Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Recall 05V388000: Cruise Control Switch Replacement
- Recall 01V258000: Wiper Motor Gear Case Cover
- Recall - Defective Wiper Motor Switch/Gear Cover
- Recall 01V227001: Seat Belt Buckle Defect
- Recall - Outboard Seats Belt May Not Fully Latch
- Recall 00V396000: Child Restraint Anchor Non-Compliance
- Recall - Revised Child Tether Instructions
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Customer Interest
- Brakes - Adjustable Brake Pedal Adjustment Inoperative
- A/C - White Flakes/Powder Blow From Dash Vents
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine - MIL ON/Multiple Misfire Codes Set/Low Power
- Suspension - Air Suspension Excessive Compressor Noise
- Drivetrain - Rear Differential Whine/Hum Noise
- Transfer Case - Inadvertent Shifts
- A/T - Torque Converter Access Plug Dislodges
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Horn - Weak Alarm System Confirmation Chirp
- Oil Pressure Sending Unit - Drip Shield Interference
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Body - Corrosion At Bottom of Door or Tailgate
- Restraints - Seat Belts Slow to Retract
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- A/T - Inadvertent Shift Interlock Disabling
- Air Suspension - Lamp ON/DTC's B2140 or C2140 Set
- Body - Front Window(s) Pop/Thump Noise at End of Travel
- Parking Assist System - False Warnings
- A/C - Heater Core Electrolysis/Leakage
- Starting System- No Crank Condition
- Interior - Leather Wrapping On Steering Wheel Is Loose
- 4X4/AWD System - Shudder On Accel/Decel/Binding On Turns
- Superceded Bulletins
- 05S28S5 - 09/30/05
- Rear Window Defroster - Inoperative
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Recall - Cruise Control Deactivation Switch/Fire Hazard
- Recall - Speed Control System Modification
- Recall - Cruise Control Deactivation Switch Defects
- Recall - Cruise Control Switch Modification
- Recall - Cruise Control Switch Defect/Fire Hazard
- Recall - Cruise Control Switch Defect
- Body - Aluminum Corrosion Service Tip
- Audio System - Popping/Screeching Noises/No Audio
- Parking Assist System - False Tone Activation
- Parking Assist System - False Activation
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Restraint System - Seat Belts Slow to retract
- A/C - White Flakes Blowing From Dash Vents
- A/C - White Flakes Are Blowing From Dash Vents
- A/C - White Flakes Come From Dash Vents With Blower ON
- A/C - White Flakes Blow From Dash Vents
- A/C - White Flakes From Vents With Blower ON
- A/C - White Flakes Coming From Vents
- A/C - White Flakes Coming From Vents W/Blower On
- Suspension - Air Suspension Compressor Noise
- Suspension - Repeat Compressor Drier Failures
- Steering - Tie Rod End Inspection Procedure
- Steering - Canadian Vehicle Tie Rod Inspection Procedure
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Drivetrain - Drive Axle Whine/Hum on Accel/Decel/Cruise
- Drivetrain - Rear Axle Whine or Hum
- Shift Interlock (BRAKE) - Inadvertent Disabling
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - DTC's P1635 or P1639 Set/4X4 Lamp ON
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Engine - Oil Recommendations/Applications
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- All Technical Service Bulletins
- Brakes - Adjustable Brake Pedal Adjustment Inoperative
- A/C - White Flakes/Powder Blow From Dash Vents
- A/C System - Diagnosis and Service Tips
- Campaign - Engine Assembly Replacement
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Steering - Correct Placement of P/S Pump Bolt/Washer
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Campaign - Tie Rod Inspection Maintenance Reminder
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Engine - MIL ON/Multiple Misfire Codes Set/Low Power
- Wheels/Tires - Road Force Measurement Equipment
- Wheels - Correct Lug Nut Torque Specifications
- Air Suspension - Repeat Compressor Drier Failures
- Suspension - Air Suspension Excessive Compressor Noise
- Warranty - Guide Supplement
- Information
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor Information
- Attachment III - Technical Information
- Owner Letter
- Supplement # 1 - Information
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Owner Letter
- Supplement # 2 - Information
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Apology Letter
- Supplement # 2 - Owner Letter
- Drivetrain - Rear Differential Whine/Hum Noise
- Transfer Case - Inadvertent Shifts
- A/T - Cooler Flushing Service Tips
- A/T - Torque Converter Access Plug Dislodges
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions/Engine Controls - Driveability Diagnosis
- Recall - Oxygen Sensor Inspection/Replacement
- Idler Arm - Replacement Specifications
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - General PCM Programming Procedures
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- Recall 05V388000: Cruise Control Switch Replacement
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Horn - Weak Alarm System Confirmation Chirp
- Oil Pressure Sending Unit - Drip Shield Interference
- Recall 01V258000: Wiper Motor Gear Case Cover
- Recall - Defective Wiper Motor Switch/Gear Cover
- Engine Head Gasket - Approved Replacement Procedures
- Steering - Tie Rod End Inspection Procedures
- PATS System - Diagnostic Service Tips
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Engine Controls - MIL ON/Lean DTC Service Tips
- Body - Corrosion At Bottom of Door or Tailgate
- Restraints - Seat Belts Slow to Retract
- Body - Exterior Mirror Glass/Motor Service Tips
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - In Line Fluid Filter Kit
- Campaign - 4R100 Transmission Replacement
- A/T - Mercon V ATF Usage
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- A/T - Inadvertent Shift Interlock Disabling
- Air Suspension - Lamp ON/DTC's B2140 or C2140 Set
- Seat Belts - Warning System Operation
- Body - Front Window(s) Pop/Thump Noise at End of Travel
- Recall 01V227001: Seat Belt Buckle Defect
- Recall - Outboard Seats Belt May Not Fully Latch
- Recall 00V396000: Child Restraint Anchor Non-Compliance
- Recall - Revised Child Tether Instructions
- Parking Assist System - False Warnings
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Starting System- No Crank Condition
- Body - Aluminum Body Panels - Corrosion
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Recall 07V336000: Cruise Control Fire Hazard
- 4X4/AWD System - Shudder On Accel/Decel/Binding On Turns
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter