Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Rear Air Conditioning Duct - Residue Accumulation
- Heater Plenum - Water Leaks to Interior
- ECM - DTC P0125 Set
- Front Brake - Squeal
- Valve Cover - Oil Leak
- Engine Oil Pan - Oil Leaks
- Engine - Oil Pan Bolt Leakage
- Engine - Oil Leaks From Rear of Cylinder Block
- Engine - Oil Leaks From Rear
- Exhaust Manifold/Header Pipe - Exhaust Leaks
- Drivetrain - Front Axle Swivel Seals Leaking
- Suspension - Vehicle Not Sitting Level
- Suspension - Vehicle Does Not Sit Level
- Wheels - Difficult to Remove
- Seat Lumbar Knob - Falls Off
- Rear Inward Facing Seats - Rattle
- Front Seats - Fore/AFT Movement
- Sunroof - Malfunction/Incomplete Operation
- Sunroof - Water Leak
- Front/Rear Sunroofs - Rattle Noise
- Sunroof - Water Leaks to The Interior
- Sunroof - Jams During Tilt Operation
- Body - Sunroof Water Leaks
- Driveline - Vibration/Noise at Low or High Speeds
- Transmission Mount - Vibration Noise
- A/T - Fluid Leaks From Torque Converter
- Clutch Slave Cylinder Heat Shield - Rattles
- ECM - MIL ON DTC P1317 Set
- Engine - Hard Starting When Cold
- Engine - Poor Starting in Cold Weather
- Front Hub Seal - Oil Leaks
- Battery - Dead/Fails to Maintain A Charge
- Underhood Fuse Box - Poor Connections/Driveability
- Electrical - Intermittent Electrical/No Start Problems
- Ignition System - Misfire at High Engine Speeds
- Ignition Module - Engine No Start/Poor Start
- Ignition System - Hard Starting
- Ignition Coil - Poor Connections
- Crankshaft Position Sensor - Loose
- CKP Sensor/Heat Shield - Revised Tightening Bolts
- Fuel System - Poor Throttle Response
- Rear Brake Light/Rear Defogger - Short Circuit
- Cruise Control - 'Set/Hold' Inoperative
- Radio - Noise With Ignition Switch in Position 1 or 2
- Passenger Seat Belt Stalk - Rattles
- Transmission Input Seal - Leaks Oil
- Starter - Engine No-Start Condition
- Fuel Gauge - Diagnostic Guidelines
- Oil Pressure Switch - Oil Leakage
- Speedometer - Noise Diagnosis
- Reverse Lights - Intermittant Operation
- Trailer Warning Light - Intermittent Operation
- A/C - Low Pressure Line Refrigerant Leaks
- Engine - Valve Cover Gasket Replacement
- Engine/Drivetrain - Vibration at 30 to 40 Mph
- Drivetrain - Difficult Differential Lock Selection
- Steering Wheel/Column Lock - Misaligned
- Steering Wheel -Misalignment
- Ignition Key Cylinder - Too Much Free Play
- Front Suspension - Bolts/Hardware Comes Loose
- Body - Vibration/Noise & Harshness
- Bulkhead - Water Leaks to Interior
- 'D' Post/Alpine Light - Water Leaks to Interior
- Body - Water Leaks To The Interior
- Security System Antenna - Reduced Range
- Emissions/Fuel Systems - Difficulty Filling Fuel Tank
- Central Locking System - Intermittent Locking
- Radio Speaker - Clicking/Cracking Noises
- Rear Subwoofer - Thump or Pop Noises
- Driver's Door - Rattles
- Rear Side Door - Windnoise At D Post
- Side Door - Water Retention
- Windshield - Water Leaks
- Windscreen Finisher A Post - Poor Fit
- Windscreen - Water Leaks/Windnoise
- Windshield/Dash - Creaking/Squeaking Noise
- Windshield - Water Leaks To The Interior
- Wipers-Washers - Rear Washer Nozzle Damaged/Broken
- Door Mirror - Wind Noise/Dust Intrusion
- Rear Bumper Filler Strip - Cracking
- Front Grille - Lower Corner Cracking
- Rear Bumper Lamp - Cracking
- Engine - No Start in Extreme Cold Conditions
- Radiator Bleed Hose - Deformation
