Powertrain Management: Technical Service Bulletins
- Recalls
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - No Start Condition
- PCM - MIL ON/DTC P0411 Set
- Engine - Misfire/MIL ON/Codes P1443/P030X Set
- PCM/IMRC Actuator - MIL ON/DTC P1518 Set
- Engine - Hard Starting/Long Crank/Stalling
- Engine - Lean Driveability Symptoms
- Engine - Intermittent No Start
- Engine - No Start/Hard Start/Surge
- Engine - Stall During Quick Tip-In Tip-Out
- Exhaust System - Buzzing/Rattling Noise
- A/T - AX4S/AX4N Codes Stored After Replacement
- A/T - AX4S/AX4N DTC'S P0500/P1785/P1784 Set
- Cooling Fan - Runs After Engine Is Shut Off
- Secondary Air Relay - MIL ON/DTC 0411 in Memory
- By Symptom
- Abnormal wear/deterioration
- Continuous fan operation
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - No Start Condition
- PCM - MIL ON/DTC P0411 Set
- Engine - Misfire/MIL ON/Codes P1443/P030X Set
- PCM/IMRC Actuator - MIL ON/DTC P1518 Set
- Engine - Hard Starting/Long Crank/Stalling
- Engine - Lean Driveability Symptoms
- Engine - Intermittent No Start
- Engine - No Start/Hard Start/Surge
- Engine - Stall During Quick Tip-In Tip-Out
- Exhaust System - Buzzing/Rattling Noise
- A/T - AX4S/AX4N Codes Stored After Replacement
- A/T - AX4S/AX4N DTC'S P0500/P1785/P1784 Set
- Cooling Fan - Runs After Engine Is Shut Off
- Secondary Air Relay - MIL ON/DTC 0411 in Memory
- Driveability
- False instrument warning light/gauges
- Engine - Misfire/MIL ON/Codes P1443/P030X Set
- PCM/IMRC Actuator - MIL ON/DTC P1518 Set
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- A/T - AX4S/AX4N DTC'S P0500/P1785/P1784 Set
- Hard Shifting
- Incorrect gear selection
- Noise
- Recalls
- Starting problems
- All Technical Service Bulletins
- Throttle Position Sensor - Function and Diagnostic Tips
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - No Start Condition
- PCM - MIL ON/DTC P0411 Set
- A/T - AX4N Electronic Shift Solenoid Applications
- Fuel Injectors - Non Warranty Reimbursement Testing
- Engine - Misfire/MIL ON/Codes P1443/P030X Set
- PCM/IMRC Actuator - MIL ON/DTC P1518 Set
- PCM - Reprogramming Out of Vehicle
- Emissions/Engine Controls - Driveability Diagnosis
- EGR DPFE Sensor - Voltage Range Revision
- Engine - Hard Starting/Long Crank/Stalling
- Mass Air Flow Sensor - Assembly Replacement
- Engine - Lean Driveability Symptoms
- Engine - Intermittent No Start
- Engine - No Start/Hard Start/Surge
- Engine - Stall During Quick Tip-In Tip-Out
- Accelerator Cable - Diagnostic Procedure
- Recall - Warranty Information Booklet Update
- EVAP System - Diagnosis and Testing
- NGS Tester - Incorrect Display During Diagnostics
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- Exhaust System - Buzzing/Rattling Noise
- A/T - AX4S/AX4N Codes Stored After Replacement
- A/T - AX4S/AX4N DTC'S P0500/P1785/P1784 Set
- A/T - AX4S/AX4N TSS Sensor Air Gap Measurements Change
- A/T - AX4N Ticking Noise
- Cooling Fan - Runs After Engine Is Shut Off
- Campaign - Fuel Delivery Module Replacement
- Recall 87V139000: Fuel Line Coupling Retainer Clips
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- Secondary Air Relay - MIL ON/DTC 0411 in Memory