Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 98V322000: Lower Ball Joint Cracking
- Recall - Front Lower Control Arm Ball Joint Replacement
- Overview
- Important Recall Information
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Owner Letter - 1995 and Foward Vehicles
- Owner Letter - 1994 and Prior Vehicles
- Supplement # I - Dealer Letter
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment II - Labor and Parts Information
- Recall 95V133000: Rear Brake Line Leak/Rupture
- Recall 99V124000: Speed Control Deactivation Switch
- Recall 87V139000: Fuel Line Coupling Retainer Clips
- Recall - Airbag Deactivation Shunt Replacement
- Recall 07V336000: Cruise Control Fire Hazard
- Recall 08V051000: Incorrect Speed Control Jumper Harness
- Recall - Cruise Control Switch Jumper Harness
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Customer Interest
- Air Conditioning - Musty/Mildew Type Odors
- Power Steering System - Noisy
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Brakes - Roughness/Pedal Vibration
- Brakes - Excessive Rear Lining Wear
- Brakes - Roughness During Application
- A/C Compressor - FX15 Noise/Resonance
- Steering - Buzz/Growl During Right Hand Turns
- Oil Filter - Balloons and/or Eventually Leaks
- Accessory Drive Belt - Squealing Noise
- Wheels - Center Ornament Falls Off
- Air Suspension - Hum Noise
- Steering - Drift/Sensitive/Constant Correction
- `A' Pillar - Wind Noise
- Power Moon Roof - Wind Noise
- A/T - Vibration/Shudder On Light Acceleration
- A/T - AODE Intermittent Loss of Torque at 3-4 Upshift
- Torque Converter Clutch - Vibration/Shudder
- Idle Air Bypass Valve - Noise Or Moan
- Engine - Lean Driveability Symptoms
- Steering Column - Squeaking/Rubbing Noise
- Engine - No Crank Condition
- Ignition Switch Lock/Steering Lock - Difficult Operation
- A/T - AODE/4R70W Shudder/Vibration Over 35 mph
- EGR - Intermittent MIL ON/Multiple DTC's Set
- Engine - Spark Knock/Ticking Sound
- Heated Backlite - Inoperative
- Cellular Phone - Phone Cradle Bumper Broken
- Front Wiper Motor - Erratic Operation
- Electronic Fuel Gauge - Erratic Readings
- A/C Clutch - Ticking/Pinging or Popping
- Power Door Lock - Inoperative
- Differential - Chatter On Turns
- Front Door Trim - Delamination at Demister Vent
- Interior Trim - Armrest Vinyl Cover Separation
- Rear View Mirror - Detaches From Windshield
- Exhaust System - Buzzing/Rattling Noise
- A/T - AODE/4R70W Delayed or No Forward Engagement
- Cell Phone - Inoperative/Static/No Reception/Busy Signal
- A/T - 4R70W/AODE DTC's Set/Shift Concerns
- A/T - AODE/4R70W Harsh Engagement/Firm Shifts
- EATC Blower Motor - Whooshing Noise
- Decklid Power Pull-Down - Inoperative
- Seat Sensor Switch - Causes Lock Malfunction
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- A/T - Inadvertent Shift Interlock Disabling
- Inside Door Handle - Detachs From Door Trim
- A/T - AODE/4R70W Erratic/Prolonged 1-2 Shift
- Front Seat - Loose or Clunk Noise
- ABS - Brake Pedal Noise/Vibration/Slip/Stick
- A/T - AODE/4R70W Intermittent Operation
- Chemicals,Additives
- Labor/Parts Updates
- Superceded Bulletins
- 97-14-14 - 07/07/97
- Wiper Motor - Component Transfer Tips
- Recall - Speed Control Deactivation Switch
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Leather Seat - Cleaning Procedure Tips
- Seat Leather - Cleaning Procedure
- Decklid - Power Pull Down Assembly Inoperative
- Decklid - Power Pull-Down Inoperative
- Inside Door Handle - Detaches From Door Trim
- Remote Keyless Entry System - Features
- Air Bag Modules Discolored - Painting Restrictions
- A/C - Musty and Mildew Type Odors
- A/C - Identification Of Non Approved Refrigerants
- Air Conditioning - Musty Odors
- A/C - R134A Retrofit Kit Availability
- A/C - R12 to R134a Retrofit Kit Availability
- A/C - Approved Flushing Procedures
- Air Conditioning - Musty or Mildew Type Odors
- A/C System - Musty/Mildew Odors
- A/C - Evaporator Core Leak Test
- A/C Evaporator - Leak Test Required For Warranty Claim
- A/C - O Ring Removal From Spring Lock Coupling
- Power Steering Pump - Noise
- Power Steering Pump - Noisy
- Power Steering Pump - Noises
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Electrical - Wiring Harness Terminal Repair Kit
- Wire Harness - Terminal Repair Kits
- Wire Harness - New Terminal Repair Kit
- Recall - Incorrect Cruise Control Jumper Harness
- Brakes - Noise/Vibration on Slow Apply and Release
- Brakes - Special Lubricant Requirements
- Brakes - Roughness/Vibration
- Brake Rotor - Hub Mounted Machining Equipment
- Brakes - Rotor/Drum Sanding Elimination
- Brake Rotor - Machining With On-Vehicle Equipment
- Front Brake Rotor - Premature Wear or Vibration
- Antilock Brakes - Cycling on Rough Roads
- Antilock Brakes - ABS Cycling On Rough Roads
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Brake Shift Interlock - Inadvertent Disabling
- A/T - AODE Transmission Pan Gasket/Reusable Design
- A/T - AODE/4R70W Main Control/Case Usage
- Ignition Switch/Lock Cylinder - Difficult Operation
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel - Volatility Related Concerns
- Fuel Economy - Expectations Versus Usage
- Fuel Tank - Punctures During High Speed Rear Impacts
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- Fuel Pump - Buzz/Whine Through Radio Speakers
- Radio - Whine/Buzz
- Deposit Resistant Fuel Injectors - ID and Application
- Fuel - Volatility Related Driveability Information
- Engine - Detonation/MIL ON/(DTC) 332 Set
- A/T - AODE/4R70W Early/Late Shifts/Engagement Concerns
- A/T - AODE/4R70W Early/Late Shift
- A/T - AODE Shifting/TCC Concerns
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Exhaust System - Buzz/Rattle Noise
- Heater Core - Repeated Failure
- Cooling System - Diagnosis Procedure
- Engine - Cylinder Head Straightedge Flatness Check
- Drive Belt - Squealing Noise in Cold Tempreatures
- A/T - Fluid Application Charts
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Steering - Drift/Wanders/Sensitive/Constant Correction
- Oil Filter - Balloons and Eventually Leaks
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- A/T - AODE/4R70W Shudder/Vibration
- A/T - AODE/4R70W Shudder/Vibration Above 35 MPH
- A/T - AODE/4R70W Vibration/Shudder On Light Acceleration
- Engine - Oil Recommendations/Applications
- Propylene Glycol Coolant - Recommendations
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- A/T - AODE/4R70W Shudder or Vibration On Light Load
- Automatic Transmission - Fluid Usage Charts
- A/C - Filter Kit Installation After Replacing Compressor
- A/C Compressor Replacement - Refrigerant Filtering
- A/C System - Use of R12 Refrigerant Substitutes
- Air Conditioning - Filtering Refrigerant
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- All Technical Service Bulletins
- Electronic Instrument Cluster- Testing Revision
- A/C System - Service TSB List
- Air Conditioning - R12 to R134A Retrofit Kit
- Air Conditioning - Musty/Mildew Type Odors
- ATC/EATC - Cold Engine Lockout Operation
- A/C - Filtering Refrigerant After Compressor Replacement
- A/C System - Diagnosis and Service Tips
