Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Aspirator Assembly Installation
- A/C Blower Motor - Noisy
- Radio - Failure
- A/C Control Panel - Malfunctions
- Power Steering - Lack of Power Assistance
- Fuel Pump - Noise/Chattering/Engine Stalling
- Ride Level Struts - Stay at Maximum Height
- Ride Leveling Struts - Faulty Operation
- Install Valve Guide Seals
- Tires - Vibrations, Flat Spotting
- Door - Front Inner Waist Seal Wind Noise
- Dashboard Area - Knocking Noise at Idle
- Fuel Tank - Filler Cap Area Filled with Water
- Engine - Poor Running in Wet or Hot Weather Conditions
- Power Antenna Mast - Poor Operation
- Passive Restraint - Motor Winch Lock Up
- CD Player - Skip
- Door Handle - Breakage/Loss of Adjustment
- Door Cable Clip - Revised
- Door Mounted Mirrors - Wind Noise
- Windshield Wiper - Smearing
- Hydraulic Braking System - Tip
- A/T - Internal Failure at High Engine Speeds in P or N
- Engine - Stalls At Idle
- Climate Control Panel Assembly - Vibrations
- High Compression Engines - Pinging
- Rear Subframe - Knocking Noise
- Rear Suspension - Knock or Sag
- Door Flap Handle - Broken
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- 86103 - 11/01/91
- 86-178 - 05/01/97
- 8238 - 07/01/94
- 82-39 - 01/01/96
- 7678 - 09/01/92
- 7639 - 02/01/94
- 6410 - 01/01/93
- 605 - 05/01/95
- 3-152 - 12/01/96
- 1228 - 02/01/92
- Climate Control - Panel Assembly Vibration
- AC Control Panel - Intermittant Operation
- A/C Blower Motors - Noisy
- Power Steering - Lack of Power from A Cold Start
- Engine Controls - Removing Seized O2 Sensors
- Cylinder Head Bolts - Revisied Torque Specification
- Cylinder Head/Gasket - Inspection and Repair Procedures
- Cylinder Head Bolts - Reuse Twice During Repair
- Engine - Oil Leak at Generator Bracket Bolts
- Front Suspension - Vehicle Pulls to One Side
- Brake Fluid - Replace Every Two Years
- Engine Performance - Poor Running In Wet Conditions
- All Technical Service Bulletins
- A/C - Aspirator Assembly Installation
- 669R - 03/01/90
- 128 - 02/01/88
- Tool - Power Diagnotic Kit Components Available
- Closed Service Actions - No Longer Warrantied
- PDU - Software Issue PDU1025
- VIN and Certification Plates/Labels - Location/Replace
- Vehicle - Green Tibbe Key Problems
- Hydraulic System - Operation and Component Functions
- Towing Strap - Provided for Emergency Service
- Accumulator Switches - Unnecessary Replacement
- Tools - Introduction of Tool Board Overlay Kit
- Service Literature - Availability
- Vehicle - System/Component Revisions
- JDS - Introduction of 4050 Subsection, Supplement Pages
- Vehicle - Product Update #8
- Vehicle - Product Update #6
- Wiring Diagrams - Correct Source Information
- VCM - Operation Has Been Revised
- A Post Fuse Box - Increased In Size
- VIN and Certification Labels - Replacement
- Passenger Side Relay Mounting Plate - Revised
- A/C Blower Motor - Noisy
- Radio - Failure
- A/C Drain Case - Sealing Modification
- A/C Condenser - Revised
- Climate Control System Instability
- R134a Retrofit Kits - Available
- Center Fascia Vent Vacuum Actuator - Conversion
- R-134a Retrofit Kits - Available
- A/C Control Panel - Intermittently Inoperative
- AC Control Panel - Diagnostic Procedure
- A/C Control Panel - Malfunctions
- Power Steering - Lack of Power Assistance
- Tools - P/S Pump Drive Dog Removing and Replacing
- Steering Rack - Torque Setting Manual Revision
- PDU - Vibration Analyzer
- Engine - Nuts and Bolts Usage Information
- Cooling System - Antifreeze Leaks
- Cooling System - Preventing Antifreeze Leaks
- Batteries - Maintenance and Testing
- Battery Isolation Switch Kit - Installation and Use
- Battery - Specification Card
- Fuel Pump - Noise/Chattering/Engine Stalling
- Ignition System - Spark Plug Corona Stain
- Strut - Procedure For Bleeding
- Tool - Rear Strut Valve Block, Relief Vavle R and R
- Ride Leveling Strut - Replacement Information
- Ride Level Struts - Stay at Maximum Height
- Ride Leveling Struts - Faulty Operation
- Rear Struts - Installation Procedure
- Tool - Proper Use of Tool JD15 For Rear Hub and Spacer
- Tool - JD189 Distributor Body/Rotor Arm Set Position
- Cylinder Head Rear Cover - Coolant/Oil Leaks
- Generator Bracket Bolts - Leaking Oil
- Engine Oil Sump - Install to Prevent Drive Plate Cracks
- Install Valve Guide Seals
- A/C Receiver Dryer - Service Precautions
- Upper Chain Guide Bolts - Apply Locking Compound
- Front Dampers - Individual/Pair Replacement
- Rear Shock Absorbers Leaking
- Hydraulic System - Testing w/Power Hydraulic Tester
