Body - Driver's Door Does Not Lock
TSB: 09-041/062006 MAZDA5 - DRIVER'S DOOR DOES NOT LOCK
APPLICABLE MODEL(S)/VINS
2006 Mazda5 vehicles with VINS lower than JM1CR******125692 (produced before April 17, 2006)
DESCRIPTION
On some vehicles, the driver's door can be opened from the outside after it is locked with the key or the remote transmitter and the door lock inside the vehicle indicates the door is locked. This is caused by the lock lever of the door lock moving out of position. To fix this problem, the lock position of the lock lever has been enlarged.
Customers having this concern should have their vehicle repaired using the following repair procedure.
REPAIR PROCEDURE
1. Verify customer concern.
2. Record the customer's radio station presets.
3. Disconnect the negative battery cable.
4. Replace the driver's door lock assembly (door latch and lock actuator) and door lock striker with modified ones. Refer to Workshop Manual section 09-14 FRONT DOOR LATCH AND LOCK ACTUATOR REMOVAL/INSTALLATION and 09-14 DOOR LOCK STRIKER REMOVAL/INSTALLATION.
5. Reconnect the negative battery cable.
6. Verify repair.
7. Reset the customer's radio station presets.
PART(S) INFORMATION
WARRANTY INFORMATION
NOTE:
^ This warranty information applies only to verified customer complaints on vehicles eligible for warranty repair. Refer to the Warranty Wizard for warranty term information.
^ Additional diagnostic time cannot be claimed for this repair.
Disclaimer