Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Carburetor - Poor Performance/Flooding
- Brakes - Roughness During Application
- Power Steering Pump - Leakage At Dipstick Cap
- Tires - Outer Edge Tire Wear/Rotation Procedure
- Driver's Seat - Slightly Faces Passenger Side
- A/T - AOD Fluid Leak
- Ignition Coil - Possible Damage From Antitheft Devices
- VV Carburetor - Engine Stalls/Stumbles
- Carburetor Vent Line - Hard Start After Hot Soak
- Front Seats - Feel Loose/Rock From Side to Side
- Third Door Latch Assembly - Malfunction
- Power Door Locks - Are Inoperative
- Inside Door Handles - Air Leaks to Interior
- Convertible/T-Top - Water Leaks/Wind Noise
- Wiper/Washer - Low Fluid Warning Light Stays On
- Convertible/T Top - Mirror Wind Noise
- A/T - Synthetic Fluid Availability
- Clutch Pedal Shaft - Broken Welds
- Door/Vent Windows - Excessive Efforts to Open
- A/C System - Chemical/Refrigerator Type Odor
- Solenoid Kicker - Engine Diesels On Shutdown
- Engine - Dieseling On Shutdown
- Engine - Spark Knock During Acceleration
- M/T - M5OD, 3rd gear Whine
- A/C Evaporator - Cold Air Leaks/Cold Air Radiation
- Engine - Spark Knock/Detonation
- Back Seat - Will Not Fold Down Flat
- Seals, Gaskets
- Superceded Bulletins
- 91118 - 05/30/91
- 89193 - 09/20/89
- Air Conditioning - Musty or Mildew Type Odors
- A/C System - Musty/Mildew Odors
- A/C - O Ring Removal From Spring Lock Coupling
- Electrical Diode - Identification/Service Replacements
- Brake Rotor - Machining With On-Vehicle Equipment
- Torque Converter - Metal To Metal Sound
- A/C - New Filter to Prevent Compressor Damage
- A/C System - New Filter Kit
- Air Conditioning - Prevent Damage to Compressor
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Wheels - Proper Lug Torque Procedures
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- A/C Compressor Replacement - Refrigerant Filtering
- A/C System - Use of R12 Refrigerant Substitutes
- Air Conditioning - Filtering Refrigerant
- All Technical Service Bulletins
- Recall/Owner Notification Program - Index Update
- RTV Sealant - Improved Material
- Brakes - Noise Diagosis/Repair TSB Sumary
- Overview
- Brake Noise Description and Application Chart
- Article No. 85-4-31
- Article No. 86-12-5
- Article No. 86-19-5
- Article No. 87-8-14
- Article No. 87-13-20
- Article No. 87-16-7
- Article No. 87-20-14
- Article No. 87-20-15
- Article No. 87-23-11
- Article No. 88-13-7
- Article No. 88-14-6
- Article No. 88-20-6
- Article No. 88-21-2
- Article No. 88-25-9
- Article No. 89-1-13
- A/C - New `Tee' Type Service Adapter Tool
- Air Conditioning - Odor Service Procedure
- A/C System - Service TSB List
- Air Conditioning - Return of Obsolete Filter Kits
- A/C - Filtering Refrigerant After Compressor Replacement
- Adhesives and Sealants - Availability and Usage
- Power Steering Pump - Changes
- Power Steering pump - Rotor and `C' Clip Changes
- Carburetor - Poor Performance/Flooding
- Fuel Filter - Replacement Information
- Brakes - Roughness During Application
- Graphic Display - False or No Warnings
- A/C - Warner Compressor Clutch Replacement
- Heater Core - Leakage Diagnostic Tips
- Front Strut/Shock - Spacers
- Steering Rack - `Short Rack' Availability
- Campaign - Steering Gear Replacement
- Power Steering Pump - Leakage At Dipstick Cap
- Distributor - Ignition Rotor Alignment Procedure
- Valve Stem Seal - Installation Preparation
- Crankshaft Seal - Leaks, Air Pressure Test
- Seals For Rocker Cover, Oil Pan, and Crankshaft
- Aluminum Wheels - Wear/Corrosion Damage
- Tires - Outer Edge Tire Wear/Rotation Procedure
- Tires - Michelin TRX Availability
- Aluminum Wheel - New Improved Wrench Adapter
- Lug Nuts - Proper Installation/Torqueing Procedure
- Wheel Stud - Removal Procedure
- Driver's Seat - Slightly Faces Passenger Side
- Differential Pinion Bolt - Removal Aid
- A/T - ATX Final Gear Housing Bolt Replacement
- A/T - AOD Fluid Leak
- Throttle Valve - Control Pressure Specification Revision
- Injector O-Rings - Ordering Information
- MCU - Diagnostic Procedure Change
- EGR Solenoids - Contamination
- Rear Brakes - Squealing Noise
- Alternator - Rectifier Bench Test Procedure
- Duraspark II Ignition - Revised Applications
- Ignition Coil - Possible Damage From Antitheft Devices
- Ignition Distributor - Advance Unit Not Adjustable
- VV Carburetor - Engine Stalls/Stumbles
- Carburetor Vent Line - Hard Start After Hot Soak
