Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Recall - Powertrain Control Module Reprogramming
- Recall 99V164000: Secondary Hood Latch, Corrosion
- Recall - Secondary Hood Latch Replacement
- Recall - Brake Line Repair
- Recall 99V123000: Right Front Brake Line Separation
- Recall 99V062001: Cruise Control Cables, Binding
- Recall - Speed Control Cable Replacement
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Question and Answer Sheet
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Owner Letter
- Recall - Speed Control Cable Inspection/Replacement
- Recall - Multifunction Switch/Harness Replacement
- Recall - Multifunction Switch Replacement
- Recall - Driver Seat Recliner Bolt Defect
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Recall 09V399000: Cruise Control Deactivation Switch
- Customer Interest
- EATC - No Setpoint/Blower Stays on HIGH
- PCM - Harsh Downshift From 3-1/Hesitates/Lacks Power
- Fuel Pump - Driveability Lack of Fuel Pressure
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - No Start/Parked On Incline w/Nose Down
- Audio System - Whining/Buzzing Noise From Speakers
- Blower Motor - Burning Odor/Smoke/Rustling Noise
- Engine - Knocking Noise From Left Side at Start Up
- A/T Cooler - Fluid Leaks at Radiator
- A/C - Erratic or Insufficient Temperature Control
- Steering - Drift/Pull to the Right
- Side Doors - Wind Noises
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine - Lean Driveability Symptoms
- Speedometer/Odometer - Inaccurate/Inoperative
- Accelerator Pedal Bracket - Cracks or Fatigues
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Exhaust System - Boom/Grunt/Groan/Moan/Vibration
- Exhaust System - Buzz/Rattle/Exhaust Noise
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- A/T - 4R70W TCIL/MIL ON/Trouble Codes Stored
- Engine Control - MIL ON, DTC P0300 or P0301 Set
- A/T - No 2nd, 3rd Gear/No Engine Braking/DTC's Set
- Restraint System - Air Bag Lamp ON/DTC B1994/B1998
- Windshield Wipers - Operate While Switch is OFF
- Windshield - Water Leaks
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- A/C - Cold Air Blows From Floor Ducts
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- A/T - 4R44E/5R55E Slipping/Delayed Shift/No Engagement
- Engine - Timing Chain Rattle Noise
- Front Seat Back - Recliner Lever Bent
- Moonroof - Water Leaks Into Vehicle
- Parking Assist System - False Warnings
- A/C - Heater Core Electrolysis/Leakage
- Chemicals,Additives
- Factory Modifications
- Labor/Parts Updates
- Safety
- Seals, Gaskets
- Superceded Bulletins
- 02-7-6 - 04/15/02
- Rear Window Defroster - Inoperative
- Front Wipers - Operate While Switch is in OFF Position
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Recall - Seat Back Recliner Bolt Defect
- Parking Assist System - False Tone Activation
- Parking Assist System - False Activation
- Passive Antitheft System (PATS) - Diagnostics Tips
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- Blower Motor - Rustling Noise/Smoke/Burning Odor
- A/T - 4R70W Delayed Or No 2-3 Upshift
- Electrical - Wiring Soldering/Crimping Tips
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Passive Antitheft System - Diagnostic Service Tip
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- A/T - Fluid Leak At Radiator Oil Cooler
- Vehicle - Calibration Information
- Speakers - Whining/Buzzing Noise
- EVAP System - MIL ON Multiple DTC's Set
- A/T - 4R70W MIL/TCIL ON/Trouble Codes Stored
- Speedometer - Inaccurate/MIL ON
- EVAP - MIL ON/DTC's P0442/P0455/No Driveability Concerns
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - Out Of Vehicle Reprogramming
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Engine - Timing Chain Rattling Noise
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- A/T - Slipping/Delayed Engagement/DTC P1762 Set
- All Technical Service Bulletins
- EATC - No Setpoint/Blower Stays on HIGH
- A/C System - Diagnosis and Service Tips
- PCM - Harsh Downshift From 3-1/Hesitates/Lacks Power
- Drivetrain - Neutral Tow Availability
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Electrical - New Terminal Grease Released For Service
- Fuel Pump - Driveability Lack of Fuel Pressure
- Fuel Pump - Whine Heard Through Radio Speakers
- Engine - No Start/Parked On Incline w/Nose Down
- Audio System - Whining/Buzzing Noise From Speakers
- Blower Motor - Burning Odor/Smoke/Rustling Noise
- Campaign - Camshaft Chain Tensioner and Intake Gasket
- Engine - Knocking Noise From Left Side at Start Up
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- A/T Cooler - Fluid Leaks at Radiator
