Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C Blower Motor - Noisy
- Steering - Hydraulic Noise When Turning the Wheel
- Power Steering - Lack of Power Assistance
- Steering - Upper Column Cowl - Rattles/Squeaks
- Engine - Poor Idle Quality
- Batteries - Discharge Due to Frequent Short Trips
- Battery - After Frequent Short Discharge
- Ride Level Struts - Stay at Maximum Height
- Ride Leveling Struts - Faulty Operation
- Install Valve Guide Seals
- Cooling Fans - Inoperative or Run with Key Off
- Tires - Vibrations, Flat Spotting
- Door - Front Inner Waist Seal Wind Noise
- Engine - Momentary Power Loss or Stalling
- Fuel Tank - Filler Cap Area Filled with Water
- Engine - Poor Running in Wet or Hot Weather Conditions
- MIL ON - A/T in Limp Home Mode
- A/T - Harsh Upshifts, at 50 mph Under Light Throttle
- Power Antenna Mast - Poor Operation
- Passive Restraint - Motor Winch Lock Up
- Front Seat Belt Height Adjuster - Rattles
- Radio Bass Speaker - Poor Operation
- Windshield Wiper - Judder/Noise
- Windshield Wiper - Smearing
- A/T - Stalls Engine When Engaging R or D
- A/T - Internal Failure at High Engine Speeds in P or N
- A/T - Harsh 3 to 4 Upshifts or Slip/Judder Engaging R
- Engine - Rough Idle In Drive
- Engine - Stalls At Idle
- Cruise Control - Set Speed Varies or Is Delayed
- MIL ON - A/T in Limp Home Mode After Rain/Car Wash
- Underscuttle - Mounting Revision
- Rear Subframe - Knocking Noise
- Diffential Housing - 4 Bolt Axle Revised Procedure
- Factory Modifications
- Labor/Parts Updates
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- 86-178 - 05/01/97
- 82-39 - 01/01/96
- 7678 - 09/01/92
- 7665 - 04/01/91
- 7640 - 08/01/92
- 7639 - 02/01/94
- 6410 - 01/01/93
- 605 - 05/01/95
- 4427 - 10/01/94
- 3-152 - 12/01/96
- 269 - 04/01/93
- 2611 - 08/01/93
- 26-17 - 02/01/98
- Not In the System
- Airbag - Deactivation Service Kits
- AC Control Panel - Intermittant Operation
- A/C Blower Motors - Noisy
- Power Steering - Lack of Power from A Cold Start
- Battery - Discharge Due to Frequent Short Trips
- A/T - Shift Quality
- Engine Controls - Removing Seized O2 Sensors
- Cylinder Head Erosion - Inspection Procedure
- Cylinder Head/Gasket - Inspection and Repair Procedures
- Cylinder Head Bolts - Reuse Twice During Repair
- Engine - Oil Leak at Generator Bracket Bolts
- Front Suspension - Vehicle Pulls to One Side
- Brake Fluid - Replace Every Two Years
- Engine Performance - Poor Running In Wet Conditions
- Engine - Rough Idle
- All Technical Service Bulletins
- Closed Service Actions - No Longer Warrantied
- PDU - Software Issue PDU1025
- VIN and Certification Plates/Labels - Location/Replace
- Vehicle - Reacquired Limited Warranty Coverage
- Vehicle - Green Tibbe Key Problems
- Service Parts and Adjustment Exclusion - Warranty
- Service Manual - Supplement Availability
- Service Literature - Availability
- Parts - Return Procedures
- Wiring Diagrams - Correct Source Information
- Electrical Harness - Interference Results in Failures
- Alpine Radio - Security Code Entry
- Tools - Additonal Required
- A/C Blower Motor - Noisy
- Tool - A/C Compressor Seal Remove/Replace
- A/C Defrost Flap - Interference Distortion of Duct
- R134a Retrofit Kits - Available
- R-134a Retrofit Kits - Available
- A/C Rotary Flaps - Sticking, Diagnosis and Repair
- Steering - Hydraulic Noise When Turning the Wheel
- Power Steering - Lack of Power Assistance
- Tools - P/S Pump Drive Dog Removing and Replacing
- Steering - Upper Column Cowl - Rattles/Squeaks
- PDU - Vibration Analyzer
- Engine - Poor Idle Quality
- PDU Software - Now Compatible With JTP 627/3
- Cooling System - Antifreeze Leaks
- Cooling System - Preventing Antifreeze Leaks
- Batteries - Maintenance and Testing Procedure
- Batteries - Discharge Due to Frequent Short Trips
- Battery - After Frequent Short Discharge
- Ignition System - Spark Plug Corona Stain
- Sanden Compressor - Seal Repair Kit
- Ride Leveling Strut - Replacement Information
- Ride Level Struts - Stay at Maximum Height
- Ride Leveling Struts - Faulty Operation