- Power Steering System - Noisy
- Engine Gasket Surface - Cleaning Procedures
- Engine - Repair Tips to Avoid Potential Damage
- Aluminum Engine - New Cleaners/Service Tips
- Throttle Position Sensor - Function and Diagnostic Tips
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Brakes - Roughness/Pedal Vibration
- Brakes - Excessive Rear Lining Wear
- Brakes - Roughness During Application
- Brake and Rotor - Service Tips
- A/C Compressor - Oil Recovery and Measuring Procedure
- A/C Clutch - Slips At High Ambient Temperature
- A/C Compressor - FX15 Noise/Resonance
- A/C Evaporator Core - On Vehicle Leak Test Requirement
- Air Conditioning - Approved Flushing Procedures
- Heater Core - On Car Pressure Test For Warranty Claim
- Steering - Buzz/Growl During Right Hand Turns
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Oil Filter - Balloons and/or Eventually Leaks
- Cooling System - New System Diagnostics
- Accessory Drive Belt - Squealing Noise
- A/C - FX15 Clutch Application Chart
- Ball Joint - Replacement Procedure Tip
- Recall 98V322000: Lower Ball Joint Cracking
- Recall - Front Lower Control Arm Ball Joint Replacement
- Overview
- Important Recall Information
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Owner Letter - 1995 and Foward Vehicles
- Owner Letter - 1994 and Prior Vehicles
- Supplement # I - Dealer Letter
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment II - Labor and Parts Information
- Wheels - Center Ornament Falls Off
- Air Suspension - Hum Noise
- Steering - Drift/Sensitive/Constant Correction
- Lug Nuts - Proper Installation/Torqueing Procedure
- `A' Pillar - Wind Noise
- Power Moon Roof - Wind Noise
- Axle - Rear Axle Shaft Assembles, Revised Design
- A/T - AODE/4R70W Reusable Pan Gasket/Filter
- A/T - Vibration/Shudder On Light Acceleration
- Torque Converter - Cleaning and Replacement Guidelines
- A/T - Cooler Flushing Service Tips
- A/T - AODE Intermittent Loss of Torque at 3-4 Upshift
- A/T Torque Converter - Leak Test Procedure
- Torque Converter Clutch - Vibration/Shudder
- Deposit Resistant Fuel Injectors - Identification
- Fuel Injectors - Non Warranty Reimbursement Testing
- A/T - AODE Shifting Concerns/TCC Engagement
- Heated Exhaust Gas Oxygen Sensor - Application Chart
- EGO Sensors - Silicone Contamination
- EGR DPFE Sensor - Voltage Range Revision
- Idle Air Bypass Valve - Noise Or Moan
- Mass Air Flow Sensor - Assembly Replacement
- Engine - Lean Driveability Symptoms
- Steering Column - Squeaking/Rubbing Noise
- Engine - No Crank Condition
- Starter Solenoids and Drives - Obsolete Parts Return
- Ignition Switch Lock/Steering Lock - Difficult Operation
- Campaign - Alarm System Update
- Connector, DIS Ignition Revised
- A/T - AODE/4R70W Shudder/Vibration Over 35 mph
- Accelerator Cable - Diagnostic Procedure
- EGR - Intermittent MIL ON/Multiple DTC's Set
- Engine - Spark Knock/Ticking Sound
- Heated Backlite - Inoperative
- Cellular Phone - Phone Cradle Bumper Broken
- Air Bag Modules - Discolored/Marred Covers
- Front Wiper Motor - Erratic Operation
- Brake Rotor - Machining Equipment/Warranty Information
- Brakes - Elimination Of Sanding Rotors And Drums
- Hub-Mount Brake Rotor Machining Equipment
- Electronic Fuel Gauge - Erratic Readings
- Wipers/Washers - Wiper Motor Transfer Tips
- A/C Clutch - Ticking/Pinging or Popping
- Engine Head Gasket - Approved Replacement Procedures
- Antilock Brakes - Cycling On Rough Roads
- Antitheft System - Recap of TSB's/Service Tips
- MIL ON/No Codes Set Explanation
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- Power Door Lock - Inoperative