- Engine - Intake Manifold Fluid Leaks
- Center Console - Creak/Squeal
- Steering System - Fluid Leaks
- Transfer Gearbox - Backlash/Clonk
- A/T - ZF Transmission/Multiple Shift Concerns
- M/T - Fluid Leaks
- M/T - Front Cover Oil Leaks
- Center Plate/Extension Housing - Oil Leak
- Engine - Excessive Noise/Vibration
- Ignition System - Hard Start/Rough Running/Misfire Codes
- Engine - Oil Leaks From Rear of Engine
- Oil Cooler Pipe - Oil Leaks
- Antitheft System - Intermittent Alarm Activation
- Rear Hub Seal - Oil Leaks
- Sill Button - Too Low/Difficult to Operate
- Rear Footwell Carpet - Poor Fit
- Rear Footwell Carpet - Loose Fit at Seat Plinth
- Carpet - Fits Poorly at Front Seats
- Drivers Heel Mat - Lifting/Loose
- Automatic Gear Selector - Graphic Film Torn
- Inside/Outside Door Handle - Intermittent Operation
- Speakers - Buzzing Noise From Front Tweeters
- Engine - Hesitation, OBD Fault 17/DTC P0121 Set
- Interior - Dash Pad Separation
- Radio - Interference & Poor AM Reception
- Keyless Entry - Remote Transmitter Button Splitting
- Headlamp Wash System - Filter
- Transfer Gearbox - Will Not Shift Out of Gear
- Transfer Gearbox - Whine
- A/C System - Water Leaks to Interior
- A/T Shift Lever - Locked/Will Not Move
- Transfer Case - Output Seal Leakage
- Body - Tailgate Rattles
- Power Take Off Cover Plate - Oil Leaks
- Ignition Timing - Poor Engine Performance
- Security System - Long Arming Light Indication
- Body - Sunroof Panel/Water Dam Separation
- Seat Base Access Panel - Rattles
- Front Seat Trim Cover - Loose/Rattles
- Differential Pinion Oil Seal - Leaks Oil
- Transfer Case - Input Seal Leakage
- Front Stub Axle Seal - Leaks Oil
- Rear Stub Axle Seal - Leaks Oil
- Drivetrain - Rear Stub Axle Oil Seal Leakage
- Drivetrain - Front Stub Axle Oil Seal Leakage
- Audio System - Speaker Vibration/Rattle Noise Diagnosis
- Recommended Repairs
- Superceded Bulletins
- RB156C2 - 06/01/05
- RB156C - 06/01/05
- RB156 - 06/01/05
- RB1562 - 06/01/05
- TEC762996 - 12/31/96
- TEC570396 - 04/18/96
- TEC440296 - 12/20/96
- TEC370296 - 05/24/96
- TEC120896 - 03/07/97
- TEC120101 - 12/01/01
- TEC100301 - 03/10/01
- H877 - 03/08/96
- Sunroof Glass/Water Dam - Detachment
- Transfer Gearbox Output Seal - Oil Leaks
- Temperature Gauge - Reads High/Flickers
- Engine - Rattling/Tapping Sounds
- Maintenance - Fluid Specifications
- Vehicle - Maintenance Fluid Specifications
- All Technical Service Bulletins
- Goodwill Self-Authorization Program - Simplification
- Technical Literature Corrections/Suggestions
- Audio System - Return/Exchange Policy
- Loctite Sealants And Adhesives - US/Canadian Equivalents
- Warranty Labor Rate - Request Forms
- Towing - Damage Reporting Procedure
- Hand Held Equipment - Repair Procedure
- GEMS - DTC Report HelpLine
- Warranty Repair - Authorizations
- Technical Literature - Guidelines for Organizing
- Maintenance - Service Interval Checklists
- Special Tool List - Updated
- Special Tool - Reorganization Kit
- OEG - Introduction of Owner Guarantee Program
- ETM - Supplement to 93/Use as 94 Manual
- Service Manual - Updated Technical Information
- Rear Air Conditioning Duct - Residue Accumulation
- Heater Plenum - Water Leaks to Interior
- ECM - DTC P0125 Set
- Steering - Lock Stop Settings
- Restraint System - Collision Repair Guidelines
- Steering - Lock Stop Setting Procedures
- Connector Housing Bracket - Vibration