- Rear Struts - Installation Procedure
- Tool - Proper Use of Tool JD15 For Rear Hub and Spacer
- Tool - JD189 Distributor Body/Rotor Arm Set Position
- Cylinder Head Rear Cover - Coolant/Oil Leaks
- Generator Bracket Bolts - Leaking Oil
- Engine Oil Sump - Install to Prevent Drive Plate Cracks
- Oil Pump - Use Loctite 501 to Seal Backing Plate
- Install Valve Guide Seals
- Water Pump and Center Gasket - Revised
- Water Pump Revised
- Cooling Fans - Inoperative or Run with Key Off
- Tool - Coolant System Pressure Test Adaptor
- A/C Receiver Dryer - Service Precautions
- Upper Chain Guide Bolts - Apply Locking Compound
- Engine Oil Cooler - Deleted
- Front Dampers - Individual/Pair Replacement
- Rear Shock Absorbers Leaking
- Tires - Vibrations, Flat Spotting
- Tires - Pirelli P5 Replaced by P4000 Super Touring Tire
- Door - Front Inner Waist Seal Wind Noise
- Fuel Injector - Identification
- DTC 44 - Diagnosing Oxygen Sensor
- Engine - Momentary Power Loss or Stalling
- Front Hub End Float - New Specification and Adjustment
- Distributor Cap - Revised
- Fuel Tank - Filler Cap Area Filled with Water
- Fuel Tank - Replacement
- Throttle Valve - Adjustment Guideline
- Engine - Poor Running in Wet or Hot Weather Conditions
- EMS - Code 89 Purge Valve Circuit Diagram Correction
- MIL ON - A/T in Limp Home Mode
- A/T - Harsh Upshifts, at 50 mph Under Light Throttle
- Antenna Mast - Cleaning and Replacement
- Power Antenna Mast - Poor Operation
- JDS - Security Control Module Diagnosis
- Radio - Reception Information
- Passive Restraint - Motor Winch Lock Up
- Front Seat Belt Height Adjuster - Rattles
- Crankshaft Bearings - Revised
- Main Bearing Cap Bolts - Reuse Twice During Repair
- Cylinder Head Casting, Gasket - Revised
- Cylinder Head Gasket Edge - Coolant Seepage
- Hydraulic System - Pressure Test Revised
- Paint - Code Information
- Paint - Quality Report Form
- CD Changer - Improper Operation and Diagnostic Procedure
- Bulb - Diagnose Failure Warning Light Illuminated
- Check Engine Light - Reporting and Erasing DTCs
- PDU - New Software Update
- PDU - Software Update
- PDU - Software Updates
- PDU - Software 1000 Error Requesting Start Engine
- Radio Bass Speaker - Poor Operation
- Windshield Wiper - Judder/Noise
- Windshield Wiper - Streaking/Smearing
- Door Mirror Chrome Cover - Repair Procedure
- Windshield Wiper - Smearing
- Windshield - Replacement Precautions
- Cooling System - Revised Engine Coolant
- Coolant Header Tank Cap Seal - Leak
- A/T - Stalls Engine When Engaging R or D
- A/T - Internal Failure at High Engine Speeds in P or N
- A/T - Harsh 3 to 4 Upshifts or Slip/Judder Engaging R
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - Button Fails to Operate Auto Changer
- Engine - Rough Idle In Drive
- Alternator Drive Belt - Tension Adjustment
- Engine - Stalls At Idle
- Cruise Control - Set Speed Varies or Is Delayed
- Fuel Filler Cap - Breakage
- Oil Pan Drain Plug - Revised Torque Specification
- A/C ECU, Water Temp Switch - Matched Pairs ID
- Tire Pressure - Correct Pressure For Maximum Comfort
- Convertible Top/Interior Trim - Cleaning Recommendations
- Passive Belt - llegal to Disconnect
- Motorized Automatic Diagonal Seat Belts
- Recall 93V179000: Passive Restraint System Defect
- MIL ON - A/T in Limp Home Mode After Rain/Car Wash
- Tool - Passenger Side Underdash Panel Removal
- Underscuttle - Mounting Revision
- Wood Veneer Repair Program
- Interior Trim - KRYTOX(R) Liquid Applications
- Glass - Bonding Procedures and Materials
- Radio - Tape Head Cleaning
- Brake Fluid - Replacement Schedule
- Rear Subframe - Knocking Noise
- Engine - Conditions for Re-Using Cylinder Head Bolts
- Hydraulic System - Valve Block Leak
- ABS Valve Block - Replacement/Repair Kit
- Blue `Hella' Relay - Diagnosis
- Brake - Diagnosis and Repair Procedure
- Up Solenoid Valve - Deleted
- Tool - Fuel Pressure Tester Adapter
- Diffential Housing - 4 Bolt Axle Revised Procedure
- Interior - Approved Cleaning Products
- Body - Windshield Damage Diagnostic Guide
- Engine Controls - Removal of Seized Oxygen (O2) Sensors