- Differential - Chatter On Turns
- Front Door Trim - Delamination at Demister Vent
- Interior Trim - Armrest Vinyl Cover Separation
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Glass - Iridescence or Mottling In Tempered Glass
- Rear View Mirror - Detaches From Windshield
- Rear View Mirror - Reattachment
- Bumpers - Isolator and Bracket Assembly Replacement
- Bumper Covers - Minor Surface Damage Repair Guidelines
- Bumper Cover - Repair Materials Update
- Cupholder Ashtrays - Installation Procedure
- Motor Oil - Viscosity Grade Recommendation
- Engine Oil - Oil Recommendations/Applications
- Cooling System - Proper Fluid Concentrations
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- Exhaust System - Buzzing/Rattling Noise
- Recall 95V133000: Rear Brake Line Leak/Rupture
- A/T - New Short Lip Piston Seals
- A/T - AODE/4R70W Delayed or No Forward Engagement
- A/T - AODE/4R70W Revised Forward Clutch Service Tip
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Shifts To Neutral At Heavy Throttle
- A/T - Delayed Engagement, Shift Errors, MLPS Codes
- A/T - AODE Output Shaft Pin Location and Updated Shaft
- A/T - AODE, 4R7OW Valve Body Cross Leaks
- A/T - AXOD, AX4S (AXODE) Revised Forward Sprag Race
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Cell Phone - Inoperative/Static/No Reception/Busy Signal
- Recall 99V124000: Speed Control Deactivation Switch
- A/T - Mercon V ATF Usage
- A/T - 4R70W/AODE DTC's Set/Shift Concerns
- A/T - AODE/4R70W Harsh Engagement/Firm Shifts
- Campaign - Transmission Range Sensor Inspection
- EATC Blower Motor - Whooshing Noise
- Campaign - Traction Control ECU Replacement
- Decklid Power Pull-Down - Inoperative
- Speedometer - Service Replacements With Pre-Set Mileage
- Climate Control - Blower Control Service Tips
- Engine - New Gasket Sealer
- Wire Harness - Terminal Repair Kit
- Electrical/Vacuum/Troubleshooting Manual
- Remote Keyless Entry System - Service Highlights
- Remote Keyless Entry System - Service Tips
- Remote Keyless Entry - Diagnostic Service Tips
- Keyless Entry System - Service Tips
- Antenna - Warranty Manual Revision
- Seat Sensor Switch - Causes Lock Malfunction
- Paint - Color Chart/Supplier Cross Reference
- Paint - Preparation Procedure And MSDS Information
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- Paint - Iron Particle Removal
- A/T - Inadvertent Shift Interlock Disabling
- Electrical Diode - Identification and Replacement
- A/T - EPC Solenoid Damage During Overhaul
- Inside Door Handle - Detachs From Door Trim
- A/T - AODE/4R70W Service Tips
- Hood Lamp Switch - Revised
- A/T - AODE/4R70W Erratic/Prolonged 1-2 Shift
- Front Seat - Loose or Clunk Noise
- ABS - Brake Pedal Noise/Vibration/Slip/Stick
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- A/C - Identification of Non Approved Refrigerants
- Air Conditioning - O Ring Removal Service Tip
- A/C - New O Ring Applications
- Recall 87V139000: Fuel Line Coupling Retainer Clips
- Brakes - New Silicone Compound/Grease
- Brakes - Vibration/Inspection Service Tips
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- Recall - Airbag Deactivation Shunt Replacement
- A/C - Adding Refrigerant Oil Service Tip
- A/C Compressor - Service Tips
- A/T - AODE/4R70W Intermittent Operation
- Seat Leather - Cleaning Procedure Tips
- Recall 07V336000: Cruise Control Fire Hazard
- Recall 08V051000: Incorrect Speed Control Jumper Harness
- Recall - Cruise Control Switch Jumper Harness
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter