Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Fuel Gauge - Erratic Readings
- Oil Pressure Gauge - Reads Zero/Needle Flickers
- Steering - Upper Column Cowl - Rattles/Squeaks
- Engine - Oil Leaks
- Batteries - Discharge Due to Frequent Short Trips
- Engine - Intermittent No Start
- Fuel - Low Pressure, Power Loss W/Tank Less Than 3/4
- Rear Brake Pad - Premature Wear Within 3000 miles
- Cooling Fans - Inoperative or Run with Key Off
- Tires - Vibrations, Flat Spotting
- Hood Gas Strut - Poor Support When Fully Open
- Seat Back Latch - Rattle
- ECU Vacuum Pipe - Knocking Noise
- Starter Motor - Will Not Engage
- Power Antenna Mast - Poor Operation
- Window Motor - Sticking/Binding
- Radio - Noise Interference On the AM Band
- Oil Pressure Gauge - Reads Low at Idle
- Coolant Temperature Gauge - High Readings
- Alarm System - Sounds Intermittently
- Windshield - Noise/Creaks
- Windshield Wiper - Smearing
- D/E Post Upper Quarter Trim Pad - Loose
- Trip Computer - Erratic Fuel Mileage Readings
- Engine Harness - Damage Due to Air Cleaner Interference
- Rear Subframe - Knocking Noise
- A/T - Fluid Leaks
- A/T - Leak Due to Blocked Vent Pipe
- Alarm System - Poor Transmitter Range
- Factory Modifications
- Seals, Gaskets
- Superceded Bulletins
- 86-178 - 05/01/97
- 82-39 - 01/01/96
- 7666 - 07/01/91
- 7640 - 08/01/92
- 7639 - 02/01/94
- 605 - 05/01/95
- 3-152 - 12/01/96
- 26-17 - 02/01/98
- Window - New Lift Motor
- Radio - AM Band Injector Noise
- Airbag - Deactivation Service Kits
- AC Control Panel - Intermittant Operation
- A/C Blower Motors - Noisy
- Engine Controls - Removing Seized O2 Sensors
- Front Suspension - Vehicle Pulls to One Side
- Brake Fluid - Replace Every Two Years
- Spark Plugs - Revised Specification
- Spark Plugs - Part Number Revised
- All Technical Service Bulletins
- Closed Service Actions - No Longer Warrantied
- PDU - Software Issue PDU1025
- VIN and Certification Plates/Labels - Location/Replace
- Vehicle - Reacquired Limited Warranty Coverage
- Vehicle - Green Tibbe Key Problems
- Vehicle - Maintenance Intervals and Service Times
- Service Parts and Adjustment Exclusion - Warranty
- Service Manual - Supplement Availability
- Service Literature - Availability
- Parts - Return Procedures
- Wiring Diagrams - Correct Source Information
- Alpine Radio - Security Code Entry
- Vehicle - Feature Changes
- Tools - Additonal Required
- Fuel Gauge - Erratic Readings
- Oil Pressure Gauge - Reads Zero/Needle Flickers
- Stop Light Failure Module - Revised Location
- JDS Software DBC 4045 - Error In A/C Test
- R134a Retrofit Kits - Available
- R-134a Retrofit Kits - Available
- A/C Rotary Flaps - Sticking, Diagnosis and Repair
- Steering - Upper Column Cowl - Rattles/Squeaks
- Power Assisted Steering - Diagnosis
- PDU - Vibration Analyzer
- Engine - Oil Leaks
- PDU Software - Now Compatible With JTP 627/3
- Cooling System - Antifreeze Leaks
- Cooling System - Preventing Antifreeze Leaks
- Batteries - Maintenance and Testing Procedure
- Batteries - Discharge Due to Frequent Short Trips
- Engine - Intermittent No Start
- Throttle Potentiometer - Initial Setting
- Fuel Pump Module - Improved
- Fuel - Low Pressure, Power Loss W/Tank Less Than 3/4
- Rear Brake Pad - Premature Wear Within 3000 miles
- Spark Plugs - Revised Part Number
- Ignition System - Spark Plug Corona Stain
- Sanden Compressor - Seal Repair Kit
- Recall - A/C Bracket Chafing Engine Wiring Harness
- Engine - Correct Pistons and Liners Replacement
- Engine Crankcase - Sealing Oil Leaks
- New Oil Pump - Available
- Cooling Fans - Inoperative or Run with Key Off
- Radiator - Damage By Incorrect Removal and Installation
- Piston Ring End Gap - Correction to Specification
- A/C Receiver Dryer - Service Precautions
