Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Oil Pressure Gauge - Reads Zero/Needle Flickers
- Air Conditioning - Blower Motor Noise
- Steering - Upper Column Cowl - Rattles/Squeaks
- Engine - Oil Leaks
- Batteries - Discharge Due to Frequent Short Trips
- Rear Brake Pad - Premature Wear Within 3000 miles
- Tires - Vibrations, Flat Spotting
- Hood Gas Strut - Poor Support When Fully Open
- ECU Vacuum Pipe - Knocking Noise
- A/T - Poor Shift Quality
- Power Antenna Mast - Poor Operation
- Radio - Noise Interference On the AM Band
- CD Player - Skip
- Convertible Top - H and E, Premature Fabric Wear
- Windshield Wiper - Smearing
- Trip Computer - Erratic Fuel Mileage Readings
- Rear Subframe - Knocking Noise
- A/T - Fluid Leaks
- A/T - Leak Due to Blocked Vent Pipe
- Seals, Gaskets
- Superceded Bulletins
- 8811 - 02/01/91
- 86-178 - 05/01/97
- 8238 - 07/01/94
- 82-39 - 01/01/96
- 7640 - 08/01/92
- 7639 - 02/01/94
- 605 - 05/01/95
- 3-152 - 12/01/96
- 26-17 - 02/01/98
- Radio - AM Band Injector Noise
- Airbag - Deactivation Service Kits
- AC Control Panel - Intermittant Operation
- A/C Blower Motors - Noisy
- Engine Controls - Removing Seized O2 Sensors
- Front Suspension - Vehicle Pulls to One Side
- Brake Fluid - Replace Every Two Years
- Spark Plugs - Revised Specification
- Spark Plugs - Part Number Revised
- All Technical Service Bulletins
- 7671 - 10/01/91
- Tool - Power Diagnotic Kit Components Available
- Closed Service Actions - No Longer Warrantied
- PDU - Software Issue PDU1025
- VIN and Certification Plates/Labels - Location/Replace
- Vehicle - Reacquired Limited Warranty Coverage
- Vehicle - Green Tibbe Key Problems
- Vehicle - Maintenance Intervals and Service Times
- Tools - Introduction of Tool Board Overlay Kit
- Service Literature - Availability
- Emission - Parts Return Procedures
- Tools - Required
- JDS - User Guide Update
- Tools - Required List S34B
- Body Panels - Excess Wax Material Removal
- Wiring Diagrams - Correct Source Information
- VIN and Certification Labels - Replacement
- Campaign - Excessive Fuel Vapor Pressure
- Campaign - Excessive Fuel Tank Vapor Pressure
- Emissions - System Type Identification
- Fuel Level Gauge - Reads Empty
- Oil Pressure Gauge - Reads Zero/Needle Flickers
- Air Conditioning - Blower Motor Noise
- A/C Condensate Drains - Blocked
- R134a Retrofit Kits - Available
- Tool - Freon Recovery System
- R-134a Retrofit Kits - Available
- A/C Rotary Flaps - Sticking, Diagnosis and Repair
- Tool - Steering Rack Bushing Replacement
- Steering - Upper Column Cowl - Rattles/Squeaks
- PDU - Vibration Analyzer
- Engine - Oil Leaks
- PDU Software - Now Compatible With JTP 627/3
- Cooling System - Antifreeze Leaks
- Cooling System - Preventing Antifreeze Leaks
- Batteries - Maintenance and Testing
- Batteries - Maintenance and Testing Procedure
- Batteries - Discharge Due to Frequent Short Trips
- Battery - Specification Card
- Battery Frame - Modification
- Varta Battery - New Information
- Rear Brake Pad - Premature Wear Within 3000 miles
- No Start May Be Caused By Vacuum Signal Line
- Spark Plugs - Revised Part Number
- Ignition System - Spark Plug Corona Stain
- Sanden Compressor - Seal Repair Kit
- Engine - Correct Pistons and Liners Replacement
- Engine Crankcase - Sealing Oil Leaks
- Engine - Oil Sump Sandwich Plate Gasket Sealing
- New Oil Pump - Available
- Radiator - Damage By Incorrect Removal and Installation
- Piston Ring End Gap - Correction to Specification
