Canada - Engine Control - MIL ON DTC's P0171 P0174 P2195 P2197
BulletinTSB2182
Issue Date
November 30, 2005
Title
M.I.L. "ON" DTC P0171, P0174, P2195 OR P2197
Component
ENGINE ELECTRICAL
Models
'05 - '06 ES 330
INTRODUCTION:
Under certain driving conditions, some 2005 - 2006 model year ES 330 vehicles may exhibit a M.I.L. "ON" condition with at least one of the following DTCs:
- P0171 (System Too Lean [Bank 1])
- P0174 (System Too Lean [Bank 2])
- P2195 (Oxygen [A/F] Sensor Signal Stuck Lean [Bank 1, Sensor 1])
- P2197 (Oxygen [A/F] Sensor Signal Stuck Lean [Bank 2, Sensor 1])
The Air Fuel (A/F) sensor manufacturing process has been improved to correct this condition. The following repair procedures should be used to properly diagnose and repair the affected vehicles.
APPLICABLE VEHICLES:
- 2005 - 2006 model year ES 330 vehicles produced BEFORE the Production Change Effective VINs shown below.
PRODUCTION CHANGE INFORMATION:
WARRANTY INFORMATION:
PARTS INFORMATION:
REQUIRED SSTs:
REPAIR PROCEDURE:
DTC P0171 or P0174
Refer to ETAS, 2005 or 2006 model year ES 330 Repair Manual: Diagnostics: SFI System (3MZ-FE): P0171, P0174.
NOTE:
Only replace the A/F sensor indicated by the M.I.L. "ON" DTC(s).
DTC P2195 or P2197
Refer to ETAS, 2005 or 2006 model year ES 330 Repair Manual: Diagnostics: SFI System (3MZ-FE): P2195, P2197.
NOTE:
Only replace the A/F sensor indicated by the M.I.L. "ON" DTC(s).
NOTE:
Issue of this Technical Service Bulletin is to ensure that proper repair information is available. IT DOES NOT CONSTITUTE AN AUTHORIZATION FOR REPAIR. Normal provisions of the formal warranty policy, as applicable, will apply.