Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Labor/Parts Updates
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Shop Manual Correction.
- Brakes - Noise Diagosis/Repair TSB Sumary
- A/C - Musty Odor Coming From Vents
- Engine - Poor Fuel Economy/Poor Heater Performance
- Air Conditioning - Odor Service Procedure
- A/C System - Service TSB List
- A/C - Filtering Refrigerant After Compressor Replacement
- Adhesives and Sealants - Availability and Usage
- Engine - Shop Manual Revisions
- Engine - No Start/Hesitation/Stalls/Low Power
- TPS Mounting Screws - Hard to Remove
- Throttle Position Sensor - Application Chart
- Throttle Position Sensor - Diagnostic Tips
- Engine - Rough Idling Condition
- Engine Compartment Wiring - Connector Service
- Engine - Hard Cold Starts/Hesitation/Stalls On Start-Up
- Fuel Filter - Replacement Information
- Electric Fuel Pump - New Service Procedure
- Brakes - Rotor Service Update
- Brakes - Roughness During Application
- Front Disc Brakes - Clicking Noise
- Brakes - Intermittent Brake Squeal
- Graphic Display - False or No Warnings
- Spark Plug - New Service Application
- Spark Plugs - Shorting/Altered Scope Pattern
- A/C - Orifice Tube Replacement Service Kit
- Air Conditioning - Approved Flushing Procedures
- Heater Core - Leakage Diagnostic Tips
- Inner Tie Rod - Replacement Procedure
- Steering Gear Input Shaft Seal - Fluid Leak
- Steering Gear - Service Replacement Gear
- Steering Gear - Simplified Valve Seal Service
- Steering Gear - Attaching Hardware
- Engine - Slow/No Start/Missfire/Poor Economy
- Engine - Hard Start/No Start/Runs Rough
- Recall 89V095000: Engine Oil Leaks Onto Hot Exhaust
- Cylinder Head Oil Drain Vent Tubes - Design Change
- Oil Dipstick/Fill Cap - White/Brown Residue
- Aluminum Oil Pan - Heli-Coil Repair of Drain Plug
- Water Pump - Special Installation Instructions
- Cooling System - New System Diagnostics
- EVTM - Cooling Fan Schematic Addition
- Electric Cooling Fan - Usage Chart
- Aluminum Radiator - Repair Precautions
- Crankshaft Seal - Leaks, Air Pressure Test
- Muffler - Drain Hole Misdiagnosis
- Front/Rear Suspension - Spring Usage
- Wheels - Loss Of Balance Weights
- Aluminum Wheels - Wear/Corrosion Damage
- Tires - Michelin TRX Availability
- Tires - Field Service Locations/Representatives
- Aluminum Wheel - New Improved Wrench Adapter
- Wheel Bolts - New, Shorter Front Wheel Bolts
- Lug Nuts - Proper Installation/Torqueing Procedure
- Wheel Stud - Removal Procedure
- Door Locks - Inoperative Due to Rustproofing
- Power Window Regulator - Counterbalance Spring
- Window Regulator Handle - Improved Attachment
- Driver's Seat - Relocation Rearward
- Front Door Weatherstrips - Shredded/Worn
- Torque Converter - Cleaning and Replacement Guidelines
- A/T - Fluid Leak At the Cooler Line Connections
- MAP and BAP Sensor - Application Chart
- TFI/MAP Connectors - No Start Condition
- Torque Converter - Holding Tool Modification
- A/T Torque Converter - Leak Test Procedure
- Engine - Hesitation/Hard Starting
- Fuel Injectors - Rotunda Injector Tester/Cleaner
- Engine - Hesitation/Lack Of Power/Rough Idle
- Fuel System - Injector Tester/Cleaner Service Tips
- EGO Sensors - Silicone Contamination
- EVP Sensors - Non Interchangeable
- EVP Sensor - Manual Revision
- Engine - Stalls After Braking When Hot
- Fuel Injection - Shop Manual Revisions
- EGR Solenoids - Contamination
- Constant Velocity Joint - Boot Wear
- Rear Brakes - Squealing Noise
- Engine - No Start/Charge Lamp ON
- Alternator - No or Low Output
- Alternator/Regulator - Integral Design Service Procedure
- Alternator - Discharge
