Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Recall - Fuel Transfer Hose and Clamp Replacement
- Recall - Engine Coolant Thermostat Defect
- Generals
- Safety
- Recall 00V359001: Ball Joint Stud Fractures
- Recall - Lower Ball Joint Inspection
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Lincoln Procedure Announcement Letter
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Attachment IV
- Supplement # 1 - Owner Letter
- Emissions
- Customer Interest
- EATC - No Setpoint/Blower Stays on HIGH
- EATC - Inaccurate Ambient Temperature Displayed
- ATC - Poor/No Cooling From L/H or R/H Vents
- Electrical - Low/Dead Battery/No Crank Condition
- A/C - Lack of Cooling From Driver/Passenger Vents
- Power Window - Squeaking/Creaking Noise When Operated
- Power Windows - Rear Window Inoperative
- A/T - Filter Improperly Installed (Stall/Engagement)
- Engine Controls - Cold Engine Flooding/Hard Start
- Engine Controls - No Start/Hard Start/Rough Idle
- Steering - Vibration/Noise/Steering Wheel Nibble
- Brake Pedal - Popping Noises
- Ignition System - Engine Misfire/DTC's Set
- PCM - Hard Start/Multiple Driveability Complaints
- PCM - Driveability Complaints
- PCM - MIL ON, DTC's P0350/P0360 Set
- A/T - 5R55N Delayed DRIVE/REVERSE Engagements
- Lighting - Moisture in Headlamp Assembly
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Brakes - ABS/ATS Lamp ON/DTC's C1288 and C1289 Set
- Restraints - Seat Belts Slow to Retract
- A/C - Musty Odors
- PCM - No Start/Theft Warning Lamp Flashes
- A/T - Inadvertent Shift Interlock Disabling
- Lights - License Plate lamp Retention Clips
- Half Shafts - Rear End Moaning/Droning Noises
- Suspension - Noise Accelerating at Highway Speeds
- High Pitched Gear Whine While Driving
- Body - Rear License Plate Loose
- Air Bag System - Lamp ON/DTC's B1994/B1998 Set
- Seats - Lack of Comfort
- A/T - 5R55N Oil Pan Drain Plug Fluid leak
- A/C - Heater Core Electrolysis/Leakage
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Engine - Drive Belt Snap Noise In Extreme Cold
- Factory Modifications
- Recommended Repairs
- Superceded Bulletins
- 99-17-4 - 08/23/98
- Power Window (Rear Door) - Inoperative
- Rear Power Window - Inoperative
- Rear Window Defroster - Inoperative
- Body - Aluminum Corrosion Service Tip
- Passive Antitheft System (PATS) - Diagnostics Tips
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Restraint System - Seat Belts Slow to retract
- SRS - MIL ON/DTC's B1994/B1998 (Side Air Bag) Set
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Electrical - Ground Locations/Diagnostic Tips
- Battery - Service/Charging Tips
- Battery - Discharged/Engine No Crank Condition
- Battery - Charging Tips and Guidelines
- Brakes - ABS/ATS DTC's B1288/B1289 Service Tips
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- A/T 5R55N - Delayed Shifts/Harsh Shifts
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON/EVAP System DTC's Set
- A/C, DATC - No Cooling From Side Vents
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Steering Wheel - Nibble/Hum/Boom/Vibration
- Engine - Oil Recommendations/Applications
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- Ignition System - Hesitation/Rough Running/MIL ON
- Engine Controls - Hard Cold Start/Flooding
- All Technical Service Bulletins
- EATC - No Setpoint/Blower Stays on HIGH
- EATC - Inaccurate Ambient Temperature Displayed
- ATC - Poor/No Cooling From L/H or R/H Vents
- Air Conditioning - DATC Operation/Service
- A/C System - Diagnosis and Service Tips
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Electrical - Low/Dead Battery/No Crank Condition
- Recall - Fuel Transfer Hose and Clamp Replacement
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Recall - Engine Coolant Thermostat Defect
- A/C - Lack of Cooling From Driver/Passenger Vents
- Recall 00V359001: Ball Joint Stud Fractures
- Recall - Lower Ball Joint Inspection
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Lincoln Procedure Announcement Letter
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Attachment IV
- Supplement # 1 - Owner Letter
- Wheels/Tires - Road Force Measurement Equipment
- Power Window - Squeaking/Creaking Noise When Operated
- Power Windows - Rear Window Inoperative
- A/T - Filter Improperly Installed (Stall/Engagement)
- A/T - Cooler Flushing Service Tips
- Campaign - PCM Reprogramming
- Engine Controls - Cold Engine Flooding/Hard Start
- Emissions/Engine Controls - Driveability Diagnosis
- Engine Controls - No Start/Hard Start/Rough Idle
- Steering - Vibration/Noise/Steering Wheel Nibble
- ABS Wheel Speed Sensor - Service Tips
- Brake Pedal - Popping Noises
- Ignition System - Engine Misfire/DTC's Set
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- PCM - Hard Start/Multiple Driveability Complaints
- PCM - Driveability Complaints
- PCM - MIL ON, DTC's P0350/P0360 Set
- A/T - 5R55N Delayed DRIVE/REVERSE Engagements
- Engine Controls - General PCM Programming Procedures
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Lighting - Moisture in Headlamp Assembly
- Engine Head Gasket - Approved Replacement Procedures
- Campaign - Steering Wheel/Shifter Knob Retrofit
- PATS System - Diagnostic Service Tips
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Brakes - ABS/ATS Lamp ON/DTC's C1288 and C1289 Set
- Engine Controls - MIL ON/Lean DTC Service Tips
- Rain Sensor Wipers - System Information
- Restraints - Seat Belts Slow to Retract
- Body - Exterior Mirror Glass/Motor Service Tips
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - Orange Prior To Repair Tag/Service Procedure
- A/T - 5R55N Service Instructions
- A/T - (5R55N) Fluid Level Checking Procedure
- A/T - 5R55N Shift Adaptive Pressure Control Strategy
- A/T - In Line Fluid Filter Kit
- A/T - Fluid Level Checking/Filling Tool and Procedure
- A/C - Musty Odors
- Climate Control - Blower Control Service Tips
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- PCM - No Start/Theft Warning Lamp Flashes
- Electrical Grounds - Locations/Fault Diagnostics
- Electrical - Wiring Soldering/Crimping Service Tips
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Cruise Control - Diagnostics Updates
- Keyless Entry System - Service Tips
- A/T - Inadvertent Shift Interlock Disabling
- Lights - License Plate lamp Retention Clips
- Seat Belts - Warning System Operation
- Half Shafts - Rear End Moaning/Droning Noises
- Suspension - Noise Accelerating at Highway Speeds
- A/C - Identification of Non Approved Refrigerants
- High Pitched Gear Whine While Driving
- Body - Rear License Plate Loose
- A/T - 5R55N Select Shift Selector Operation
- Air Bag System - Lamp ON/DTC's B1994/B1998 Set
- Campaign - Rear Seat Latch Owner's Guide Update
- Seats - Lack of Comfort
- Brakes - Vibration/Inspection Service Tips
- A/T - 5R55N Oil Pan Drain Plug Fluid leak
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Body - Aluminum Body Panels - Corrosion
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Engine - Drive Belt Snap Noise In Extreme Cold