Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Interior - Water Leaks
- A/C - Odor From the Ventilators
- A/T - Hold Lamp Goes ON/OFF, DTC 55 Pulse Generator
- Emissions - Coolant Leak at BAC Valve
- A/C Compressor - Continuous Engagement
- Cowl Area - Wet Passenger Carpet, Inoperative Blower
- Steering - Rattling Noise from Front Passenger Side
- Engine - Constant Rough Idle, Black/Blue Exhaust Smoke
- HLA - Noise After Long Storage
- Engine - Piston Slap Noise
- Radiator Fan - Operates On Low Speeds Only
- Engine - Low, Rough Idle, Vibration in DRIVE
- Engine, Radiator Mounts - Vibration During Idle in DRIVE
- A/C - Receiver/Drier Inlet/Outlet Pipes Leak
- A/C - REC/Fresh Control Lever Hard to Operate
- Wheels, Aluminum - Hard to Remove
- Power Locks - Drivers Lock Won't Lock/Unlock Other Doors
- Window Regulator - Improper Operation
- Seat, Drivers - May Not Adjust Up or Down
- Static Electricity Shock - Recommended Antistatic Sprays
- Door Weatherstrip - Wind Noise Around Doors
- Windows/Mirrors - Wind Noise
- Body - Water Leaks To The Interior
- Body - Water Leak In Front Floor, Headliner, Trunk Area
- A/T - 2nd to 3rd Gear Splippage or Flare Up
- A/T - ATF Leakage from Cooler Line
- Clutch Pedal - Returns Slowly in Extremely Cold Weather
- CPU - Inoperative, Electrical Malfunction
- Intermediate Steering Shaft - Growl Noise
- Fuel - Rough Idle Within 15 Seconds After Cold Start
- Engine Oil Pressure Switch - Revised
- Headlight - Flickering at Idle or On Unpaved Roads
- Headlight - Flicker at Idle or On Unpaved Roads
- A/C - Insufficient Cooling
- Cylinder Head Cover Gasket - Seepage
- Parking Brake Cable - Groan Noise From Rear Suspension
- Steering Wheel - Slightly Off Center.
- Windows - Wind Noise Diagnosis
- Door Trim - Revised
- Door Trim - Separated
- Trunk/Lamp Assembly - Water Intrusion
- Belt Line Moulding - Revised
- Combination Lamp, Rear - Water Leakage From Mounting
- Engine - Hydraulic Lash Adjuster Noise Returning to Idle
- Center Console Lid Lock - Loose, Rattling Noise
- Power Steering Hose - Revised Ground Bolt Length
- Power Steering - Noise
- A/T - Hard Shift During Light Throttle
- A/T - Poor Shift Quality
- M/T - Erratic Operation or Excessive Wear
- Engine Mount - New Tightening Torque
- Trailing Arm Link - Revised to Eliminate Noise
- Idle Speed - Fluctuation/Hunting
- Assist Handle - Falls Off
- Assist Handle - Cap Falls Off
- Seat Trim, Front - Material Looks Worn Out
- A/T - Valve Body Revisions Improve Shift Quality
- Sunvisor - Will Not Go Up or Down
- Chemicals,Additives
- Labor/Parts Updates
- Manual Updates
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Interior - Console Damage Prevention During Removal
- Fuel System - Fuel Ethanol Content Testing
- Mirrors - Door Mirror Glass Is Loose
- Wheels/Tires - Tire Pessure/Rotation Information
- Mirrors - Interior Mirror Removal
- Electrical - Lightning Strike Information
- Wheels - Aluminum Wheel Cleaning Precautions
- Special Tools - Storage Cabinet System
- Required Tools - Inventory List
- Tools - Shipment Of NGS Program Card Version 2.0
- Vehicle - Proper Use of Corporate Logo
- Tools - Using the EC/At Tester
- Emission Inspection Test - Proper Preparation
- Emissions - Proof of Recall Correction Certificate
- Interior - Water Leaks
- A/T - Proper Control Unit Connection
- A/C - Wiring Harness Modification
- Vehicle - Beginning VINS
- Campaign - Reverse Clutch Pistion Failure
- Recall - Outer Front Door Handle
- A/C - 0 Ring Replacement
