Door Windows - Wind Noise

Bulletin No.: 002/93
Issued: 2/5/93
Revised

Category
S

Applicable Model/s
1993 RX-7

Subject:
WIND NOISE FROM THE DOOR WINDOWS

AFFECTED VINS

This bulletin applies to 1993 vehicles with a VIN of JM1FD3***P0205708 or lower produced through April 30, 1992.

This bulletin does not apply to vehicles with a VIN equal to or greater than VIN of JM1FD3***P0205709 and produced after April 30, 1992.

DESCRIPTION

Some vehicles may experience a wind noise from the right and left door windows (near the outside door handles). This noise is due to air entering the cabin area. When completely rolled up, the windows do not fit flush against the glass channel.

REPAIR INFORMATION





Inspect the vehicle for excessive clearance. See figure above. If the above condition exists, replace the affected glass guide(s) with a modified part. See figure. The glass guide has been modified to reduce the sliding resistance between the glass and glass channel. This modification makes the glass fit flush against the glass channel.

Removal and installation procedures are outlined in Section S of the applicable Workshop Manual.





PARTS INFORMATION

WARRANTY INFORMATION
(Applies to vehicles covered under warranty.)

Warranty Type Code: A
Customer Comment Code: 82
Damage Code: 97
Part No. of Main Cause: FD01 58 601B, FD01 59 601B
Operation No: S1004XRX
Labor Hours: 0.6 hrs. (one side)