Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 05V198000: Flasher Module Replacement
- Recall - Wiper Motor/Module Defect
- Recall - Theft Protection Non-Compliance
- Recall - FMVS 114 Theft Protection Non-Compliance
- Recall - Rear Side Door Latch Corrosion
- Recall 03V269000: Child Restraint Non-Compliance
- Recall - Child Restraint Anchorage Non-Compliance
- Recall - Child Restraint Information Non-Compliance
- Recall 04V061000: Windshield Wiper System Malfunctions
- Recall - Flasher Relay Module Replacement
- Customer Interest
- Electrical - Multiple Intermittent Concerns
- A/C - Poor Performance in High Heat/Humidity Conditions
- A/C - Intermittent Insufficient Cooling When Hot
- Engine Controls - Engine Ticking Noise at Idle
- Electrical - Intermittent No Crank/No Start Condition
- Ignition System - SES Lamp ON/DTC P0300 Set/Misfire
- A/C - Blower Motor Inoperative/Won't Shut OFF
- Steering - Moan/Vibration/Shudder
- A/T/Suspension - Intermittent Rumbling/Booming Noise
- Suspension - Clunk/Pop/Rattle/Loose Lumber Noise
- Body - Popping Noise When Rolling Up Front Door Window
- Body - Water Leaks Onto Front Carpet
- A/T - Rattle Noise Coming From Under Vehicle
- A/T - Rattle Noise From Under the Vehicle
- A/T - SES Lamp ON/DTC P0757/Slipping/Poor Performance
- Fuel System - Multiple Driveability Symptoms
- Steering - Steering Column Squeak/Rubbing Noise
- Steering - Hiss/Rush Noise From Steering Column
- Battery - Discharges After Ignition Switch Replacement
- Ignition -MIL ON/A/T Stuck in 3rd Gear/DTC's Set
- A/T - Stuck In 2nd or 3rd Gear/MIL ON/Inst. Panel Inop.
- Engine Controls/Emissions - Hesitation/A/T Slipping
- Engine Controls - Higher Than Normal Engine Temperature
- Engine Controls - SES Lamp ON/DTC's P0133 or P0172
- Emissions - Misfire DTC's/Catalytic Converter Damage
- Lighting - Headlamps Flicker or Dim While Driving
- Lighting - Turn Signals/Flasher Stuck ON
- Body - Rattling Sound From Hood
- Body - Liftgate Glass Unlatches on Bumpy Roads
- Body - Doors Are Hard To Close
- Body - Liftgate/Glass Hard To Open/CHMSL Hits Roof
- Restraints - Seat Belt Retractor Won't Release
- Instruments - Outside Rear View Mirror Vibration
- Audio System - Poor Reception/Station Drifts
- Audio System - CD Player Skips/Inoperative/Sluggish
- Keyless Entry System - Inoperative
- Audio System - Error Codes Displayed
- Lighting - Center Mounted Stop Lamp Applique Loose
- A/C - Intermittently Inoperative/Blows Warm Air
- A/T - 4L60E Harsh 1 - 2 Upshift
- A/T - 4L60-E Harsh 1-2 Upshift
- Exhaust System - Rattle/Popping Sound
- A/C - Poor Performance
- Body - Rattle From Under The Hood
- Fuel System - Pump Nozzle Shuts OFF/Tank Slow to Fill
- A/C - Musty Odors On Hot/Humid Days
- Ignition System - MIL ON/Misfire DTC's/Rough Idle
- Body - Popping/Creaking Noise From The C-Pillar Area
- Electrical - MIL ON/DTC's P0480/P0526/P1481/P1484
- A/T - Slipping/MIL ON/DTC P0757/Poor Performance
- Body - Poor Liftgate or Liftgate Glass Fit/Glass Broken
- Body - Distortion On Outside of Vehicle Glass Surfaces
- Body - Right Rear Door Glass Binding
- Electrical - MIL ON/DTC's P0480/P0526/P1481 Set
- Ignition System - Runs Rough/Misfire DTC's When Wet
- Body - Bumps Or Rust Colored Spots In Paint
- Body - Doors are Hard to Close
- Brakes - ABS Lamp ON/DTC's C0265/C0201/U1041 Set
- Body - Center Mounted Stop Lamp Applique loose
- Wipers/Washers - Poor Cleaning Performance
- A/C - Blower Motor Inoperative/Won't Shut OFF When Cold
- Fuel System - MIL ON/Multiple DTC's Set
- OnStar(R) - Incorrect GPS Position During OnStar(R) Call
- Instruments - Erratic Speedometer Operation/Needle Shake
- Lighting - Ext. Lamp Condensation/Replacement Guideline
- A/T - Harsh 1-2 Shift/DTC's P0741/P0756/P0894
- Body - Rear License Pocket Perimeter Gasket Loose
- Recommended Repairs
- Safety
- Superceded Bulletins
- Wipers - Performance/Cleaning and Maintenance
- Body - Outer Glass Surface Distortion/Orange Peeling