- Engine Oil Cooler - Full Flow Introduced
- Wheel Alignment - Tire Wear/Handling Problems
- Tires - Vibrations, Flat Spotting
- Tires - Pirelli P5 Replaced by P4000 Super Touring Tire
- Hood Gas Strut - Poor Support When Fully Open
- Window - Lift Components Diagnosis and Repair Procedures
- Front Seat - Fore/AFT Motor Inoperative
- Seat Back Latch - Rattle
- ECU Vacuum Pipe - Knocking Noise
- Front Hub End Float - New Specification and Adjustment
- Starter Motor - Will Not Engage
- Throttle Valve - Adjustment Guideline
- Antenna Mast - Cleaning and Replacement
- Power Antenna Mast - Poor Operation
- Window Motor - Sticking/Binding
- JDS - Security Control Module Diagnosis
- Alpine AJ8700 Radio - Diagnostic Procedure
- Radio - Noise Interference On the AM Band
- Radio - Reception Information
- Airbag Modules - Not Interchangeable
- Oil Filter - Changing When Sandwich Plate Is Removed
- Oil Filter - Shorter Improved Clearance
- JDS - ISO Connector LI90, Wire Link Lead
- Oil Pressure Gauge - Reads Low at Idle
- Oil Pressure and Coolant Temperature - Low Readings
- Coolant Temperature Gauge - High Readings
- Hydraulic System - Pressure Test Revised
- Front Suspension - Calculating Pull Index
- Paint - Code Information
- Paint - Quality Report Form
- CD Changer - Improper Operation and Diagnostic Procedure
- Airbags - Deactivation Service Kits
- Alarm System - Sounds Intermittently
- MIL ON - DTCs 23,34,36,44 or 45 Air Injection
- Check Engine Light - Reporting and Erasing DTCs
- PDU - New Software Update
- PDU - Software Update
- PDU - Software Updates
- Windshield - Noise/Creaks
- Windshield Wiper - Smearing
- Windshield - Replacement Precautions
- Heated Rear Window - Inhibit Switch Deleted
- Cooling System - Revised Engine Coolant
- Coolant Filler Cap - Relief Pressure Changed to 15 PSI
- A/T - 3L80/THM 400 Center Support Bolt
- A/T - Torque Converter Identification
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - THM 400 Rear Band Adjustment Too Loose
- A/T - Rapid Converter Pump Bushing Wear
- A/T - Methods to Check for Restricted Exhaust
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - THM 400 Too Sensitive 3-2 Downshift
- A/T - No Upshift/Governor Contamination
- A/T - THM 400 No Reverse
- A/T - Checking Pressure Switches For Leaks
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - Button Fails to Operate Auto Changer
- Alternator Drive Belt - Tension Adjustment
- D/E Post Upper Quarter Trim Pad - Loose
- Trip Computer - Erratic Fuel Mileage Readings
- A/C ECU, Water Temp Switch - Matched Pairs ID
- Engine - Poor Operation Due to Poor Engine Ground
- Recall 91V155000: Engine Wiring Harness Chafing
- Engine Harness - Damage Due to Air Cleaner Interference
- Tool - Fuel Pressure Test Adaptor and Procedure
- Tire Pressure - Correct Pressure For Maximum Comfort
- Suspension - Alignment Specifications
- Convertible Top - H and E, Proper Lowering Procedure
- Convertible Top/Interior Trim - Cleaning Recommendations
- Wood Veneer Repair Program
- Interior Trim - KRYTOX(R) Liquid Applications
- Glass - Bonding Procedures and Materials
- Radio - Tape Head Cleaning
- Brake Fluid - Replacement Schedule
- Rear Subframe - Knocking Noise
- Engine - Conditions for Re-Using Cylinder Head Bolts
- ABS Valve Block - Replacement/Repair Kit
- Trip Computer - Removal Procedure
- Blue `Hella' Relay - Diagnosis
- A/T - Fluid Leaks
- A/T - Leak Due to Blocked Vent Pipe
- Alarm System - Poor Transmitter Range
- Tappet Block to Cylinder Head Joint - Sealant
- Brake - Diagnosis and Repair Procedure
- Tool - Fuel Pressure Tester Adapter
- Interior - Approved Cleaning Products
- Body - Windshield Damage Diagnostic Guide
- Engine Controls - Removal of Seized Oxygen (O2) Sensors