Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Engine - Long Crank Times, Rough Idle, Hesitation
- A/C - Chemical Type Odor
- A/C - Lack of Heat to Floor Area
- A/C - Poor Performance, Insufficient Cooling
- A/C - Vibration Noise From Under Dash
- Engine - Oil Leaks Around Oil Pan Area
- Engine - Oil Leaks
- Engine - Oil Leak Diagnosis
- Radio - Interference from Electric Fuel Pump
- AM/FM Radio - Whining/Buzzing Noise
- Audio System - Electrical Noise from Fuel Pump
- Audio System - Whining/Buzzing Noise From Speakers
- A/C - Inadequate Heating On Driver Side Floor
- Heater - Inadequate Heating on Driver's Side
- Engine - Knocking/Chattering Noises
- HLA - Noise After Long Storage
- Engine - Roaring Noise From Fan Clutch
- Engine Mount/Exhaust System - Vibration
- Exhaust Heat Shields - Buzzing/Rattling Noise
- Exhaust System - Buzzing/Rattling
- Frame - Snapping or Popping Noise
- Power Door Locks - Lock Actuator Bracket Loose
- Seat Covers - Cut Too Short
- Seat, Front - Will Not Move or Difficult to Move
- Door Weatherstrip - Wind Noise Around Doors
- Steering Column - Rattles, Loose Tilt Control Lever
- Driveline - Ping Or Creak Noise
- Driveline - Ping/Creak Noise
- Drive Axle - Vibration and Resonance During Acceleration
- Transfer Case - Remains in 4WD Even After Shifted to 2WD
- Transfer Case - Vibration or Moan During Acceleration
- A/T - Torque Converter Vibration or Resonance Noise
- Clutch - Gear Grinding or Weak Pedal Feel
- Exhaust - Sulfur Odor
- Engine Controls - Hard Start, Rough Idle, and Stalling
- Idler Pulley - Squeal On Start Up
- Brakes, Rear - Grab/Squeal
- Rear Brakes - Squeal/Grab
- Front Brakes - Drag After Being Applied
- Ignition Switch - Hard Start
- Engine - Rough Idle, No Start or Hard Start
- Ignition Control Module - MIL ON/Driveability Concerns
- Engine - Rough Idle/No Start
- Fuel Line - Knocking Noise
- Fuel System - Knocking Noise from Fuel Line
- Engine Performance - Hard Starting, Poor Driveability,
- Rear Defogger - Inoperative
- AM Radio - Noise & Reception Problems
- Radio - Static, Motor/Ignition Noise, No Speaker Sound
- Seat Belts - Twisted at D Ring or Tongue
- Seat Belts - Will Not Reach Fully Across Occupants Lap
- Brakes - Judder/Vibration/Pulsation
- Fuel Gauge - Reads Below Full
- Speedometer - Reads Higher Than Actual Vehicle Speed
- MIL On Intermittently, KOER DTC 41 or 42 Set
- Suspension, Front - Rattle, Clunk, or Pop Noise
- Radius Arm Insulator, Front - Rattle Noise
- Front Suspension - Rattle/Clunk/Pop/Creak/Squeak
- Suspension - Rattle From Front Passenger Side
- Transfer Case - Delayed, or No 4WD Engagement
- Automatic Locking Hubs - Ratcheting Noise
- Auto Locking Hubs - Diagnosing Noise Concerns
- Windshield - Molding Partially Dislodged From the Glass
- Rear View Mirror, Outside - Vibrates While Driving
- Mirror, Rearview - Falls Off
- M/T - Grinding Noise Shifting from 2nd to 3rd Gear
- Audio System - AM Band Noise/Reception Concerns
- Steering, Brakes, Suspension - Drift/Pull
- Vehicle - Fuel Deterioration During Long Storage Periods
- Cruise Control - Intermittent or Inoperative
- Paint, Clear Coat - Cracking
- Running Boards - Noise/Vibration
- A/T - Increase in RPM During 2 to 3 Upshift
- Exhaust - Heat Shield Rattles
- Exhaust - Buzzing or Rattling Noise
- Front Seat - Will Not Move or Difficult to Move
- Seats - Move Slightly Forward on Deceleration
- M/T - Grinding Noise In 2ND, 3RD, & 4TH Gear Lock Up
- Suspension - The Vehicle Drifts or Pulls to the Right
- Audio System - Whining/Buzzing Noise From Radio Speakers
- Front Seat - Foam Seat Cushion Exposed
- Passenger Seat Back - Rattles When Unoccupied
- Chemicals,Additives
- Labor/Parts Updates
- Manual Updates
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Interior - Console Damage Prevention During Removal
- Fuel System - Fuel Ethanol Content Testing
- Mirrors - Door Mirror Glass Is Loose
