Various Malfunctions
- A/C - Unpleasent Odors When In Use
- A/C - System Operation Update
- A/C - Refrigerant System Sealer/Leak Detection
- A/C - Compressor Will Not Engage
- Steering - Steering Wheel Vibration/Shimmy
- Steering, Suspension - Vibration/Shimmy
- Vehicle - Fluid Leakage/Seepage Information
- Drivetrain - Driveline 'Clunk' Explanation
- Engine - Long Block Availability
- Remote Starter Kits - Causes MIL ON (P0705) set
- Disc Brakes - Squeal
- Recall 01I002000: Timing Belt and Tensioner
- Timing Belt - Scrapping Old Inventory
- Campaign - Timing Belt Replacement
- Campaign - Premature Timing Belt Wear
- A/C - Receiver Dryer Replacement Recommendations
- Recall - 00V058 Rear Axle Lower Trailing Link
- Body - Vibrations
- Tire Pressure - Manual Revisions
- Tires - Replacement Program Terminated
- Wheel Lug - Torque Stick Now Used for Installation
- Body - Door Weatherstrips Loose/Out of Position
- Recall - Head Impact Protection
- A/T Torque Converter - MIL ON DTC P1870
- A/T - 4L30E MIL ON/DTC P1870 Stored in PCM
- M/T - Speedometer Gear Bushing Mounting Position Update
- PCM - Reprogramming
- PCM - Alternate Reprogramming Procedure
- Engine Controls - ECM Reprogramming Recommendations
- Drum Brakes - Adjustment Procedure
- DTCs 53/63/65 (ABS Wheel Sensor) Set
- ABS Pump - Runs Continuously/Possible ABS Light ON
- Recall - ABS Coil Integrated Module Replacement
- Recall - ABS Coil Integrated Module Update
- Starter - Engine No Crank/No Start Condition
- Crankshaft Position Sensor - Flow Chart Revision
- PCM - MIL ON/DTC P0502 Set
- PCM - Code P1336 Set After Engine Replacement
- Emissions - Misfire DTC's/Catalytic Converter Damage
- Antitheft - Alarm Sounds Intermit., Dome Lamp Flickers
- Tailgate glass - Breakage After Tint Film Installation
- Oil Filter - Precaution During Installation
- DTC P1441 EVAP/Fuel Sender Calibration Revised
- Recall 00V058000: Rear Axle Lower Link Joint Nut, Bolt
- Ignition Switch - Won't Turn to The Lock Position
- Suspension - Proper Ride Height Adjustment Suppliment
- Kent-Moore Essential Tools Update: New SRS Tool Adapters
- Exhaust System - Sulfur/Rotten Egg Smell
- Scan Tool - Introducing Powerlink Diagnostics
- Engine Controls - Long Crank Time During Cold Restart
- Tools - Powerlink Diagnostics Interface Module
- A/T - MIL ON/DTC P1870 Stored in Memory
- Hood Protector - Part Number Replacement
- Child Restraint - Top Tether Seat Anchor Bracket Kit
- Safety Glass - Identification and Maintenance
- Windshield Washer Tank - Leaks Fluid
- Mud Flap - Rubbing Sound When Turning
- Interior - Rear Cup Holder Swing Arm Loose
- CD Player - Compatible Compact Discs
- A/T - Fluid Requirements
- Body - Wind Noise/Turbulence
- Wheels/Tires - Tire Balancer Adapter Plate Usage
- Recall 00V121001: Interior Modifications
- Roof Rack - Whistling/Fluttering Noise
- Paint - Colors and Codes
- A/T - Shift Lock Solenoid Replacement
- HVAC System - Unpleasant Odors When In Use
- A/T - (4L30E) Delayed Gear Engagement
- Tailgate Glass - Rattles/Squeaks
- Fuel Hose Connector - Quick Release Procedure
- Brakes - Rear Drum Brake Adjustment Procedure
- Brakes - Squeal Upon Light Application
- Tailgate Lock - Key Does Not Unlock the Cylinder
- Alignment - Toe In Specification Change
- Airbag - On/Off Switch Kit Availability
- A/C - Insufficient Cooling During Maximum A/C Operation
- A/T - Oil Pan Drain Plug Leak
- Interior - Rear Storage Compartment Lid Lock Knob Broken
- Rear Axle Seal - Leakage
- Tires - Proper Inflation Pressure Information
- Fuel System - Top Tier Detergent Gasoline Information
- A/C - Contaminated R134A Refrigerant Precautions
- Engine - Oil Usage Testing and Reporting
- A/C - SAE J2788 Refrigerant Recovery Standard
- Fuel System - Fuel Mileage Do's and Don'ts
- Recall 10V436000: Rear Lower Control Arm Bracket
- Recall 10V436 - Rear Suspension Trailing Arm Bracket