Sunroof - Rattle Noise
Bulletin No.: 010/95Issued: 2/28/95
Revised:
Applicable Model/s
See Below
Subject:
SUNROOF RATTLE NOISE
APPLICABLE MODELS/VIN
ALL 1993-94 626
1995 626 model vehicles with a VIN of 1YVGE22C7S5318295 or lower
DESCRIPTION
During normal driving with the sunroof open, a rattle may be heard. If a customer complains of this noise, perform the repairs listed in this bulletin.
REPAIR PROCEDURE
1. Verify the complaint.
2. Tilt the sunroof fully and remove and retain the four (4) T-25 "torx" screws from the sunroof glass panel.
3. Carefully remove the sunroof glass panel.
NOTE:
Store panel in a safe area until after repair is complete.
4. Verify that two (2) black foam rectangles are installed on the drip rail. Refer to Fig. 1
NOTE:
If the foam rectangles are GRAY, remove them. Use alcohol to remove the residue adhesive.
5. After the alcohol has dried, press two (2) new BLACK foam retangles (included in the service kit) onto the drip rail where the gray foam retangles were removed. Refer to Fig. 2
NOTE:
Press firmly when installing the new foam retangles, foam has adhesive back.
6. Remove and retain "C" clips from the front guide assemblies. Refer to Fig. 1
7. Gently pull upward on the front guides to expose the collissa portion of the assembly. Refer to Fig. 3 for identification of collissa.
8. Use alcohol to wipe away any grease from the collissa portion of the guide assemblies.
9. After alcohol has dried, place the black felt pads (included in the service kit) on each collissa arm and fold over as shown. Refer to Fig. 3
NOTE:
Press firmly when installing felt, felt has adhesive back.
10. Install collissa into front guide assemblies.
11. Install front guide pins and "C" clips.
12. Install sunroof glass.
13. Verify repair.
PARTS INFORMATION
Part Number Description Qty
GC1M 69 PADS Pad Kit 1
WARRANTY INFORMATION
(Applies To Verified Customer Complaints On Vehicles Covered Under Normal Warranty Refer To The SRT Microfiche For Warranty Term Information.)
Warranty Type: A
Symptom Code: 93
Damage Code: 82
Part Number Main Cause: GC1M 69 PADS
Quantity: 1
Operation Number: YY0182RX
Labor Hours: 0.3 Hrs.