- Wheels/Tires - Tire Pessure/Rotation Information
- Mirrors - Interior Mirror Removal
- Electrical - Lightning Strike Information
- Wheels - Aluminum Wheel Cleaning Precautions
- Vehicle - Service Manual Updates
- Special Tools - Storage Cabinet System
- Required Tools - Inventory List
- Tools - Shipment Of NGS Program Card Version 2.0
- Wire Harness - Repair Kit Availability
- Wire Harness - Terminal & Repair Kit Available
- Quality Assurance - Technical Assistance 800 Phone Lines
- Recall - Fuel Tank Hear Shield, Rear Bumper
- Emission Inspection Test - Proper Preparation
- Emissions - Proof of Recall Correction Certificate
- Engine - Long Crank Times, Rough Idle, Hesitation
- Ignition - Digital Meter Use With Pinpoint Tests
- Engine - Proper Oil Filling Procedure
- Vehicle - Beginning VIN
- Vehicle - Drift/Pull While Braking/Steering Diagnostics
- Vehicle - Drift While Braking & Steering Diagnosis
- Vehicle - Drift/Pull While Braking and Steering
- A/C - 0 Ring Replacement
- A/C - Chemical Type Odor
- A/C - Lack of Heat to Floor Area
- A/C - Poor Performance, Insufficient Cooling
- A/C - Vibration Noise From Under Dash
- A/C - Install Filter Kit When Replacing Compressor
- A/C - O Ring Replacement
- Engine - Oil Leaks Around Oil Pan Area
- Engine - Oil Leaks
- Engine - Oil Leak Diagnosis
- Coolant - Propylene Glycol Based Not Recommended
- Radio - Interference from Electric Fuel Pump
- AM/FM Radio - Whining/Buzzing Noise
- Audio System - Electrical Noise from Fuel Pump
- Audio System - Whining/Buzzing Noise From Speakers
- A/C Compressor - Revised
- A/C System - Filtering Procedure
- A/C - Inadequate Heating On Driver Side Floor
- Heater - Inadequate Heating on Driver's Side
- Front Wheel Bearings - New High Temperature Grease
- Engine - Knocking/Chattering Noises
- HLA - Noise After Long Storage
- Rear Oil Seal - Installation Revision
- Engine - Partial Repair Components Available
- Engine - Roaring Noise From Fan Clutch
- Engine Mount/Exhaust System - Vibration
- Exhaust Heat Shields - Buzzing/Rattling Noise
- Exhaust System - Buzzing/Rattling
- Tire Chains - Installation Precautions
- Recall - Firestone Tire Recall
- Frame - Snapping or Popping Noise
- Frame - Rivet Replacement
- Recall 91V028000: Bumper Separation When Towing
- Bumper - Painting Preparation
- Power Door Locks - Lock Actuator Bracket Loose
- Seat Covers - Cut Too Short
- Seat, Front - Will Not Move or Difficult to Move
- Door Weatherstrip - Wind Noise Around Doors
- Recall 97V235002: Sunroof Glass Panel Separation
- Recall 97V235000: Sunroof Glass Panel May Separate
- Steering Column - Rattles, Loose Tilt Control Lever
- Steering Column/Blind Rivet Replacement-Manual Revision
- Steering, Ignition - Lock Cylinder Replacement
- Driveline - Ping Or Creak Noise
- Driveline - Ping/Creak Noise
- Drive Axle - Vibration and Resonance During Acceleration
- Transfer Case - Remains in 4WD Even After Shifted to 2WD
- Transfer Case - Vibration or Moan During Acceleration
- A/T - Torque Converter Vibration or Resonance Noise
- Clutch - Gear Grinding or Weak Pedal Feel
- Exhaust - Sulfur Odor
- Engine Controls - Hard Start, Rough Idle, and Stalling
- Air Flow Meter - Service Precautions
- Idler Pulley - Squeal On Start Up
- Brakes, Rear - Grab/Squeal
- Rear Brakes - Squeal/Grab
- Recall 96V024000: Master Cylinder Studs May Fracture
- Front Brakes - Drag After Being Applied
- Recall 96V024002: Brake Booster Replacement
- Battery - Ignition OFF Draw Current Diagnosis
- Battery - Diagnostic and Charging Procedures
- Ignition Switch - Hard Start
- Engine - Rough Idle, No Start or Hard Start
- Ignition Control Module - MIL ON/Driveability Concerns
- Engine - Rough Idle/No Start
- Fuel Line - Knocking Noise
- Fuel System - Knocking Noise from Fuel Line
- Recall 91V020000: Fuel Tank Damage
- Engine Performance - Hard Starting, Poor Driveability,
- Throttle Adjustment Screw - Adjustment Precaution
