Part 1

ENGINE ASSEMBLY

COMPONENTS (Part 1):

COMPONENTS (Part 2):

COMPONENTS (Part 3):

COMPONENTS (Part 4):

COMPONENTS (Part 5):

COMPONENTS (Part 6):

COMPONENTS (Part 7):

COMPONENTS (Part 8):

COMPONENTS (Part 9):

COMPONENTS (Part 10):

COMPONENTS (Part 11):

REMOVAL
1. DISCHARGE FUEL SYSTEM PRESSURE
2. DISCHARGE REFRIGERANT FROM REFRIGERATION SYSTEM
3. PLACE FRONT WHEELS FACING STRAIGHT AHEAD
4. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL

CAUTION: Wait for least 90 seconds after disconnecting the cable from the negative (-) battery terminal to prevent airbag and seat belt pretensioner activation.

5. REMOVE SERVICE PLUG GRIP
6. DRAIN ENGINE OIL
7. DRAIN ENGINE COOLANT





8. REMOVE COOL AIR INTAKE DUCT SEAL
(a) Remove the 7 clips and intake duct seal.





9. REMOVE ENGINE ROOM SIDE COVER RH
(a) Remove the 4 clips and side cover.





10. REMOVE ENGINE ROOM SIDE COVER LH
(a) Remove the 3 clips and side cover.





11. REMOVE V-BANK COVER SUB-ASSEMBLY
(a) Hold the front of the V-bank cover and raise it to disengage the 2 clips on the front of the cover. Continue to raise the cover to disengage the clip on the rear of the cover and remove the cover.

NOTICE: Attempting to disengage both front and rear clips at the same time may cause the cover to break.

12. REMOVE FRONT WHEELS
13. REMOVE ENGINE UNDER COVER
14. REMOVE NO. 2 ENGINE UNDER COVER
(a) Remove the 4 screws, 2 grommets, 2 spacers and under cover.

15. REMOVE REAR ENGINE UNDER COVER RH
(a) Remove the bolt and under cover.

16. REMOVE REAR ENGINE UNDER COVER LH
(a) Remove the bolt and under cover.

17. REMOVE FRONT FLOOR BRACE CENTER
18. REMOVE FRONT EXHAUST PIPE ASSEMBLY
19. REMOVE PROPELLER WITH CENTER BEARING SHAFT ASSEMBLY





20. REMOVE NO. 1 AIR CLEANER INLET
(a) Remove the bolt and air cleaner inlet.

21. DISCONNECT NO. 2 VENTILATION HOSE
22. REMOVE AIR CLEANER CAP WITH AIR CLEANER HOSE





23. REMOVE AIR CLEANER CASE
(a) Remove the 3 bolts, 2 clamps and case.

24. REMOVE OIL PUMP MOTOR CONTROLLER





25. DISCONNECT NO. 2 FUEL VAPOR FEED HOSE
(a) Remove the clamp and disconnect the feed hose.

26. DISCONNECT RADIATOR HOSE INLET
27. DISCONNECT RADIATOR HOSE OUTLET
28. DISCONNECT RADIATOR RESERVE TANK HOSE





29. DISCONNECT HEATER WATER INLET HOSE A
(a) Disconnect the inlet hose.





30. DISCONNECT HEATER WATER OUTLET HOSE A
(a) Disconnect the outlet hose.





31. DISCONNECT NO. 1 INVERTER COOLING HOSE
(a) Disconnect the cooling hose.





32. DISCONNECT NO. 2 INVERTER COOLING HOSE
(a) Disconnect the cooling hose.