- Wheel Alignment - Tire Wear/Handling Problems
- Tires - Vibrations, Flat Spotting
- Tires - Pirelli P5 Replaced by P4000 Super Touring Tire
- Infra Red Locking System - Check
- Infra Red Locking - Description
- Door Sill Locking Button Bezel - Revised
- Door - Front Inner Waist Seal Wind Noise
- A/T - Front Pump/Intermediate Plate Failure
- VCM - Feedback Fueling Fault Code Changes
- Front Hub End Float - New Specification and Adjustment
- Distributor Cap - Revised
- Dashboard Area - Knocking Noise at Idle
- Fuel Tank - Filler Cap Area Filled with Water
- Throttle Valve - Adjustment Guideline
- Engine - Poor Running in Wet or Hot Weather Conditions
- Antenna Mast - Cleaning and Replacement
- Power Antenna Mast - Poor Operation
- Cruise Control - Test For Revised System
- Revised Cruise Control Features
- Radio - Reception Information
- Passive Restraint - Motor Winch Lock Up
- Passive Restraint Emergency - Anchor Adaptor Available
- Main Bearing Cap Bolts - Reuse Twice During Repair
- Oil Pressure Transmitter - Replacement Tips
- Cylinder Head Casting, Gasket - Revised
- Cylinder Head Gasket Edge - Coolant Seepage
- ABS Combined Pressure Warning Switch - Replacement
- Brake Accumulator - Individual Component Replacement
- Hydraulic System - Pressure Test Revised
- Low Brake Pressure - Diagnosing Warning On the VCM
- Recall 90V024000: Possible Loss of Brake Fluid
- Hydraulic System - Operation, Component Functions
- Paint - Scratches, Swirl Marks, Other Surface Damage
- CD Changer - Improper Operation and Diagnostic Procedure
- CD Player - Skip
- Fuel Tank Breather System - Modified
- Check Engine Light - Reporting and Erasing DTCs
- Tool - Fuel Injection Tester
- JDS - Software Reference Guide
- Engine Management System - Revised
- Washer Additive Quantities
- Door Handle - Breakage/Loss of Adjustment
- Door Cable Clip - Revised
- Door Mounted Mirrors - Wind Noise
- Windshield Wiper - Smearing
- Windshield - Replacement Precautions
- Recall 90V023000: Power Brake Hydraulic Hose
- Hydraulic Braking System - Tip
- A/T - ZF and GM 400 Repair Reference
- A/T - Internal Failure at High Engine Speeds in P or N
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Alternator Drive Belt - Tension Adjustment
- Engine - Stalls At Idle
- Climate Control Panel Assembly - Vibrations
- Oil Pan Drain Plug - Revised Torque Specification
- Fuse - Electrical Chart
- Electrical Fuse - Information
- Fuses - For Auxiliary Component Installation
- A/C ECU, Water Temp Switch - Matched Pairs ID
- High Compression Engines - Pinging
- Suspension - Alignment Specifications
- Driveline - Vibration Diagnostics and Repair
- Convertible Top/Interior Trim - Cleaning Recommendations
- Passive Restraint System - Description
- Seat Belt System - Functional, Component Tests
- Overview
- Functional Test
- Component Tests
- Overview
- Test 1 - Rear Dock Switch Open Circuit
- Test 2 - Rear Dock Switch Short Circuit
- Test 3 - Front Dock Switch Open Circuit
- Test 4 - Front Dock Switch Short Circuit
- Test 5 - Belt Proximity Switch Open Circuit
- Test 6 - Belt Proximity Switch Short Circuit
- Test 7 - Power Supplies
- Test 8 - Motor Feeds
- Test 9 - Weight Switch Open Circuit
- Test 10 - Door Input Open Circuit
- Test 11 - Door Input Short Circuit
- Test 12 - Ignition Input Open Circuit
- Test 13 - Ignition Input Short Circuit
- Test 14 - Inertia Switch Input Open Circuit
- Test 15 - Inertia Switch Input Short Circuit
- Test 16 - Warning Output Open Circuit
- Test 17 - Warning Output Short Circuit
- Test 19 - Warning Lamp Output Short Circuit
- Test 20 - Audible Warning Output Open Circuit
- Test 21 - Audible Warning Output Short Circuit
- Connector Description
- Passive Belt - llegal to Disconnect
- Motorized Automatic Diagonal Seat Belts
- Recall 93V179000: Passive Restraint System Defect
- Wood Veneer Panels - Repair Process
- Wood Veneer Repair Program
- Interior Trim - KRYTOX(R) Liquid Applications
- Glass - Bonding Procedures and Materials
- Brake Fluid - Replacement Schedule
- Rear Subframe - Knocking Noise
- Solenoid Valve Block - Component Replacement
- Ride Height Sensor - New Modification Procedure
- Rear Suspension - Knock or Sag
- Ride/Level Control - Misdiagnosis of Faults
- Engine - Conditions for Re-Using Cylinder Head Bolts
- Door Flap Handle - Broken
- Blue `Hella' Relay - Diagnosis
- Recall - Power Brakes
- Interior - Approved Cleaning Products
- Body - Windshield Damage Diagnostic Guide
- Engine Controls - Removal of Seized Oxygen (O2) Sensors