Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Lighting - Headlamp Unit Fogged/Droplets Forming
- Drivetrain - Oil Leak At Seam Between A/T And Transfer Case
- A/T - ECO Start/Stop Inoperative, DTC P0944 Stored In TCM
- Lighting - Headlamps/Front Fog Lamps Leaking Or Fogged
- A/T - Hard 2-3 Upshift Or Slips, No 3rd Gear/DTC's Stored
- A/C - HVAC - Foam Cleaner Information and Work Procedure
- Suspension - Strut/Shock Absorber Replacement Guidelines
- A/C - Musty/Moldy Odor Complaints, Cleaning Procedure
- Cell Phone - Call Cannot Connect/DTC D662 Set
- Brakes - Squealing/Grinding Noises From Front Brakes
- Steering - Squealing or Squeaking Noises When Turning
- Audio System - Poor Audio Quality When Using Cell Phone
- Navigation System - Wrong Destination Displayed
- Audio System - CD Skips/Magazine Stuck/Won't Eject
- Wipers/Washers - Wipers Chattering/Noisy
- Suspension - Vehicle Lowers On One Side or Corner
- Engine - Oil Leaks Between Oil Level Sensor & Oil Pan
- Suspension - Vehicle Raises/Lowers Erratically
- COMAND(R) System - Multiple System Malfunctions
- A/T - Limp Home Mode/Codes 2502/2505/P0894/P2711
- Entertainment System - CD's or DVD's Won't Eject
- A/T Controls - Limp Home Mode/Harsh Engagement
- A/T - No Power Output From A/T
- A/T - Selection Range Sensor Learning Not Possible
- Interior - Front Door Wooden Trim Panel Loose
- Interior - Seat Noise Complaints
- ABS/TCS - ABS/ESP Lamps ON/Codes C1140/C1540
- Brakes - Front/Rear Brakes Squeal
- Keyless Entry - LED on Transmitter Key Not Functioning
- Steering - Steering Gear Apparent Leakage Information
- A/T - Multiple DTC's Set/Limp Home Mode
- Interior - Sun Visor Mirror Cover/Vanity Lamp Broken
- Suspension - Remains at Raised Level/Hard Ride
- A/T - Fluid Leaks at The Electrical Connector
- Garage Door Opener - Range Too Short/Can't Program
- Interior - Seats are Dirty/Stained
- Body - Sunroof Water Leaks/Rattles
- Suspension - Front End Knock/Thump On Bumps
- Body - Door Mirror Seal Damaged
- Lighting - Auto Lamps/Rain Sensor Malfunctions
- Parking Assist System - Erroneous Activation
- Ignition System - Runs Rough/MIL ON/Misfire DTC's
- Steering/Suspension - Front End Squeak/Thump Noise
- A/T - Limp Home Mode/Multiple Codes Stored
- Engine Controls - MIL ON/Multiple O2 Sensor DTC's Set
- Navigation System - DVD Not Recognized
- Body - Corrosion Between Roof And Quarter Panel
- Body - Wind Noise Diagnostics/Repair
- Keyless Entry - Various Malfunctions
- Suspension - Height Randomly Changes
- Accessories - Can't Program Garage Door Opener
- Parking Assist System - Sensors Loose/Come Out Of Bumper
- Parking Assist System - Triggers For No Reason
- Tire Monitor System - False Warning Message Displayed
- Electrical - Suspension Message Displayed In Cluster
- Body - Front Door Window Motor Locks Up When Closing
- A/C - No Or Low A/C Cooling Performance
- Steering - Leaks At Steering Gear/Hose Junction
- ABS/TCS - ESP Service Required Mssg/Multiple Codes Set
- Emissions - Multiple Codes Set/MIL ON
- Cooling System - MIL ON/Low Engine Power
- Audio System - AM/FM Interference With Rear Defogger ON
- Body - Windshield/Rear Window Body Seam Corrosion
- Steering - Speed Sensitive Steering Malfunctions/DTC's
