Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Fuel Gauge - Does Not Read Full
- Engine - Poor Idle Quality
- Cooling Fans - Run Continuously
- Ride Level Struts - Stay at Maximum Height
- Ride Leveling Struts - Faulty Operation
- Cooling Fans - Inoperative or Run with Key Off
- Tires - Vibrations, Flat Spotting
- Steering Wheel - Excessive Play, Knock When Turned
- Differential - Whine Noise At 45-50 MPH and 65-70 MPH
- Engine - Momentary Power Loss or Stalling
- Fuel Tank - Filler Cap Area Filled with Water
- Engine - Poor Running in Wet or Hot Weather Conditions
- MIL ON - A/T in Limp Home Mode
- Power Antenna Mast - Poor Operation
- Radio - Requires Frequent Recoding
- Front Seat Belt Height Adjuster - Rattles
- Security System Transmitter - Battery Drain
- Windshield Wiper - Judder/Noise
- Windshield Wiper - Smearing
- Cupholder - Broken
- A/T - Stalls Engine When Engaging R or D
- A/T - Internal Failure at High Engine Speeds in P or N
- A/T - Harsh 3 to 4 Upshifts or Slip/Judder Engaging R
- Engine - Rough Idle In Drive
- Engine - Stalls At Idle
- MIL ON - A/T in Limp Home Mode After Rain/Car Wash
- Rear Subframe - Knocking Noise
- A/T Gearshift Interlock - Locks in Park
- MIL ON - DTC 12 Changeover Relay and Link Lead
- Factory Modifications
- Labor/Parts Updates
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- 86-178 - 05/01/97
- 82-39 - 01/01/96
- 7640 - 08/01/92
- 70-28 - 04/01/98
- 6410 - 01/01/93
- 605 - 05/01/95
- 4427 - 10/01/94
- 3-152 - 12/01/96
- 269 - 04/01/93
- 2611 - 08/01/93
- 26-17 - 02/01/98
- 17-9 - 05/01/97
- MIL ON - DTC #12
- Alarm System Transmitter - Frequently Battery Drain
- Airbag - Deactivation Service Kits
- AC Control Panel - Intermittant Operation
- A/T - Gearshift Interlock
- A/T - Shift Quality
- Campaign - Gear Selector Locks In Park
- Campaign - Gearshift Selector Lever Locks In Park
- Engine Controls - Removing Seized O2 Sensors
- MIL ON - DTC 12 Install Changeover Relay, Link Lead
- Cylinder Head Erosion - Inspection Procedure
- Cylinder Head/Gasket - Inspection and Repair Procedures
- Cylinder Head Bolts - Reuse Twice During Repair
- Engine - Oil Leak at Generator Bracket Bolts
- A/C R134A - Use Butyl O Ring Seals
- Front Suspension - Vehicle Pulls to One Side
- Engine Performance - Poor Running In Wet Conditions
- Engine - Rough Idle
- All Technical Service Bulletins
- Service Actions - Perform During Next Service Interval
- Closed Service Actions - No Longer Warrantied
- PDU - Software Issue PDU1025
- VIN and Certification Plates/Labels - Location/Replace
- Vehicle - Reacquired Limited Warranty Coverage
- Vehicle - Green Tibbe Key Problems
- Enhancement Program - Service Action Procedure
- Paint and Wood Veneer - Fault codes
- Campaign - Sedan Enhancement Program
- Service Parts and Adjustment Exclusion - Warranty
- Fault Codes - Warranty Guidelines
- Software Issue DBC4070 - Newly Released
- Parts - Return Procedures
- Vehicle - New Model Year Changes
- Vehicle - Model Code Identification
- Fuel Gauge - Does Not Read Full
- R134 A/C System Connections - Revised Torque Specs
- A/C System - R134A Refrigerant Introduction
- A/C System - Inoperative Diagnostic Procedure
- A/C Vacuum Reservoir - Location
- R134 A/C System - O-Ring Specification
- R134a Retrofit Kits - Available
- R-134a Retrofit Kits - Available
- Tools - A/C System Leak Detection System
- Climate Control System - Pipe/Pressure Switch Location
- Tools - P/S Pump Drive Dog Removing and Replacing
- Steering Rack - Revised Version
- PDU - Vibration Analyzer
- Engine - Poor Idle Quality
- PDU Software - Now Compatible With JTP 627/3
- Cooling Fans - Run Continuously
- Idle Speed - Corrected JDS Adjustment Procedure
- Ignition System - Spark Plug Corona Stain