- Rear Defogger - Inoperative
- AM Radio - Noise & Reception Problems
- Radio - Static, Motor/Ignition Noise, No Speaker Sound
- Seat Belts - Twisted at D Ring or Tongue
- Seat Belts - Will Not Reach Fully Across Occupants Lap
- Brakes - Rotor and Drum Inspection Criteria
- Brakes - Use On Car Brake Lathe to Correct Judder
- Brakes - Judder/Vibration/Pulsation
- Ignition System - Pinpoint Test Ohm Meter Usage
- Fuel Gauge - Reads Below Full
- Speedometer - Reads Higher Than Actual Vehicle Speed
- Speedometer - Replacement Procedure
- Suspension, M/T, ABS,- Manual Corrections
- Roof Drip Rail - Sealer Information
- Vehicle - Emission Calibration Label
- NGS System - Reprogramming Service
- MIL On Intermittently, KOER DTC 41 or 42 Set
- Year 2000 - Computer Systems Compliance
- Star Tester - New Version Program Cards
- Hood Latch - Lubrication Maintenance
- Suspension, Front - Rattle, Clunk, or Pop Noise
- Radius Arm Insulator, Front - Rattle Noise
- Front Suspension - Rattle/Clunk/Pop/Creak/Squeak
- Suspension - Rattle From Front Passenger Side
- Transfer Case - Delayed, or No 4WD Engagement
- Automatic Locking Hubs - Ratcheting Noise
- Auto Locking Hubs - Diagnosing Noise Concerns
- Windshield - Molding Partially Dislodged From the Glass
- Rear View Mirror, Outside - Vibrates While Driving
- Rear View Mirror R & I - Manual Revision
- Mirror, Rearview - Falls Off
- Roof Rack - Installation Caution
- Engine - Oil Recommendations
- Brake Lines - Sweating Is a Normal Condition
- Brake Lines - Sweating
- A/T - Diagnostic Procedures
- Fuel System, A/T - Manual Corrections
- A/T - Workshop Manual Revisions
- A/T - Transmission Spring In Converter Channel
- A/T - Repair Policies
- A/T - A4LD Slipping or Soft Shifts After Rebuild
- A/T - A4LD Front Seal Blow Out
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Pump Damage After Overhaul
- A/T - Binding Condition In Park
- A/T - E40D Second Gear Starts
- A/T - A4LD, 4R44E/4R55E Pump Interchangeability
- A/T - A4LD Bellhousing & Pump Interchange
- A/T - A4LD Support Ring Identification
- A/T - A4LD/C3 Front Pump Support Inspection
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - A4LD Overdrive Sun Gear Support Inspection
- A/T - A4LD Delay In Reverse/Occasional No-Reverse
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Grinding Noise Shifting from 2nd to 3rd Gear
- Audio System - AM Band Noise/Reception Concerns
- CD Auto Changer - Dramatic Volume Increase
- Steering, Brakes, Suspension - Drift/Pull
- Engine - Oil Filling Precautions
- Fuel Injector - Cleaner Kit for Improved Performance
- Vehicle - Fuel Deterioration During Long Storage Periods
- Cruise Control - Intermittent or Inoperative
- Alignment - Optimum Specifications
- Alignment - Background Information & Specifications
- Paint, Clear Coat - Cracking
- Paint - Color Codes
- Stone Shield Paint - Protection Kit
- Running Boards - Noise/Vibration
- A/T - Increase in RPM During 2 to 3 Upshift
- Exhaust - Heat Shield Rattles
- Exhaust - Buzzing or Rattling Noise
- Recall 91V189001: Defective A/T Parking Prawl
- Front Seat - Will Not Move or Difficult to Move
- Seats - Move Slightly Forward on Deceleration
- Front Axle - Identification Tag Information
- A/C Refrigerant - Recommendations
- A/C - R134a Training/Equipment Requirements
- M/T - Grinding Noise In 2ND, 3RD, & 4TH Gear Lock Up
- A/C - O-Ring Replacement
- Fuel Volatility - Driveability Concerns
- Fuel - California Reformulated Gasoline
- Steering/Suspension - Alignment Settings
- Suspension - The Vehicle Drifts or Pulls to the Right
- Audio System - Whining/Buzzing Noise From Radio Speakers
- Seat Belt - Extender Availability
- Seat Belt - Extenders
- Front Seat - Foam Seat Cushion Exposed
- Passenger Seat Back - Rattles When Unoccupied
- Wheels - Wheel Lock Installation Precautions
- Wheels - Stain Prevention Information
- Fuel System - Ethanol Fuel Usage