- Lighting - Low Beam Check Bulb Message Displayed
- A/C - Musty/Moldy Odor Issues
- A/T - Limp Home Mode/DTCs 2200/2201/2767/2768
- Engine - Oil Level Message General Information
- Suspension - Vehicle Lowers After Sitting
- A/T - 722.9, Delayed Reverse Engagement
- Engine - Oil Warning Message In Instrument Cluster
- Suspension - ABC Suspension Humming/Buzzing Noise
- A/T - Hard Converter Lock-Up/Hard 1-2 Shift
- ABS/TCS - ESP/BAS Warning and Service Light ON/DTC's Set
- A/T - Harsh Engagement From Park To Drive
- Electrical - Malfunctions in Driver and Front Passenger Door
- Drivetrain - Noises at Full Lock From Front Axle Area
- Computers/Controls - Malfunctions Of Various Power/Control Unit
- Factory Modifications
- Seals, Gaskets
- Superceded Bulletins
- S-00_40-89A - 08/10/10
- S-00_40-89 - 08/09/10
- P-46_25-71 - 01/19/10
- S-54_21-244 - 7/8/11
- S-07_61-89 - 7/08/11
- S-82_70-686 - 04/30/09
- S-01_45-26 - 05/15/09
- S-09_41-22A - 04/19/06
- S-09_41-22 - 12/21/05
- S-82_70-475 - 11/14/05
- S-46_50-34 - 03/27/06
- S-27_19-82B - 07/02/08
- S-68_05-47 - 04/11/06
- S-27_00-102A - 01/09/08
- S-27_00-102 - 11/30/07
- S-46_30-40A - 11/27/07
- S-46_30-40 - 04/26/06
- S-82_10-598 - 10/24/07
- P-32_50-35B - 02/22/08
- S-83_30-74J - 10/24/07
- S-83_30-74I - 10/08/07
- S-83_30-74H - 05/30/07
- S-83_30-74G - 05/08/07
- S-83_30-74F - 03/05/07
- S-83_30-74E - 02/28/07
- S-83_30-74D - 03/27/06
- S-83_30-74C - 10/26/05
- S-83_30-74B - 06/02/05
- S-83_30-74A - 02/04/05
- S-83_30-74 - 01/31/05
- S-14_30-15C - 11/30/07
- S-14_30-15B - 03/09/06
- S-14_30-15A - 10/04/05
- S-14_30-15 - 07/02/03
- 2006110005B - 12/01/06
- S-18_00-17E - 06/01/06
- S-18_00-17D - 04/13/06
- S-32_25-19 - 12/30/04
- S-32_25-19A - 03/15/06
- S-32_25-19B - 05/05/06
- S-32_25-19C - 07/18/07
- S-32_25-19D - 10/18/07
- S-46_25-37 - 02/01/08
- S-18_00-36 - 01/01/06
- P-27_00-47E - 01/19/07
- P-27_00-47D - 05/01/06
- P-83_30-74F - 03/05/07
- P-83_30-74E - 02/28/07
- 2006110005 - 11/17/06
- P-46_20-25 - 08/17/05
- P-27_00-47B - 04/05/05
- P-14_30-15A - 10/04/05
- P-18_40-29 - 08/15/05
- P-00_00-73 - 09/18/01
- P-82_30-366A - 06/01/05
- S-98_00-13J - 08/01/05
- P-42_10-51C - 03/15/05
- Wipers/Washers - Maintaining Wiping Quality
- Lighting - Exterior Bulb Replacement Information
- Electrical - Horns Do Not Operate Correctly
- Lighting - Headlamp Lens Fogged Or Droplets Forming
- ABS/TCS - ESP/BAS Visit Workshop Message/Codes Set
- Lighting - Exterior Light Bulb Replacement Information
- Lighting - Exterior Light Bulb Replacement Info.
- Body - Sunroof Rattles/Water Leaks
- Body - Sliding Roof Rattles/Water Leaks
- Body - Sliding Roof Water Leaks/Rattling Noises
- Paint/Body - MBUSA Approved Refinishing Products Update
- Paint/Body - MBUSA Approved Refinishing Products
- Paint/Body - Approved Refinishing Products
- Body/Paint - MBUSA(R) Approved Refinishing Products
- Body/Paint - Approved Refinishing Materials
- Body/Paint - MBUSA Approved Refinishing Materials
- Body/Paint - Approved Refinishing Products
- Body - MBUSA Approved Refinishing Products
- Lighting - Moisture in Mirror Turn Signal Lamps
- Lighting - Moisture In Turn Signals in The Mirrors
- Interior - Visor Mirror Cover Broken/Vanity Light Inop.