- A/C - O Ring Installation Procedure
- A/C - Odor From the Ventilators
- A/C - Installation Updates
- A/C - Diagnosis & Repair of Refrigerant Leaks
- A/C - Front Harness Revised
- A/C - O Ring Set
- Refrigerant - Importance of Correct Charge Level
- A/C - O Ring Replacement
- A/T - Hold Lamp Goes ON/OFF, DTC 55 Pulse Generator
- A/C - Manual Corrections
- Coolant - Propylene Glycol Based Not Recommended
- Emissions - Coolant Leak at BAC Valve
- Battery - Dies In A relatively Short Period Of Time
- Secondary Air Injection - Coolant Leak, Idle Speed Hunt
- Electronic Devices/Electrical - Diagnosis and Repair
- A/C Compressor - Continuous Engagement
- Cowl Area - Wet Passenger Carpet, Inoperative Blower
- Steering - Rattling Noise from Front Passenger Side
- Engine - Constant Rough Idle, Black/Blue Exhaust Smoke
- HLA - Noise After Long Storage
- Engine - Piston Slap Noise
- Engine - Partial Repair Components Available
- Cooling System - Allowable Replacement Thermostat Set
- Recall 88V022000: Throttle Frosted/Slow Return To Idle
- Radiator Fan - Operates On Low Speeds Only
- Engine - Low, Rough Idle, Vibration in DRIVE
- Engine, Radiator Mounts - Vibration During Idle in DRIVE
- A/C - Receiver Drier Fuse Plug Elimination
- A/C - Receiver/Drier Inlet/Outlet Pipes Leak
- Receiver Dryer - Replacement Criteria
- A/C - REC/Fresh Control Lever Hard to Operate
- Wheels, Aluminum - Hard to Remove
- Tire Chains - Installation Precautions
- Original Equipment - Tires Listed
- Power Locks - Drivers Lock Won't Lock/Unlock Other Doors
- Window Regulator - Improper Operation
- Seat, Drivers - May Not Adjust Up or Down
- Static Electricity Shock - Recommended Antistatic Sprays
- Door Weatherstrip - Wind Noise Around Doors
- Windows/Mirrors - Wind Noise
- Body - Water Leaks To The Interior
- Body - Water Leak In Front Floor, Headliner, Trunk Area
- A/T - 2nd to 3rd Gear Splippage or Flare Up
- A/T - ATF Leakage from Cooler Line
- Clutch Pedal - Returns Slowly in Extremely Cold Weather
- Fuel Injector - Checks for Proper Installation
- CPU - Inoperative, Electrical Malfunction
- ECU - No Interchangeability Between New and Old Unit
- EGI Control Unit - Remanufactured Exchange Program
- EGI Control Unit - Remanufactured Parts Available
- Air Flow Meter - Nuts May Fall Into Engine
- Intermediate Steering Shaft - Growl Noise
- Battery - Current Draw
- Battery - Factory Added Sediment Mistaken for Sulfate
- Battery, Maintenance Free - Characteristics of MF Type
- Battery, Maintenance Free - Charging & Testing
- Fuse Block, Main - Melt Down Causes Battery Discharge
- Fuel - Rough Idle Within 15 Seconds After Cold Start
- Fuel - Use of Regular Unleaded Gasoline
- Throttle Adjustment Screw - Adjustment Precaution
- Charcoal Canister - Routing of Drain Hose
- Recall 87V149000: Floor Mat/Accelerator Inteference
- Audio Set - Identification Number
- Recall 88V063000: Automatic Seat Belt Partial Movement
- Brakes - Use On Car Brake Lathe to Correct Judder
- A/T - MTX Primary Shaft Revision
- Engine Oil Pressure Switch - Revised
- Speedometer - Replacement Procedure
- Headlight - Flickering at Idle or On Unpaved Roads
- Headlight - Flicker at Idle or On Unpaved Roads
- Wiper Motor - Inoperative/Circuit Breaker Operation
- Cooling Fan Relay - Relocated to Prevent Water Ingress
- A/C - Insufficient Cooling
- Vehicle - Manual Corrections
- Cylinder Head Cover Gasket - Seepage
- Parking Brake Cable - Groan Noise From Rear Suspension
- Steering Wheel - Slightly Off Center.