- Sanden Compressor - Seal Repair Kit
- Ride Leveling Strut - Replacement Information
- Ride Level Struts - Stay at Maximum Height
- Ride Leveling Struts - Faulty Operation
- Rear Struts - Installation Procedure
- Tool - Proper Use of Tool JD15 For Rear Hub and Spacer
- Tool - JD189 Distributor Body/Rotor Arm Set Position
- Cylinder Heads and Gaskets - Revised
- Generator Bracket Bolts - Leaking Oil
- Engine Oil Sump - Install to Prevent Drive Plate Cracks
- Oil Pump - Use Loctite 501 to Seal Backing Plate
- Water Pump and Center Gasket - Revised
- Water Pump Revised
- Cooling Fans - Inoperative or Run with Key Off
- Tool - Coolant System Pressure Test Adaptor
- A/C Receiver Dryer - Service Precautions
- Upper Chain Guide Bolts - Apply Locking Compound
- Engine Oil Cooler - Deleted
- Rear Shock Absorbers Leaking
- Tires - Vibrations, Flat Spotting
- Seat Lumbar Pump - Circuit Diagrams Correction
- Seat Track Assembly - Servicing Guidlines
- Steering Wheel - Excessive Play, Knock When Turned
- Differential - Whine Noise At 45-50 MPH and 65-70 MPH
- Fuel Injector - Identification
- DTC 44 - Diagnosing Oxygen Sensor
- Engine - Momentary Power Loss or Stalling
- Fuel Tank - Filler Cap Area Filled with Water
- Fuel Tank - Replacement
- Throttle Valve - Adjustment Guideline
- Engine - Poor Running in Wet or Hot Weather Conditions
- MIL ON - A/T in Limp Home Mode
- Power Antenna Mast - Poor Operation
- JDS - Security Control Module Diagnosis
- Radio - Requires Frequent Recoding
- Front Seat Belt Height Adjuster - Rattles
- Crankshaft Bearings - Revised
- Main Bearing Cap Bolts - Reuse Twice During Repair
- Brake Pedal Switch - Parts Inventory Simplified
- Cylinder Head Casting, Gasket - Revised
- Hydraulic System - Pressure Test Revised
- Front Suspension - Calculating Pull Index
- Paint Code - Information
- Paint - Quality Report Form
- Airbags - Deactivation Service Kits
- Security System Transmitter - Battery Drain
- Air Injection Pump - Runs After Every Engine Start
- Check Engine Light - Reporting and Erasing DTCs
- PDU - New Software Update
- PDU - Software Update
- PDU - Software Updates
- PDU - Software 1000 Error Requesting Start Engine
- Windshield Wiper - Judder/Noise
- Windshield Wiper - Smearing
- Windshield - Replacement Precautions
- Cupholder - Broken
- Cooling System - Revised Engine Coolant
- Coolant Header Tank Cap Seal - Leak
- A/T - Gearshift Interlock Manual Override
- A/T - Stalls Engine When Engaging R or D
- A/T - Internal Failure at High Engine Speeds in P or N
- A/T - Harsh 3 to 4 Upshifts or Slip/Judder Engaging R
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - Button Fails to Operate Auto Changer
- Engine - Rough Idle In Drive
- Engine - Stalls At Idle
- Fuel Filler Cap - Breakage
- Oil Pan Drain Plug - Revised Torque Specification
- Dash Liner - Poor Fit and Appearance
- Recall - Intermittent AIR pump Clutch Operation
- Suspension - Alignment Specifications
- Convertible Top/Interior Trim - Cleaning Recommendations
- MIL ON - A/T in Limp Home Mode After Rain/Car Wash
- Wood Veneer Repair Program
- Interior Trim - KRYTOX(R) Liquid Applications
- Glass - Bonding Procedures and Materials
- Brake Fluid - Replacement Schedule
- Rear Subframe - Knocking Noise
- A/T Gearshift Interlock - Locks in Park
- Engine - Conditions for Re-Using Cylinder Head Bolts
- ABS Valve Block - Replacement/Repair Kit
- Blue `Hella' Relay - Diagnosis
- Security System Transmitter - Intermittent Operation
- Tool - Fuel Pressure Tester Adapter
- PAG Oil for R134a Systems
- Interior - Approved Cleaning Products
- Body - Windshield Damage Diagnostic Guide
- MIL ON - DTC 12 Changeover Relay and Link Lead
- Engine Controls - Removal of Seized Oxygen (O2) Sensors