- Interior - Sun Visor Mirror Cover Damaged/Broken
- Interior - Sun Visor Mirror Cover is Broken
- Body - Wind Noise From Various Locations
- Navigation System - DVD Not Being Recognized Information
- Campaign - Navigation DVD Update
- Navigation System - Won't Recognize DVD After Module R&R
- Navigation System - DVD Not Recognized After Module R&R
- COMAND(R) - Muliple System Errors
- Accessories - Garage Door Opener Can't Be Programmed
- A/C - Various Musty/Moldy Odor Complaints
- S-83_30-74N - 04/15/09
- A/C - Various Musty/Moldy Odor Issues
- A/C - Musty/Moldy Odor Complaints
- A/C - Various Musty/Moldy Odors
- A/C - Musty/Mildewy/Moldy Type of Odors
- P-83_30-74I - 10/08/07
- A/C System - Musty or Moldy Odors
- P-83_30-74G - 05/08/07
- A/C - Musty/Moldy Odor Complaints Cleaning Procedure
- Suspension - Shock Absorber/Strut Replacement Criteria
- Suspension - Shock Absorber/Strut Replacement Guidelines
- Suspension - Strut/Shock Replacement Guidelines
- Suspension -Strut/Shock Absorber Replacement Guidelines
- Suspension Strut/Shock Absorber Replacement Guidelines
- P-32_50-34C - 06/24/08
- Suspension Vehicle Lowers After Sitting
- Suspension - Vehicle Level Lowers After Being Parked
- Suspension - Vehicle Lowers After Being Parked
- Suspension - Knocking/Thumping From Front End
- Suspension - Front End Knock/Thump On Rough Roads
- Suspension - Front End Thumping/Knocking Noises
- Steering - Steering Gear Leakage Information
- Steering - Flow Noises/Fluid Foams in Reservoir
- Suspension - Vehicle Randomly Lowers While Driving
- Suspension - Vehicle Randomly Lowers
- Suspension - Vehicle Height Lowers After Parking
- Electrical Part Incompatibility Malfunctions
- Restraints -Repair And Diag. Of Airbag Wiring Harnesses
- Antitheft System - 'Replace Key Battery' Message Displayed
- Charging System - Voltage Regulator Inspection/Testing
- Charging System - Voltage Regulator Testing/Inspection
- Brakes - Front Brake Squeal/Grind Applied or Not
- LI42-45_P-048852 - 02/03/10
- A/T/Drivetrain - Oil Leak At Seam Between A/T And Transfer Case
- A/T - Momentary Slip 1-2 & 2-3 Upshift At Cold Start
- P-27_60-88 - 11/27/06
- Campaign - A/T Pilot Bushing Inspection/Replacement
- A/T - Fluid Leaks at Electrical Connector
- A/T - Diag. Verification For Valve Body/Conductor Plate
- AT - Ordering Notes For Electrohydraulic Control Unit
- A/T - Correct Electro-Hydraulic Control Modules
- A/T - Auxiliary Oil Pump, Test For DTC P0944
- A/T - Electrohydraulic Control Unit Part Numbers
- A/T - Electro-Hydraulic Control Module Identification
- A/T - Hard 1-2 Shift/Hard Converter Lock-Up
- Recall - Software Coding Errors
- P-27_00-102 - 11/30/07
- Steering - Speed Sensitive Steering malfunctions/DTC's
- A/T - Switches To Limp Home Mode And One Or More DTC's Stored
- Engine Controls - MIL ON/Multiple O2 Sensor Codes Set
- Emissions - MIL ON/DTC's P2003, P2047 P0810, P0814 Set
- Emissions - MIL ON/DTC's P2003/P2047/P0810 & P0814
- Engine Controls - MIL ON/Multiple Codes
- Engine Controls - MIL ON/Multiple Codes Stored In ECM