- Starter - Remains Energized With Engine Running
- Instrument Cluster Warning Lights - Dimly Lit
- Engine - Cranks/No Start/Stalls At Idle
- Ignition System Resistance - Manual Revision
- Campaign - TFI Module Inspection/Replacement
- TFI Module/PIP Sensor - New Diagnostic Procedure
- Ignition System - Weak/No Spark
- Distributor - Oil Leak
- Engine/Ignition - No Start Condition
- Ignition Coil - Possible Damage From Antitheft Devices
- Ignition System - Diagnostics Manual Correction
- Ignition Coil - Stumbles/Stalls/Noise In Radio
- Spark Plug/Coil Wire - Resistance, Manual Correction
- Ignition System - Octane Rod Replacement Deletion
- Engine - Rough Idle/Stalls/Residue On Dipstick
- Engine - Rough Idle/Stalling During Deceleration
- Engine - Stalling/Hard Start/No Start/Rough Idle
- EEC IV Power Relay - Shop Manual Revisions/Updates
- Engine - Exhaust Backfires On Deceleration
- Engine - Spark Knock
- EFE Heater Spacer - Hard Start/Hesitation
- Engine - Low Power/Surge at Steady Speeds
- Radio - Improper Stereo Light Operation
- AM/FM Cassette Radio - Dial Lighting Dim
- Radio/Cassette - Stereo/Mono Switching
- Heated Backlite - Inoperative
- Electric Rear Window Defroster - Inoperative
- Front Seat Belts - D Ring Does Not Rotate Freely
- Seat/Shoulder Belts - General Service Information
- Brake Rotor - Machining Equipment/Warranty Information
- Oil Fill Cap/Dipstick - White/Brown Substance
- Engine - Oil Dipstick May Not Be Read Correctly
- Engine Vacuum System - Starting/Driveability Problems
- Recall - Emissions Control Systems Modifications
- Fuel Pump/Sender - Erratic Operation Prevention
- Fuel Tank Sending Unit - Connector Replacement
- Speedometer/Odometer - Inaccurate Readings
- Headlamp - Lens Moisture Diagnosis/Tips
- Headlamps - Flicker When Fog Lamps Are On
- Stabilizer Bar - Squeak/Grunt/Crunch Noise
- Front/Rear Stabilizer Bar Bushings - Squeak/Grunt Noise
- `B' Pillar - Cosmetic Crack At Belt Line
- Chassis Components - Cosmetic Surface Rust
- Roof/`A' Pillar - Water Leaks To Interior
- Antitheft Devices - Installation Precautions
- Recall - Emission Control System Modification
- Emission Diagnosis - Manual Revisions
- EEC IV Emissions Diagnosis - Supplemental Information
- Emission Control System - Technician's Glossary
- Fuel System - Liquid/Vapor Leak Detection
- Exhaust - Squeaky Flex Joint Gasket
- EEC Electrical Connectors - Driveability Concerns
- EEC IV - Invalid/Erratic Service Codes
- EEC Harness - Engine Stalls/Stumble
- Electronic Modules - Protection From Static Electricity
- Electrical/Electronic/Fuel Induction - Glossary
- Tailgate - Hinge/Latch Release Adjustment Revision
- Power Door Locks - Are Inoperative
- Door Speakers - Distorted Sound Quality
- Door Latches - Adjustment/Modification Prohibition
- Front/Rear Door Handles - Air Drafts
- Safety Belt - Tongue Cover Now Available
- Child Safety Seat - Tether Attachment Instructions
- Windshield - Revised Service Procedure
- Windshield - Water Leaks
- Windshield - Revised Installation Procedure
- Windshield/Interior Glass - Fog/Film
- Manual Vent Windows - Difficult to Open
- Manual Vent Windows - Hard to Open
- Vent Windows - May Stick to Weatherstrip
- Glass - Iridescence or Mottling In Tempered Glass
- Bumpers - Isolator and Bracket Assembly Replacement
- Bumper Cover - Repair Materials Update
- Engine Oil - Recommended Usage
- Engine Coolant - Recycled Coolant Not Authorized
- Recycled Engine Coolant - Service Tips
- Brakes - Brake Tube Replacement
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - ATX Revised Piston Seals For Direct Clutch
- A/T - ATX Planetary Gear Design Changes
