Center Console - Rattle Noise
Bulletin No.: 003/94Issued: 1/13/94
Revised
Category
S
Applicable Model/s
1992-93 929
Subject:
RATTLE NOISE FROM CENTER CONSOLE
This bulletin replaces Service Bulletin Cat. S, No. 050/93. Replace the original bulletin with this copy.
APPLICABLE MODELS/VINS
929
1992 - Vehicles with a VIN of JM1HD461*N0100001 through JM1HD461*N0199999
1993 - Vehicles with a VIN of JM1HD461*P0200001 through JM1HD461*P0212374
NOTE:
The asterisk (*) in the VIN range can be any number (0 through 9) or "X".
DESCRIPTION
A rattling noise may be heard from the center console. The noise is most evident when driving over rough roads. This noise is caused by a loose console lid.
To correct this condition, the striker on the console lid has been modified.
REPAIR PROCEDURE
To eliminate the noise, install two plastic rivets (fasteners) in the console lid. This will reduce the gap between the console and the lid. Follow the instructions below.
1. Open console lid and mark the console rubber cushions with chalk.
2. Close the console to transfer the chalk marks from the cushions to the lid.
3. Carefully drill a 5 mm hole in the lid in the two areas indicated by the chalk.
NOTE:
Do not drill the hole larger than 5 mm. Do not drill through the console lid. Install a drill stop if necessary.
4. Remove 6 mm from the bottom of the plastic rivet (fasteners) and install them in the holes.
PARTS INFORMATION
Part Number Description Qty
M001 58 787 Fastener 2
WARRANTY INFORMATION
(Applies to vehicles covered under normal vehicle warranty)
Warranty Type: A
Symptom Code: 82
Damage Code: 99
Part Number Main Cause: M001 58 787
Quantity: 2
Operation Number: XX0595RX
Labor Hours: 0.2 Hrs.