- A/C - Rear Window Defroster Grid Repair
- SB07-11-S008 - 07/06/07
- Lighting - Exterior Lamp Condensation/Replacement
- Lighting - Center High Mount Stop Lamp Applique Loose
- Instruments - Noise From Instrument Cluster
- Body - Water Intrusion at 'A' Pillar
- Interior - Cleaning Seats/Carpet/Leather/Vinyl
- Body - Rear License Plate Perimeter Gasket
- Body - License Plate Pocket Gasket Loose/Out of Position
- Body - Rear License Plate Pocket Gasket Out of Place
- Body - Rear License Plate Pocket Gasket Loose
- Body - Rear Liftgate Sticking/Binding
- Body Doors are Hard to Close
- A/C - Blower Motor Inop .or Works On Low Speed Only
- Steering Steering Gear Stub Shaft Bearing Kit
- A/C - Automatic Dual Zone A/C Battery Draw
- Charging System Operational Information
- ABS - Warning Lamp ON/DTC's C0201/C0265/U1041
- A/T - 2-3 Upshift/3-2 Downshift Shift Bump/Clunk
- A/T - Cracked or Broken Case Diagnosis
- A/T - 2nd - 3rd/3rd - 2nd Gear Shift Clunk Explanation
- SB07-02-S001 - 06/20/07
- A/T - MIL ON/DTC P0757/Slipping/No 3rd or 4th Gear
- A/T - 4L60-E - DTC P0756 Diagnostic Tips
- Brakes - ABS Lamp ON/DTC's C0265/C0201/U1041
- Engine Controls - OnStar(R) System Inoperative
- A/T - DTC P0756 Diagnostic Tips
- Engine Controls - Revised DTC P0336 Diagnostics
- Cooling System - MIL ON/DTC P0526 Set
- Engine - Gasket Sealant Usage
- Engine - Oil Consumption Usage Testing/Reporting
- Engine - New In-Vehicle Cylinder Head Service Procedure
- Engine - In Vehicle Cylinder Head Service Procedure
- Engine - Head Bolt/Main Cap Broken Bolt Extraction
- Cooling System - Dex-Cool(R) Coolant Dye
- Starting/Charging - Jump Starting Precautions
- Cooling System - DEX-COOL(R) Coolant Dye Information
- Tires - OE Tire Driving Characteristics
- Air Filter - SES Lamp ON/Driveability Issues
- All Technical Service Bulletins
- SB05-13-S003 Cancellation/Refer to SB08-13-S002
- Electrical - Multiple Intermittent Concerns
- Electrical - Inspect Connectors for Various Malfunctions
- A/C - Refrigerant System Sealer/Leak Detection
- A/C - Poor 2nd/3rd Row Seat Heater Performance
- A/C - Poor Performance in High Heat/Humidity Conditions
- A/C - Freon Leak and/or Low Charge
- A/C - Mode Actuator Cam Gear Alignment
- A/C - Intermittent Insufficient Cooling When Hot
- Drivetrain - Driveline 'Clunk' Explanation
- Engine Controls - Engine Ticking Noise at Idle
- Cooling System - Fan Contacts Shroud
- Battery - Parasitic Drain Information
- Starting System - No Crank/No Start/Security Lamp ON/OFF
- Electrical - Intermittent No Crank/No Start Condition
- Instruments - DIC Actual Vs. Perceived Fuel Economy
- Ignition System - SES Lamp ON/DTC P0300 Set/Misfire
- A/C - Suction Line Screen Kit Recommendations
- A/C - Blower Motor Inoperative/Won't Shut OFF
- Steering - Moan/Vibration/Shudder
- A/C - Revised Mode Actuator Replacement Procedure
- A/T/Suspension - Intermittent Rumbling/Booming Noise
- Wheels/Tires - Wheel Weight Usage Precautions
- Suspension - Clunk/Pop/Rattle/Loose Lumber Noise
- Body - Popping Noise When Rolling Up Front Door Window
- Body - Water Leaks Onto Front Carpet
- Driveline - Ping/Pop/Click From Propeller Shaft
- A/T - Rattle Noise Coming From Under Vehicle
- A/T - Rattle Noise From Under the Vehicle
- A/T - SES Lamp ON/DTC P0757/Slipping/Poor Performance
- A/T - Torque Converter Replacement Guidelines
- Fuel System - Multiple Driveability Symptoms
- Engine Controls - ECM Reprogramming Recommendations
- Steering - Steering Column Squeak/Rubbing Noise
- Steering - Hiss/Rush Noise From Steering Column
- Brakes - Revised Rear Caliper Mounting Bolt Torque
- Brakes - Revised Front Caliper Mounting Bolt Torque
- Brakes - Rear Caliper Mounting Bolt Torque Revision
- Battery - Discharges After Ignition Switch Replacement
- Battery - Intermittent Dead Battery
- Ignition -MIL ON/A/T Stuck in 3rd Gear/DTC's Set
- A/T - Stuck In 2nd or 3rd Gear/MIL ON/Inst. Panel Inop.