- Technical Hotline - Contact Prior to Selected Repairs
- Idle Air Control Valve - Unnecessary Replacement
- Fuel Pump - Component Replacement
- Engine - Misfire Diagnosis
- Fuel System - Fuel Pump Component Replacement
- Front Brake - Squeal
- Spark Plugs - Recommendations/Service
- Spark Plug - Recommendations
- Spark Plug - New Part/Extended Service Interval
- Hub Bearing - Adjustment
- Power Steering Box - Warranty Policy Change
- Power Steering Box - Replacement
- Exchange Power Steering Boxes - Availability
- Engine - Camshaft Knock
- Engine - Valve Guide Cleaning
- Valve Cover - Oil Leak
- Cylinder Block - Applications/Interchangeability
- Engine Oil Pan - Oil Leaks
- Engine - Oil Pan Bolt Leakage
- Engine - Oil Leaks From Rear of Cylinder Block
- Engine - Oil Leaks From Rear
- Exhaust Manifold/Header Pipe - Exhaust Leaks
- Plenum - Sealing Change
- Drivetrain - Front Axle Swivel Seals Leaking
- Suspension - Vehicle Not Sitting Level
- Suspension - Coil Spring Installation Precautions
- Suspension - Vehicle Does Not Sit Level
- Shock Absorbers - Warranty Policy
- Alloy Wheel Rims - Tire Installation & Removal
- Alloy Roadwheels - Retrofit Recommendations
- Wheels - Difficult to Remove
- Rear Bumper Attachment Bolt - Torque
- Seat Lumbar Knob - Falls Off
- Rear Inward Facing Seats - Rattle
- Front Seats - Fore/AFT Movement
- Interior - Electric Front Seat Play Adjustments
- Body - Carbalflo XTR5(R) Lubricant Usage
- Sunroof - Malfunction/Incomplete Operation
- Sunroof - Water Leak
- Front/Rear Sunroofs - Rattle Noise
- Sunroof - Water Leaks to The Interior
- Sunroof - Jams During Tilt Operation
- Body - Sunroof Water Leaks
- Driveline - Vibration/Noise at Low or High Speeds
- Recall - Driveshaft Nut/Bolt Replacement
- Transmission Mount - Vibration Noise
- Drivetrain/Brakes - Brake Line Bracket Modification
- Transfer Box - Noise
- Transfer Gearbox - Overhaul Recommendations
- A/T - Filter Replacement Interval
- A/T - Intermediate Plate/Oil Pump Replacement
- A/T - Fluid Leaks From Torque Converter
- A/T - Cooler Flushing
- Clutch Slave Cylinder Heat Shield - Rattles
- ECM - MIL ON DTC P1317 Set
- Engine - Hard Starting When Cold
- Cold Start
- Temperature Gauge - Inaccurate/False DTC's Stored
- ECM - MIL ON DTC P0461 Set
- Engine - Poor Starting in Cold Weather
- Oxygen Sensor - Codes 44 & 45 Diagnosis
- Oxygen Sensor - Handling and Diagnosis
- Heated Oxygen Sensor - Unnecessary Replacement
- Mass Air Flow Sensor - Gold Plated Connectors
- Front Hub Seal - Oil Leaks
- Battery - Identification/Warranty Information
- Replacement Battery - Installation
- Battery - Dead/Fails to Maintain A Charge
- Battery - Intersate(R) Battery Retrofitting
- Underhood Fuse Box - Poor Connections/Driveability
- Electrical - Intermittent Electrical/No Start Problems
- Ignition System - Misfire at High Engine Speeds
- Cranks - No Start/Hesitation When Driving
- Ignition Module - Engine No Start/Poor Start
- Ignition System - Hard Starting
- Ignition Coil - Poor Connections
- Crankshaft Position Sensor - Loose
- CKP Sensor/Heat Shield - Revised Tightening Bolts
- Recall 04V203000: Fuel Tank Stress Cracking
- Recall - Fuel Tank Replacement
- Recall - Fuel Tank Replacement (Canadian Vehicles)
- Fuel System - Poor Throttle Response
- Rear Brake Light/Rear Defogger - Short Circuit
- Squeaks And Rattles - Diagnosis/Repair
