Main Harness - Rerouting

NO. 86/03/94/US

DATE: 07/10/94

MODEL
Range Rover Discovery

AFFECTED VEHICLES
Left hand drive derivatives only -
Range Rover from VIN LH 647645 to LH 650335
Discovery from VIN LJ 081991 to LJ 090456

SUBJECT
Main Harness Routing-Left hand "A" Post

DETAIL

A small number of left hand drive vehicles may have been dispatched from Land Rover with the main harness incorrectly routed in the area of the left hand "A" post. The harness may have been routed in-board of the lower "A" post trim panel and in some cases in-board of the bonnet release cable. In either case it will be necessary to inspect and re-route the harness following the instructions listed in this bulletin.

ACTION REQUIRED

At the first opportunity, Pre-Delivery Inspection or 1000 mile service, check the routing of the harness in the left hand "A" post region and re-route as necessary.

PARTS INFORMATION

Not applicable

PROCEDURE

1. Open the left hand front door and check the routing of the harness in the footwell to ensure that it is located behind the lower "A" post trim panel.
2. If the harness is routed in front of the trim panel inspect for damage to the wiring and repair as necessary.





3. If the harness is routed in-board of the bonnet release cable, disconnect the bonnet release and reroute in-board of the harness. (Refer to illustration).
4. Re-route the main harness behind the lower "A" post trim, ensure there is sufficient clearance between the harness, clutch pedal and pedal return spring.

WARRANTY

Normal warranty policy and procedures apply.

COMP. CODE
7Y1C

SRO
Operation 2 Range Rover and Discovery:
86.70.89129 - 00.35 hour (inclusive of harness repair)
Operations 3 and 4 Range Rover and Discovery
86.70.89130 - Reposition harness 00.20 hour