- Engine Controls/Emissions - Hesitation/A/T Slipping
- Engine Controls - Higher Than Normal Engine Temperature
- Engine Controls - SES Lamp ON/DTC's P0133 or P0172
- Engine - Hard Starting After Filling Fuel Tank
- Emissions - Misfire DTC's/Catalytic Converter Damage
- Body - Mirror Actuator Replacement
- Audio System - XM Satellite Radio(R) Information
- Lighting - Headlamps Flicker or Dim While Driving
- Lighting - Turn Signals/Flasher Stuck ON
- Recall 05V198000: Flasher Module Replacement
- Recall - Wiper Motor/Module Defect
- A/C - Rear Heater/A/C Line Replacement
- Steering - Revised Steering Wheel Replacement
- Recall - Theft Protection Non-Compliance
- Recall - FMVS 114 Theft Protection Non-Compliance
- Onstar(R) - Red LED/DTC B2470/Unable To Connect
- Onstar(R) - Generation 5 and 6 Logic Lock
- OnStar(R) - Changing Default Language
- OnStar(R) - Programming for Canadian French Recognition
- Air Bag System - Proper Diagnosis and Service
- Starting - No Crank/No Start/Theft Deterrent
- Emissions - OBDII I/M Readiness Testing
- Emissions - DTC P0440/P0455 or P0442 Diagnostics
- Exhaust System - Sulfur/Rotten Egg Smell
- Engine Controls - DTC P2135 Service Manual Revision
- Engine Controls - Lack Of Power/TCC Engaged by 20mph
- A/T Controls - P0894/P1870 Diagnostics
- A/T Controls - DTC P0756 Diagnostic Tips
- Body - Rattling Sound From Hood
- Body - Liftgate Glass Unlatches on Bumpy Roads
- Body - Doors Are Hard To Close
- Wipers/Washers - Will Not Turn Off, Other Concerns
- Recall - Rear Side Door Latch Corrosion
- Body - Liftgate/Glass Hard To Open/CHMSL Hits Roof
- Restraints - Seat Belt Retractor Won't Release
- Recall 03V269000: Child Restraint Non-Compliance
- Recall - Child Restraint Anchorage Non-Compliance
- Recall - Child Restraint Information Non-Compliance
- Instruments - Outside Rear View Mirror Vibration
- A/T - Shift Stabilization Mode Explanation
- A/T - Delayed Shift Engagement Diagnostic Aid
- A/T - 4L30-E - Removal/Replacement Precautions
- Audio System - Poor Reception/Station Drifts
- Audio System - CD Player Skips/Inoperative/Sluggish
- Keyless Entry System - Inoperative
- A/T - Fluid Requirements
- A/C - Programmable Control Module Identification
- Cruise Control - Disengages After Accelerating
- Keyless Entry System - Operational Characteristics
- Remote Keyless Entry (RKE) - Operational Characteristics
- Audio System - Error Codes Displayed
- Lighting - Center Mounted Stop Lamp Applique Loose
- A/T - Shift Lock Control Function Explanation
- A/C - Intermittently Inoperative/Blows Warm Air
- Keys - Code Cutter Applications
- A/T - 4L60E Harsh 1 - 2 Upshift
- A/T - 4L60-E Harsh 1-2 Upshift
- Recall 04V061000: Windshield Wiper System Malfunctions
- Exhaust System - Rattle/Popping Sound
- Body - Revised Liftgate Lock Cylinder Replacement
- A/T - Cracked/Broken Case Diagnosis
- A/C - Poor Performance
- Body - Rattle From Under The Hood
- Recall - Flasher Relay Module Replacement
- Fuel System - Pump Nozzle Shuts OFF/Tank Slow to Fill
- Body - Door Latch Freezing in Cold Temperatures
- A/C - Musty Odors On Hot/Humid Days