- Cruise Control - 'Set/Hold' Inoperative
- Cell Phone - Radio Mute Function
- Radio - Noise With Ignition Switch in Position 1 or 2
- Passenger Seat Belt Stalk - Rattles
- Transmission Input Seal - Leaks Oil
- Starter - Engine No-Start Condition
- Fuel Gauge - Diagnostic Guidelines
- Oil Pressure Switch - Oil Leakage
- Speedometer - Noise Diagnosis
- Reverse Lights - Intermittant Operation
- Trailer Warning Light - Intermittent Operation
- A/C - Low Pressure Line Refrigerant Leaks
- Cylinder Head Gasket - Revised Part
- Engine - Valve Cover Gasket Replacement
- Engine/Drivetrain - Vibration at 30 to 40 Mph
- Drivetrain - Difficult Differential Lock Selection
- Steering Wheel/Column Lock - Misaligned
- Steering Wheel -Misalignment
- Ignition Key Cylinder - Too Much Free Play
- Front Suspension - Bolts/Hardware Comes Loose
- Front Axle - Swivel Seals Leaking Grease
- Body - Vibration/Noise & Harshness
- Preliminary Paint/Body Information
- Warranty - Annual Corrosion Inspection
- Body - Creak At Low Speed
- Bulkhead - Water Leaks to Interior
- Sealant Material - Approved Supplier List
- 'D' Post/Alpine Light - Water Leaks to Interior
- Body - Water Leaks To The Interior
- Body - New A Pillar Replacement Trim
- Bulb Holder - Improved Design
- SRS - Torx Head Retainers
- SRS System - Questions & Answers
- SRS - Fuse Repalcement
- Air Bag - Safety Label Instruction
- SRS - Parts Replacement Policy
- Alarm System - Transmitter Code Learning
- Security System Antenna - Reduced Range
- Campaign - Engine Cold Start Improvements
- Recall - Cold Start Improvements
- GEMS System - OBD ll Diagnostic Information Document
- Warranty Claims - MIL Event Requirements
- GEMS Code P0125 Diagnosis
- Recall - Improved Starting in Cold Weather
- Emissions/Fuel Systems - Difficulty Filling Fuel Tank
- Central Locking System - Intermittent Locking
- Radio Speaker - Clicking/Cracking Noises
- Rear Subwoofer - Thump or Pop Noises
- Clock - Runs Counter Clockwise
- Washer Pump - Updated/Conversion Link Lead
- Front Suspension Bushings - Replacement
- Driver's Door - Rattles
- Rear Side Door - Windnoise At D Post
- Side Door - Water Retention
- Hood Liner - Production Modifications
- Windshield - Water Leaks
- Windscreen Finisher A Post - Poor Fit
- Windscreen - Water Leaks/Windnoise
- Windshield/Dash - Creaking/Squeaking Noise
- Windshield - Water Leaks To The Interior
- Windscreen Glass - Replacement
- Rear Washer Jet - New Design
- Wipers-Washers - Rear Washer Nozzle Damaged/Broken
- Door Mirror - Wind Noise/Dust Intrusion
- Rear Bumper Filler Strip - Cracking
- Front Grille - Lower Corner Cracking
- Rear Bumper Lamp - Cracking
- Drink Holder - Replacement Procedure
- Engine Oil - Viscosity Recommendations
- Engine Oil - Winter Driving Specification
- Engine - Oil Refill Quantity/Dipstick Level
- Engine - No Start in Extreme Cold Conditions
- Engine - Cold Climate Oil Recommendations
- Antifreeze/Coolant Mix - Incorrect
- Antifreeze - Protection Level
- Coolant - Incorrect Anti Freeze Mixture
- Coolant/Antifreeze - Checking Protection Level
- Radiator Bleed Hose - Deformation
- Engine Valley Cover Gasket - Revised Part
- Engine - Intake Manifold Fluid Leaks
- Center Console - Creak/Squeal
- Steering System - Fluid Leaks
- Transfer Gearbox - Backlash/Clonk
- A/T - ZF Transmission/Multiple Shift Concerns
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Manual Gearbox - Service Procedure