- A/C Receiver Dryer - Service Precautions
- Perelli Snow Tires - Approved
- Pirelli Tires - Replaced with Goodyear
- Wheel Alignment - Tire Wear/Handling Problems
- Tires - Vibrations, Flat Spotting
- Tires - Pirelli P5 Replaced by P4000 Super Touring Tire
- Hood Gas Strut - Poor Support When Fully Open
- ECU Vacuum Pipe - Knocking Noise
- Front Hub End Float - New Specification and Adjustment
- Campaign - Replacement of Coil High Tension Leads
- Recall - Coil Wire Replacement
- Recall 92V009000: Fuel Injector Hose Deterioration
- Engine - To Prevent Hesitation
- Throttle Valve - Adjustment Guideline
- A/T - Poor Shift Quality
- Antenna Mast - Cleaning and Replacement
- Power Antenna Mast - Poor Operation
- Alpine AJ8700 Radio - Diagnostic Procedure
- Radio - Noise Interference On the AM Band
- Radio - Reception Information
- Airbag Modules - Not Interchangeable
- Oil Filter - Changing When Sandwich Plate Is Removed
- Oil Filter - Shorter Improved Clearance
- ABS Combined Pressure Warning Switch - Replacement
- Hydraulic System - Pressure Test Revised
- Front Suspension - Calculating Pull Index
- Paint Code - Information
- Paint - Quality Report Form
- CD Changer - Improper Operation and Diagnostic Procedure
- CD Player - Skip
- Airbags - Deactivation Service Kits
- Alarm System - Fault Diagnosis
- Recall - R351 Purge Kit installation
- Tool - Fuel Injection Tester
- JDS - Software Issue 4036 Electrical Systems
- PDU - New Software Update
- PDU - Software Update
- PDU - Software Updates
- Convertible Top - H and E, Premature Fabric Wear
- Windshield Wiper - Smearing
- Windshield - Replacement Precautions
- Front Fenders - Excess Metal, Removal Procedures
- Cooling System - Revised Engine Coolant
- Coolant Filler Cap - Relief Pressure Changed to 15 PSI
- A/T - 3L80/THM 400 Center Support Bolt
- A/T - Torque Converter Identification
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - THM 400 Rear Band Adjustment Too Loose
- A/T - Rapid Converter Pump Bushing Wear
- A/T - Methods to Check for Restricted Exhaust
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - THM 400 Too Sensitive 3-2 Downshift
- A/T - No Upshift/Governor Contamination
- A/T - THM 400 No Reverse
- A/T - Checking Pressure Switches For Leaks
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - Button Fails to Operate Auto Changer
- Alternator Drive Belt - Tension Adjustment
- Trip Computer - Erratic Fuel Mileage Readings
- A/C ECU, Water Temp Switch - Matched Pairs ID
- Engine - Poor Operation Due to Poor Engine Ground
- Suspension - Alignment Specifications
- Convertible Top Pivot Pin - Revised
- Convertible Top - H and E, Proper Lowering Procedure
- Convertible Top Seal - Improved
- Convertible Top/Interior Trim - Cleaning Recommendations
- Wood Veneer Panels - Repair Process
- Wood Veneer Repair Program
- Interior Trim - KRYTOX(R) Liquid Applications
- Glass - Bonding Procedures and Materials
- Brake Fluid - Replacement Schedule
- Rear Subframe - Knocking Noise
- Engine - Conditions for Re-Using Cylinder Head Bolts
- ABS Valve Block - Replacement/Repair Kit
- Blue `Hella' Relay - Diagnosis
- A/T - Fluid Leaks
- A/T - Leak Due to Blocked Vent Pipe
- Tappet Block to Cylinder Head Joint - Sealant
- Brake - Diagnosis and Repair Procedure
- Tool - Fuel Pressure Tester Adapter
- Interior - Approved Cleaning Products
- Body - Windshield Damage Diagnostic Guide
- Engine Controls - Removal of Seized Oxygen (O2) Sensors