- Engine Controls - Engine Control Module (N3/10) Flashing
- Computers/Controls - Malfunctions Of Various Power/Control Uni
- Engine - MIL ON/DTC's Set/Low Power Output
- Cooling System - MIL ON/Poor Performance/DTC's Set
- Engine - Oil Leaks From The Oil Level Sensor
- Engine - Oil Leaks From Oil Level Sensor
- Electrical ESP, ABS & BAS 'Defective' Message/DTC's
- Suspension - Vehicle Lowers After Being Parked/DTC's Set
- Tire Monitor System - Service Precautions
- Steering - Fluid Leaks Near The Steering Rack
- Instruments - Low Oil Level Messages Displayed
- Wipers - Chattering/Noisy After Blade Replacement
- Engine - MB Approved Engine Oils
- A/C - Not Cooling/Compressor Noise
- Engine - Oil Level Display and Measurement
- Engine - Approved Oils Information
- Steering - Approved Hydraulic Fluids
- A/T - Fluid Specification Changes
- All Technical Service Bulletins
- Keyless System/Instruments - 'Replace Key Battery' Displayed
- Body/Frame - Dedicated Frame Straightener
- Body - License Plate Bracket Installation Precautions
- A/T - 722.96 Transmission Group 28 Damage Code Changes
- Lighting - Headlamp Unit Fogged/Droplets Forming
- A/C - A/C Sealant
- Collision Avoidance - Short Range Sensor Replacement Info.
- Battery - Battery Charging Information
- Drivetrain - Oil Leak At Seam Between A/T And Transfer Case
- A/T - ECO Start/Stop Inoperative, DTC P0944 Stored In TCM
- Steering - Warranty Policy Regarding Steering Wheels
- Restraints - Seat Belt Buckle Warranty Replacement Information
- Lighting - Headlamps/Front Fog Lamps Leaking Or Fogged
- A/T - Hard 2-3 Upshift Or Slips, No 3rd Gear/DTC's Stored
- A/C - HVAC - Foam Cleaner Information and Work Procedure
- Parking Assist - Malfunction and Fault Scenarios
- Parking Assist - Parktronic Sensor Return Policy
- Restraints - Repair And Diag. Of Airbag Wiring Harnesses
- Audio/COMAND(R) - Repair Of Wiring Harnesses
- Suspension - Strut/Shock Absorber Replacement Guidelines
- A/T - Operating Fluid Specification Changes
- Brakes/Traction Control - Handling Multipole Rings
- Body - License Plate Bracket Omission
- A/C - Musty/Moldy Odor Complaints, Cleaning Procedure
- Fuel System - Use Of E10 Fuel
- Brakes - Brake Lining Instructions
- Suspension - Assembly Of Suspension Struts And Shocks
- Transmission Controls - Control Module Flashing Info.
- Steering - Approved Hydraulic Fluids
- A/C System - Update Of Vehicle System Technology Guide
- Engine Control - Engine Control Module (N3/10) Flashing
- Computers/Controls - Module Programming Precautions
- Charging System - Voltage Regulator, Inspection/Testing
- Electrical - Battery Test & Inspection Information
- A/T - Electrohydraulic Control Unit ID & Ordering
- Paint/Body - MBUSA Approved Refinishing Products Update
- Wheels - Checking Components For Bolted Wheel Connection
- A/T - Diag. Verification For Valve Body/Conductor Plate
- Electrical - Electrostatic Discharge Damage Prevention
- Lighting - Uprated H7 Bulbs
- Electrical - Aftermarket Tampering Malfunctions
- Chemicals/Lubrication - Multi-Grade Metal Grease Info.