- M/T - Fluid Leaks
- M/T - Front Cover Oil Leaks
- Center Plate/Extension Housing - Oil Leak
- Engine - Excessive Noise/Vibration
- Serpentine Drive Belt - Update
- A/T - Fluid Level Checking
- Ignition System - Hard Start/Rough Running/Misfire Codes
- Engine - Oil Leaks From Rear of Engine
- Oil Cooler Pipe - Oil Leaks
- Antitheft System - Intermittent Alarm Activation
- Wiring - Header Junction Repair Kit
- Main Harness - Rerouting
- Relay - Contact Resistance Test Procedure
- Rear Hub Seal - Oil Leaks
- Drivers Side Fascia Access Panel - Installation
- Driver Closure Plate - Fixing Stud Omitted
- Sill Button - Too Low/Difficult to Operate
- Audio System - Diagnosis & Troubleshooting
- Pioneer Audio System - Fault Diagnosis
- Radio And CD Changer - Out of Warranty Repairs
- Paint - Codes & Types
- Sandpaper - U.S. vs U.K. Abrasive Grades
- Paint - Standox Tinting Guide for Paint Matching
- Paint - Plastic Component Refinishing Procedures
- Rear Footwell Carpet - Poor Fit
- Rear Footwell Carpet - Loose Fit at Seat Plinth
- Carpet - Fits Poorly at Front Seats
- Drivers Heel Mat - Lifting/Loose
- Automatic Gear Selector - Graphic Film Torn
- EAS - Updated Service & Diagnostic Information
- New Edition - EAS Diagnostic Unit Operating Manual
- Inside/Outside Door Handle - Intermittent Operation
- Speakers - Buzzing Noise From Front Tweeters
- Hub Nut - Revised Torque Setting Procedure
- Engine - Hesitation, OBD Fault 17/DTC P0121 Set
- LT230T Transfer Gearbox - Oil Specification
- Drivetrain - Transfer Case Oil Specification
- Dashboard - Torque Specifications
- Interior - Dash Pad Separation
- Multi-Function Unit - Wiring/Connector Information
- Radio - Interference & Poor AM Reception
- Keyless Entry - Remote Transmitter Button Splitting
- A/C System - CFC Free Refrigerant (R134a)
- M/T - Gearbox 5th Layshaft & Gear Retention
- M/T - Mod Improves Joint Between 5th Gear & Layshaft
- Headlamp Wash System - Filter
- Transfer Gearbox - Will Not Shift Out of Gear
- Transfer Gearbox - Whine
- A/C System - Water Leaks to Interior
- Drivetrain - Revised Pinion Assembly/Torque Values
- A/T Shift Lever - Locked/Will Not Move
- SRS Harness - Replacement Procedure
- SRS Air Bag Harness - Sensor Connections
- Transfer Case - Output Seal Leakage
- Body - Tailgate Rattles
- Interior - Cold Air Drafts
- Power Take Off Cover Plate - Oil Leaks
- No Obstacles Lease Program - Scheduled Maintenance
- Ignition Timing - Poor Engine Performance
- Engine - Base Idle Adjustment During PDI
- ABS - Hot Flush And Bleed Update
- Vehicle - Lift Standards & Approved Suppliers
- Campaign - Oil Pressure Switch Replacement
- Interior - Child Seat Tether Bracket Installation
- Interior - Child Seat Tether Installation
- Recall - Inadvertent Air Bag Deployment
- Security System - Long Arming Light Indication
- Body - Sunroof Panel/Water Dam Separation
- Seat Base Access Panel - Rattles
- Front Seat Trim Cover - Loose/Rattles
- Differential Pinion Oil Seal - Leaks Oil
- Transfer Case - Input Seal Leakage
- Front Stub Axle Seal - Leaks Oil
- Rear Stub Axle Seal - Leaks Oil
- Drivetrain - Rear Stub Axle Oil Seal Leakage
- Drivetrain - Front Stub Axle Oil Seal Leakage
- Maintenance - Fluid Specifications/Applications
- Audio System - Speaker Vibration/Rattle Noise Diagnosis
- Body - Windshield Damage Diagnostic Aid
- Suspension - Correct Ball Joint Splitter Usage