- Carburetor and Tune-Up Specifications
- Carburetor/Tune-Up Specifications
- Fuel Tube/Connector - Service Procedure
- High Altitude Modifications
- Seat/Shoulder Belts - General Service Information
- Overview
- Section 1 -Identification of Seat Belt System Types For Model Years 1974-1985
- Section 2-Description of Seat Belt System For Model Years 1974-1985
- A.Continuous Loop Three-Point Shoulder/Lap Belt - System With Moveable Tongue and One Retractor - 1976 to Present Cars and Ligh
- B.Dual Retractor Three-Point Shoulder/Lap System - 1974 to 1983 Cars and Light Trucks and 1974 to 1985 Econolines and Club Wago
- C.Two-Point System - Center Front/Rear and Rear Seat Lap Belts
- Section 3-Functional Test Procedure For Shoulder Harness
- Section 4-Functional Test Procedure For Lap Belts and Retractor
- Section 5-Seat Belt Procedure After an Accident
- Section 6-Cleaning Belt Webbing
- Section 7-Service Parts
- Section 8-Service Recalls Involving Seat Belts
- Section 9-TSB's Involving Seat Belts
- Brake Rotor - Machining Equipment/Warranty Information
- Vehicle - Intermittent Operation Diagnosis
- Speedometer/Odometer - Inaccurate Readings
- M/T - Clutch Cable Installation
- High Strength Steels - Welding Procedures
- Front Seats - Feel Loose/Rock From Side to Side
- Antitheft Devices - Installation Precautions
- Aftermarket Antitheft Devices - Hard Start/No Start
- Idle Emissions - Test Procedure
- Emission Control System - Technician's Glossary
- Fuel System - Liquid/Vapor Leak Detection
- EEC Systems - Symptomized Comprehensive TSB Index
- EEC Harness - Engine Stalls/Stumble
- Electronic Modules - Protection From Static Electricity
- Electrical/Electronic/Fuel Induction - Glossary
- Third Door Latch Assembly - Malfunction
- Tailgate - Hinge/Latch Release Adjustment Revision
- Power Door Locks - Are Inoperative
- Inside Door Handles - Air Leaks to Interior
- Convertible/T-Top - Water Leaks/Wind Noise
- Hood - Palm Dent Service Procedure
- Safety Belt - Tongue Cover Now Available
- Door Glass Spacer/Retainer - Correct Usage
- Wiper/Washer - Low Fluid Warning Light Stays On
- Convertible/T Top - Mirror Wind Noise
- Campaign - T Top Water Leaks
- T-Roof - Optional Lock System installation
- Bumpers - Isolator and Bracket Assembly Replacement
- Rear Lamp Assembly - Replacement
- Recycled Engine Coolant - Service Tips
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - Modulator Chart
- A/T - C4/C5 Replacing Forward Drum Oil Rings
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - C5 Slipping On 1-2 Shift After Rebuild
- A/T - C3 Front Seal Update
- A/T - C3 Slipping or No Drive Condition
- A/T - A4LD/C3 Front Pump Support Inspection
- A/T - C5 Delayed Engagement/Abrupt Apply In Reverse
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - C3 No Reverse After Rebuild
- A/T - Sprag Rotation
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- A/T - Synthetic Fluid Availability
- A/T, M/T - New `Mercon' Transmission Fluid
- A/T, M/T - Fluid Usage Chart
- Clutch Pedal Shaft - Broken Welds
- Oil Leak - Rotunda Black Light Diagnostic Procedures
- Wiring - Circuit Number/Color Code Charts
- Wire Harness Terminal and Connector - Service Kit
- Speed Control - New Rotunda Tester Information
- Self Adjusting Clutch - Replacement
- Door/Vent Windows - Excessive Efforts to Open
- T Top - Door Reinforcement Kit Availability
- Safety Belts - Service Procedure, Manual Revision
- Paint - Cosmetic Damage From Airborn Materials
- Paint - Cosmetic Surface Service Procedures
- A/C - Pressure Cycling Switch Diagnostic Procedure
- A/C System - Chemical/Refrigerator Type Odor
- Solenoid Kicker - Engine Shutdown Dieseling
- Solenoid Kicker - Engine Diesels On Shutdown
- Engine - Dieseling On Shutdown
- Engine - Spark Knock During Acceleration
- A/T - AOD Orifice Control Valve Plug Retainer
- A/T - AOD Main Control Valve Body Gasket
- Headlamp Bulb - Replacement Recommendations
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- M/T - M5OD, 3rd gear Whine
- A/C Coupling - Cleaning Procedures
- A/T - C5 Output Shaft Modification
- A/C Evaporator - Cold Air Leaks/Cold Air Radiation
- Electric Choke System - Testing Tool
- Power Steering Fluid - Tips
- Engine - Spark Knock/Detonation
- Rotunda Gas Chek Kit - Requires Modification
- Back Seat - Will Not Fold Down Flat
- Recall - Screw Replacement for Seat Back Assembly
- Seat Back Frame - Unauthorized Service