- Cell Phone - Calls Cut Off/Dropped
- Cell Phone - TeleAid Mod. Replacement Requirements
- Cell Phone - Call Cannot Connect/DTC D662 Set
- Cellular Phone - Voice Control Installation
- Interior - Door Panel Damaged by Seat Belt Latch Plate
- Recall 05V560000: Air Bag Defect/Replacement
- COMAND(R) System - Inoperative/Locks Up
- Campaign - Instrument Cluster Recoding
- Cruise Control - Radar Sensor Adapter
- Brakes - Squealing/Grinding Noises From Front Brakes
- Steering - Squealing or Squeaking Noises When Turning
- Audio System - Poor Audio Quality When Using Cell Phone
- Cell Phone - TeleAid(R) Call Will Not Connect
- Air Bag System - SRS Lamp ON/Multiple DTC's Set
- Engine Controls - CVN Redocumentation Process
- Electrical - Voltage Drop Testing at The Fuses
- Navigation System - Wrong Destination Displayed
- Audio System - CD Skips/Magazine Stuck/Won't Eject
- Body - Laminated Glass Chip/Crack Repair Information
- Engine - Approved Engine Oil Availability
- Steering - Pentosin CHF 11S(R) Power Steering Fluid
- Steering - Play/Movement Explanation
- A/T - Filter Part Number/Replacement Information
- Wipers/Washers - Wipers Chattering/Noisy
- Suspension - Vehicle Lowers On One Side or Corner
- Engine - Oil Leaks Between Oil Level Sensor & Oil Pan
- Suspension - Vehicle Raises/Lowers Erratically
- Charging System - Returning Alternators & Regulators
- COMAND(R) System - Multiple System Malfunctions
- Wipers/Washers - Intermittent Function Operation
- A/T - Limp Home Mode/Codes 2502/2505/P0894/P2711
- Entertainment System - CD's or DVD's Won't Eject
- Campaign - Install Software for Navigation System
- A/T Controls - Limp Home Mode/Harsh Engagement
- A/T - No Power Output From A/T
- A/T - Selection Range Sensor Learning Not Possible
- Interior - Front Door Wooden Trim Panel Loose
- Drivetrain - Front Axle Grinding Noise Diagnosis
- Interior - Seat Noise Complaints
- Body - Replacement Sheet Metal With Seam Sealer
- A/T - Throttle/Brake Pedal Application Precaution
- ABS/TCS - ABS/ESP Lamps ON/Codes C1140/C1540
- A/C - Fluorescent Dye Leak Testing
- Brakes - Front/Rear Brakes Squeal
- Suspension - Shock/Strut Replacement Guidelines
- Drivetrain - Rear Axle Surface Corrosion
- Keyless Entry - LED on Transmitter Key Not Functioning
- Instruments - Displaying Vehicle Voltage Instructions
- Steering - Steering Gear Apparent Leakage Information
- Wheels - Recommendation Against Chroming Alloy Wheels
- A/T - Multiple DTC's Set/Limp Home Mode
- Interior - Sun Visor Mirror Cover/Vanity Lamp Broken
- Paint - Adhesive Residue Removal
- Suspension - Remains at Raised Level/Hard Ride
- A/T - Fluid Leaks at The Electrical Connector
- Steering - Flow Noises/Fluid Foaming After Repairs
- A/C - Unpleasant Odor From Air Conditioning Vents
- Exhaust System - Exhaust Pipe Chrome Tip Care
- Interior - Interior Damage From Scent Dispensers
- A/C - Control Module/Control Functions/Diagnostics
- Wheels/Tires - Nitrogen Usage Recommendations
- Garage Door Opener - Range Too Short/Can't Program
- Interior - Seats are Dirty/Stained
- Steering - Power Steering Diagnostic Tips
- Suspension - Shock/Strut Replace Guidelines
- Body - Sunroof Water Leaks/Rattles
- Suspension - Front End Knock/Thump On Bumps
- Body - Door Mirror Seal Damaged
- Body/Lighting - Moisture in Mirror Turn Signals
- Campaign - Navigation System Disc Update
- Recall - Acceleration Sensor Inspection/Replacement
- Recall 08V405000: Acceleration Sensor Replacement
- Lighting - Auto Lamps/Rain Sensor Malfunctions
- Parking Assist System - Erroneous Activation
- Ignition System - Runs Rough/MIL ON/Misfire DTC's