- Windows - Wind Noise Diagnosis
- S.R.T. Manual - Revisions
- Year 2000 - Computer Systems Compliance
- Star Tester - New Version Program Cards
- Recall 93V174000: Door Latch Defect
- Door Trim - Revised
- Door Trim - Separated
- Trunk/Lamp Assembly - Water Intrusion
- Windshield Moulding - Water Stain Prevention
- Belt Line Moulding - Revised
- Combination Lamp, Rear - Water Leakage From Mounting
- Coolant - Reconditioned Antifreeze, Not Recommended
- Engine - Hydraulic Lash Adjuster Noise Returning to Idle
- Center Console Lid Lock - Loose, Rattling Noise
- Power Steering Hose - Revised Ground Bolt Length
- Power Steering - Noise
- A/T - Diagnostic Procedures
- A/T - Problems W/Aftermarket Accessories to Wired EC-AT
- A/T - Rebuilt Assemblies
- A/T - EC/At Replacement
- Tools - Service & Repair for EC-AT
- A/T - Hard Shift During Light Throttle
- A/T - Poor Shift Quality
- A/T - Rebuilt Transaxle Identification Number Locations
- A/T - Specified Manual Shift Lock Nut Torque
- A/T - G4A, 4EAT Sprag Rotation
- A/T - G4A, 4EAT Pressure Tap Locations
- A/T - G4A, 4EAT Valve Body Identification
- A/T - Engine Vacuum Testing
- A/T - G4A-EL Engine Stalls In Gear/TCC Stays Locked-up
- A/T - G4A-EL/4EAT Low Pump Pressure
- A/T - G4A-EL/4EAT Repeated Reverse Clutch Failure
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - F4EAT Diagnostic Information
- A/T - G4A-EL, 4EAT Erratic Pressure Rise
- A/T - G4AEL, G4AHL, F4EAT, F4AEL Shift Feel Complaints
- A/T - G4A-EL Retrieving Trouble Codes
- A/T - Failsafe Modes
- A/T - Slipping/Vehicle Does Not Move After Rebuild
- A/T - Low OR No Line Pressure Rise/Worn Throttle Cam
- A/T - 4EAT, G4A-EL Engine Stalls In Drive
- A/T - Reverse Piston Return Spring Revised
- A/T - G4AEL/4EAT DTC 60, 61, 62, or 63/Pinched Wires
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - G4A-EL, 4EAT Engagement Problems
- A/T - G4A-EL 3-4 Shift Hunt
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- A/T - G4A-EL & F4EAT Trouble Code Identification
- M/T - Erratic Operation or Excessive Wear
- Tools - Shim Selector
- Engine Mount - New Tightening Torque
- Trailing Arm Link - Revised to Eliminate Noise
- Main Fuse Block - Loose Cables Cause Overheating
- Fuel Injector - Cleaner Kit for Improved Performance
- Idle Speed - Fluctuation/Hunting
- Cruise Control - OE Replacement Recommended
- Alignment - Specifications
- Alignment - Background Information & Specifications
- Back Window - Side & Lower Molding Installation
- Shoulder Belt - Auxiliary Anchor Point
- Seat Belt Harness - Modification
- Assist Handle - Falls Off
- Assist Handle - Cap Falls Off
- Seat Trim, Front - Material Looks Worn Out
- Audio System - Troubleshooting
- A/T - Valve Body Revisions Improve Shift Quality
- Recall 87V196000: Wheel Cylinder Contamination
- Sunvisor - Will Not Go Up or Down
- A/C Refrigerant - Recommendations
- A/C - R134a Training/Equipment Requirements
- A/C - O-Ring Replacement
- Recall 87V186000: Fuel Tank Straps/Fuel Tank Leak
- Fuel Volatility - Driveability Concerns
- Fuel - California Reformulated Gasoline
- Pre Alignment - Specifications
- Wheels - Wheel Lock Installation Precautions
- Wheels - Stain Prevention Information
- Fuel System - Ethanol Fuel Usage