Front Drain Hose

REMOVAL




1. Remove the following parts:
1. Front door
2. Sail garnish
3. A-pillar trim
4. Front scuff plate inner
5. Rear scuff plate
6. B-pillar lower trim
7. Front seat belt upper anchor installation bolt
8. B-pillar upper trim
9. Rear package tray lid
10. Sub-trunk
11. Third-row seat
12. Trunk end trim
13. Rear header trim
14. Third-row seat belt lower anchor installation bolt
15. Cargo compartment light
16. Trunk side trim
17. Second-row seat belt upper anchor installation bolt
18. C-pillar trim
19. Map light
20. Sunvisor
21. Assist handle
22. headliner
23. Front side trim
24. Side panel (passenger's side)
25. Side wall
26. Front console
27. Glove compartment
28. Lower panel
29. Center panel unit
30. Selector lever component
31. Driver-side air bag module
32. Meter hood
33. Lower column cover
34. Instrument cluster
35. Steering shaft
36. Climate control unit
37. Rear heat duct (1).
38. Windshield wiper arm and blade
39. Cowl grille
40. Dashboard

2. Disconnect the front drain hose from the sunroof frame.
3. Remove the front drain hose from the clips.
4. Pull the front drain hose into the vehicle interior and remove the front drain hose.

INSTALLATION

CAUTION: If the front drain hose is pinched or bent at any point, the water in the hose may not drain and could leak inside the vehicle. During and after installation of the trims and headliner, always make sure there is no interference with the front drain hose. Correct any abnormality if found.

1. Apply soapy water to the part of the sunroof frame where the front drain hose is inserted.
2. Insert the front drain hose end into the sunroof frame.
3. Install the front drain hose to the clips parallel to the pillar and free of looseness.
4. Insert the front drain hose grommet into the hole of the inner hinge pillar.
5. Install the following parts:
1. Dashboard
2. Cowl grille
3. Windshield wiper arm and blade
4. Rear heat duct (1).
5. Climate control unit [FULL-AUTO AIR CONDITIONER].)
6. Steering shaft
7. Instrument cluster
8. Lower column cover
9. Meter hood
10. Selector lever component
11. Driver-side air bag module
12. Center panel unit
13. Lower panel
14. Front console
15. Glove compartment
16. Side panel (passenger's side)
17. Side wall
18. Front side trim
19. Headliner
20. Assist handle
21. Sunvisor
22. Map light
23. C-pillar trim
24. Second-row seat belt upper anchor installation bolt
25. Trunk side trim
26. Cargo compartment light
27. Third-row seat belt lower anchor installation bolt
28. Rear header trim
29. Trunk end trim
30. Third-row seat
31. Sub-trunk
32. Rear package tray lid
33. B-pillar upper trim
34. Front seat belt upper anchor installation bolt
35. B-pillar lower trim
36. Rear scuff plate
37. Front scuff plate inner
38. A-pillar trim
39. Sail garnish
40. Front door