- A/C - Erratic or Insufficient Temperature Control
- Wheels/Tires - Road Force Measurement Equipment
- Recall - Firestone Tire Recall
- Steering - Drift/Pull to the Right
- Recall - Firestone Tire Recall Supplement
- Side Doors - Wind Noises
- A/T - Cooler Flushing Service Tips
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- PCM - Reprogramming Out of Vehicle
- Emissions/Engine Controls - Driveability Diagnosis
- Engine - Lean Driveability Symptoms
- Speedometer/Odometer - Inaccurate/Inoperative
- Recall - Powertrain Control Module Reprogramming
- Engine Controls - General PCM Programming Procedures
- Composite Fuel Rail - Service Tip
- Accelerator Pedal Bracket - Cracks or Fatigues
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Engine Head Gasket - Approved Replacement Procedures
- PATS System - Diagnostic Service Tips
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Exhaust System - Boom/Grunt/Groan/Moan/Vibration
- Exhaust System - Buzz/Rattle/Exhaust Noise
- PCM - Calibration Information
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- A/T - 4R70W TCIL/MIL ON/Trouble Codes Stored
- Engine Control - MIL ON, DTC P0300 or P0301 Set
- A/T - No 2nd, 3rd Gear/No Engine Braking/DTC's Set
- Restraint System - Air Bag Lamp ON/DTC B1994/B1998
- Recall 99V164000: Secondary Hood Latch, Corrosion
- Recall - Secondary Hood Latch Replacement
- Windshield Wipers - Operate While Switch is OFF
- Interior Door Trim Panel - Replacement Tip
- Windshield - Water Leaks
- Front Bumper Bracket - Replacement Tip
- Motor Oil - Viscosity Grade Recommendation
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- Recall - Brake Line Repair
- Recall 99V123000: Right Front Brake Line Separation
- A/T - Cold Fluid Level Checking
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- Recall 99V062001: Cruise Control Cables, Binding
- Recall - Speed Control Cable Replacement
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Question and Answer Sheet
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Owner Letter
- Recall - Speed Control Cable Inspection/Replacement
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Climate Control - Blower Control Service Tips
- A/C - Cold Air Blows From Floor Ducts
- Engine - Oil System Priming Procedures
- Recall - Multifunction Switch/Harness Replacement
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Keyless Entry System - Service Tips
- Interior Trim - Vinyl Surface Repair Tips
- Locks - Lock Service Packages Available
- Paint - Rough Texture
- Paint - Premature Clearcoat Cracking Service Tips
- A/T - Inadvertent Shift Interlock Disabling
- A/T - 4R44E/5R55E Slipping/Delayed Shift/No Engagement
- Engine - Timing Chain Rattle Noise
- Hood Lamp Switch - Revised
- Recall - Multifunction Switch Replacement
- A/C - Identification of Non Approved Refrigerants
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Front Seat Back - Recliner Lever Bent
- Brakes - Vibration/Inspection Service Tips
- Fuel - Volatility Related Driveability Concerns
- Moonroof - Water Leaks Into Vehicle
- Recall - Driver Seat Recliner Bolt Defect
- Parking Assist System - False Warnings
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- A/T - 5R44E/5R55E Part Level Change/Compatibility
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Recall 09V399000: Cruise Control Deactivation Switch
- Comprehensive Noise/Vibration/Harshness Procedure
- Overview
- Description and Operation
- Diagnosis and Testing
- Overview
- Diagnostic Process
- 1. Customer Interview
- 2. Pre-Drive Check
- 3. Preparing For the Road Test
- 4. Verify the Customer Concern
- 5. Road Test
- 6. Check OASIS/TSBs/Repair History
- 7. Diagnostic Procedure
- NVH Condition and Symptom Categories
- Symptom Charts
- Pinpoint Tests
- Overview
- Pinpoint Test A: Brake Vibration/Shudder Diagnosis
- Pinpoint Test B: Engine Ticking Noise Diagnosis
- Pinpoint Test C:Front ENG. ACC. Drive (Fead) Bearing Hoot Diag.
- Pinpoint Test D: Power Steering Moan Diagnosis
- Pinpoint Test E: Engine Driven Cooling Fan Moan Diagnosis
- Pinpoint Test F: Drumming Noise Diagnosis
- Pinpoint Test G: Engine Ticking, Knock/Continuous Rattle Diag.
- Pinpoint Test H: Front Suspension Noise Diagnosis
- Pinpoint Test I: Rear Suspension Noise Diagnosis
- Pinpoint Test J: Wheel and Tire Diagnosis
- Pinpoint Test K: High Speed Shake or Shimmy Diagnosis
- Pinpoint Test L: Clutch Vibration
- Pinpoint Test M: Transfer Case Vibration
- Component Tests
- Tire Wear Patterns & Frequency Calculations
- General Procedures