- Power Steering - Tips When Pump Replacement Necessary
- Ignition System - MIL ON/Misfire DTC's/Rough Idle
- Suspension - Revised Shock Module Replacement
- Tires - Proper Inflation Pressure Information
- Lighting - Headlamp Fluctuating/Flickering Explanation
- Body - Popping/Creaking Noise From The C-Pillar Area
- Electrical - MIL ON/DTC's P0480/P0526/P1481/P1484
- A/T - Slipping/MIL ON/DTC P0757/Poor Performance
- Body - Poor Liftgate or Liftgate Glass Fit/Glass Broken
- Body - Distortion On Outside of Vehicle Glass Surfaces
- Body - Right Rear Door Glass Binding
- A/T - Shift Lock Control Function
- Instruments - Noise Coming From Instrument Cluster
- Fuel System - Top Tier Detergent Gasoline Information
- Paint - Paint Code Information
- A/C - Contaminated R134A Refrigerant Precautions
- Starting/Charging - Correct Jump Starting Procedure
- Electrical - MIL ON/DTC's P0480/P0526/P1481 Set
- Steering - Steering Gear Stub Shaft Bearing Kit
- Engine - Cylinder Head Bolt/Main Bolt Extraction
- Engine - HVLA/Rocker Arm Removal Tool
- A/T - Oil Cooler Flush Procedure
- Fuel System - Hard Start/MIL ON/DTC's Set/Misfire
- Charging System - Operational Information
- Ignition System - Runs Rough/Misfire DTC's When Wet
- Lighting - PRNDL Display Reduced Visibility
- Engine - Oil Usage Testing and Reporting
- A/T - 2-3 or 3-2 Shift Clunk Information
- Body - Bumps Or Rust Colored Spots In Paint
- Body - Doors are Hard to Close
- A/C - SAE J2788 Refrigerant Recovery Standard
- Engine - GM Liquid Gasket/Engine Sealants
- Engine - In Vehicle Cylinder Head Service Procedures
- Tires - Original Equipment Tire Characteristics
- Fuel System - MIL ON/DTC's Set/ Driveability Issues
- Brakes - ABS Lamp ON/DTC's C0265/C0201/U1041 Set
- Campaign - Fuel Tank Inlet Check Valve Fracture
- A/C - Rear Window Defroster Grid Repair Information
- A/C - Preferred Rear Window Defroster Grid Repair Method
- Ignition - Can't Remove Key From Ignition Lock
- Body - Center Mounted Stop Lamp Applique loose
- Wipers/Washers - Poor Cleaning Performance
- Engine - GM Engine Sealant Usage
- A/C - Blower Motor Inoperative/Won't Shut OFF When Cold
- Fuel System - MIL ON/Multiple DTC's Set
- A/C - Dual Zone A/C Battery Draw Information
- OnStar(R) - Incorrect GPS Position During OnStar(R) Call
- OnStar(R) - Re-Establishing Communications
- Instruments - Erratic Speedometer Operation/Needle Shake
- Body - Metal Panel Corrosion Protection
- Lighting - Ext. Lamp Condensation/Replacement Guideline
- A/T - Harsh 1-2 Shift/DTC's P0741/P0756/P0894
- Instruments - Door Mirror Information
- Cooling System - DEX-COOL(R) Coolant Leak Detection Dye
- Electrical - Terminal Probe Test Kit Information
- Fuel System - Fuel Mileage Do's and Don'ts
- Body - Rear License Pocket Perimeter Gasket Loose
- Steering - Power Steering Pump Replacement Tips
- A/T - Cooler Line Fitting Information
- A/T - DTC P0894/P1870 Diagnostic Information
- OnStar(R) - Generation 5 to Generation 6 Upgrade
- Body - Distortion In Outer Surface Of Vehicle Glass
- Campaign - OnStar(R) Analog System Deactivation