- Power Steering - Fluid Filling/Bleeding Precautions
- Steering/Suspension - Front End Squeak/Thump Noise
- A/T - Limp Home Mode/Multiple Codes Stored
- Engine Controls - MIL ON/Multiple O2 Sensor DTC's Set
- Navigation System - DVD Not Recognized
- Electrical - Horn Replacement Information
- Body - Corrosion Between Roof And Quarter Panel
- Body - Wind Noise Diagnostics/Repair
- Keyless Entry - Various Malfunctions
- Suspension - Height Randomly Changes
- Accessories - Can't Program Garage Door Opener
- Vehicle - Approved Service Products On WIS
- Parking Assist System - Sensors Loose/Come Out Of Bumper
- Parking Assist System - Triggers For No Reason
- Tire Monitor System - False Warning Message Displayed
- Electrical - Suspension Message Displayed In Cluster
- Body - Front Door Window Motor Locks Up When Closing
- A/C - No Or Low A/C Cooling Performance
- Steering - Leaks At Steering Gear/Hose Junction
- Wheels - Approved Alloy Wheel Cleaning Product
- Wheels/Tires - Alloy Wheel Radial Crack Information
- ABS/TCS - ESP Service Required Mssg/Multiple Codes Set
- Emissions - Multiple Codes Set/MIL ON
- Cooling System - MIL ON/Low Engine Power
- Audio System - AM/FM Interference With Rear Defogger ON
- Cell Phone - Calls Dropped Or Cut Off
- Body - Corrosion At Roof/Rear Fender Junction
- Body - Windshield/Rear Window Body Seam Corrosion
- A/T - Electro-Hydraulic Control Module ID/Ordering
- Tire Monitor System - Steel Valve Stem Cap Precautions
- Body - New Window Glazing Adhesive Repair Kit
- Steering - Speed Sensitive Steering Malfunctions/DTC's
- Drivetrain - Axle Mount Service Guidelines
- Lighting - Low Beam Check Bulb Message Displayed
- Tire Monitor System - Service Precaution
- A/C - Musty/Moldy Odor Issues
- Brakes - Brake Pad Paste Usage
- Engine - Cylinder Wall Inspection
- Brakes - Caliper Bolt Replacement Information
- Cell Phone - Bluetooth(R)/Cell Phone Diagnostic Tool
- Lighting - Xenon Headlamp Brightness Explanation
- Wipers/Washers - Wiping Quality Maintenance
- A/T - Limp Home Mode/DTCs 2200/2201/2767/2768
- Audio System - Copy Protected CD Information
- Brakes - Brake Component Corrosion Information
- Vehicle - Maintenance Systems Overview
- Engine - Oil Level Message General Information
- Suspension - Vehicle Lowers After Sitting
- Recall - ECM Update For Various Issues
- A/T - 722.9, Delayed Reverse Engagement
- Lighting - Exterior Light Bulb Replacement
- Body - Windshield/Window Glass Bonding System
- Engine - Oil Warning Message In Instrument Cluster
- Lighting - Automatic Lights Switch OFF Too Late
- Computer/Controls - DAS/XD 2009-10-05-1274
- Computer/Controls - DAS/XD Add-On 2009-10-05-1271
- Computer/Controls - DAS/XD Add-On 2009-11-27-1321
- Suspension - ABC Suspension Humming/Buzzing Noise
- A/T - Hard Converter Lock-Up/Hard 1-2 Shift
- ABS/TCS - ESP/BAS Warning and Service Light ON/DTC's Set
- A/T - Harsh Engagement From Park To Drive
- Interior - Floor Mat Safety Information
- Restraints - Air Bag Durability And Reliability
- AT - Electrohydraulic Control Unit Order Notes Update
- Audio System - Radio Interruption Information
- Paint - Clearcoat With Higher Scratch Resistance
- Brakes - Brake Rotors Treated With Zinc Dust Spray Paint
- Body - Cleaning Tin-Plated Surfaces
- Emissions - I/m Dynamometer Emissions Testing
- Steering/Suspension - Wheel Alignment Data
- Electrical - Malfunctions in Driver and Front Passenger Door
- Drivetrain - Noises at Full Lock From Front Axle Area
- Antitheft System - 'Replace Key Battery' Message Displayed
- Computers/Controls - Malfunctions Of Various Power/Control Unit