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - EEC Trouble Codes
- A/T - Diagnostic Trouble Codes for 1983-1992
- A/T - ATX Planetary Gear Interchange
- A/T - Delayed Forward Engagement/Servo Apply Lip Seals
- A/T - ATX Bind-Up In Reverse
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - ATX No Upshift Condition/Occurs Very Suddenly
- A/T - ATX No Upshift/Governor Drive Gear
- A/T - ATX New Right Hand Half Shaft
- A/T - ATX Shifting Problems After Rebuild
- A/T - ATX Problems and Solutions
- A/T - ATX Governor Driving Gear and Driven Gear Wipe Out
- A/T - Pressure Tap Locations
- A/T - ATX Erratic Upshifts Sometimes No Upshift
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - ATX Late or No Upshift
- A/T - ATX No Movement In Any Direction
- A/T - Installation Of In-Line Fluid Filter and Flow Test
- A/T - ATX Torque Converter Differences
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - ATX New Design Lip Seals
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - MTX Reverse Gear Shift Pattern Change
- M/T - MTX Filler Plug Revised Removal Procedure
- Rough Idle, Stalls At Idle and During Deceleration
- Accessory Drive Belt - `V' Ribbed Belt Cracking
- A/T, M/T - New `Mercon' Transmission Fluid
- A/T, M/T - Fluid Usage Chart
- Low Coolant Warning System - Retrofit Kit
- A/C - New Push Button/Blower Switch
- Recall 85V054000: Throttle Lever Jammed
- Driveability TSB's - Summary
- Oil Leak - Rotunda Black Light Diagnostic Procedures
- Wiring - Diagram Symbol Explanantion
- Wiring - Circuit Color Code Elimination
- Wiring - Circuit Number/Color Code Charts
- Wiring - Continuity Testing of Connector Terminals
- Wiring - Electrical System Troubleshooting Tips
- Wire Harness Terminal and Connector - Service Kit
- Fuel System - Pressure Test Gauge Tool Update
- Speed Control - New Rotunda Tester Information
- Speedometer/Speed Control - Inoperative
- Door/Vent Windows - Excessive Efforts to Open
- Safety Belts - Service Procedure, Manual Revision
- Paint - Cosmetic Damage From Airborn Materials
- Paint - Preparation Procedure And MSDS Information
- Fleet Colors - Revised Paint Code Numbers
- Overview
- Service Refinish Codes
- Whites & Cream
- Grays, Metallic Gray, Browns, Metallic Brown & CONT'D, Reds, Metallic Reds & Orange
- Yellows, Greens, Metallic Green, Blues, Metallic Blue, Purple Pink, Metallic Purple Pink
- Paint - Revised Prices
- Exterior Paint - Comprehensive Repair Procedures
- Paint - Iron Particle Removal
- Luggage Cover - Creak or Rattle Noise
- A/C - Pressure Cycling Switch Diagnostic Procedure
- A/C System - Chemical/Refrigerator Type Odor
- Electrical Diode - Identification and Replacement
- Engine - No Start/Idles Rough/Knock When Cold
- Distributor Stator - Replacement Procedure
- Recall - Seat Track Support Modification/Replacement
- Recall 89V170000: Seat Track Pedestal Fracture
- Recall 89V170000: Seat Track Fatigue Fracture
- A/C - R12 Refrigerant Service Tips
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- A/C - Identification of Non Approved Refrigerants
- A/T - Planet Gear Service Interchangeability
- M/T - MTX Fill Plug Removal Procedure Revision
- A/C Coupling - Cleaning Procedures
- A/C - Spring Lock Coupling Service
- Air Conditioning - O Ring Removal Service Tip
- A/C - New Refrigerant O-Rings
- Differential - Revised Removal Procedure
- Shift Lever - Cannot Be Pulled Out of Park Position
- Seat Belt - Service Kit For Front Outboard Tongue
- M/T - Jumps Out of 2nd or 4th Gear
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Rotunda Gas Chek Kit - Requires Modification
- Fuel - California Reformulated Gasoline
- A/T - ATX - Revised Converter Hub Seal/Service