Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Labor/Parts Updates
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Shop Manual Correction.
- Brakes - Noise Diagosis/Repair TSB Sumary
- A/C - Musty Odor Coming From Vents
- Engine - Poor Fuel Economy/Poor Heater Performance
- Air Conditioning - Odor Service Procedure
- Dealer Installed A/C - Installation Concerns
- Heater - Inadequate Output
- A/C System - Service TSB List
- Automatic Temperature Control - New Connector Design
- Air Conditioning - Return of Obsolete Filter Kits
- A/C - Filtering Refrigerant After Compressor Replacement
- Adhesives and Sealants - Availability and Usage
- Engine - Shop Manual Revisions
- Electrical - New Terminal Grease Released For Service
- Engine - Loading/Stalling
- Fuel Pump - Buzzing/Humming After Engine Shut Down
- Engine - Hard Start/No Start
- TP Sensor - Poor Engine Performance/Mileage
- Engine - Intermittent/Constant High Idle Speed
- TPS Mounting Screws - Hard to Remove
- Throttle Position Sensor - Application Chart
- Throttle Position Sensor - Diagnostic Tips
- Engine Compartment Wiring - Connector Service
- Engine - Idle Speeds High/Erratic
- Fuel Filter - Replacement Information
- Engine - No Start/Hard Start/Stalls After A Hot Soak
- Radio/Two-Way Communications - Whine/Buzz
- Electric Fuel Pump - New Service Procedure
- Engine - No Restart After Hot Soak/Stalls During Drive
- Engine - Rough Idle/Surge/Stalling
- Brakes - Rotor Service Update
- Brakes - Roughness During Application
- Front Disc Brakes - Clicking Noise
- Brakes - Intermittent Brake Squeal
- Graphic Display - False or No Warnings
- Spark Plugs - Shorting/Altered Scope Pattern
- Engine - Overheating/AC Inoperative
- A/C Compressor - Clutch Slippage
- Blower Motor - Chirping/Squeaking
- A/C - Orifice Tube Replacement Service Kit
- Air Conditioning - Approved Flushing Procedures
- Heater Core - Leakage Diagnostic Tips
- Front Suspension - Rubbing/Scraping Noise
- Recall 85V086000: Rear Suspension Bolts Fracture
- Recall 85V145000: Rear Suspension Bolts Fracture
- Inner Tie Rod - Replacement Procedure
- Steering Gear Input Shaft Seal - Fluid Leak
- Steering Gear - Service Replacement Gear
- Steering Gear - Simplified Valve Seal Service
- Steering Gear - Attaching Hardware
- Engine - Hard Start/No Start/Runs Rough
- Engine Timing Components - Service Procedures
- Aluminum Oil Pan - Heli-Coil Repair of Drain Plug
- Oil Pan - Revised Shop Manual Installation Procedure
- Cooling System - New System Diagnostics
- Cooling Fan Schematic - Manual Revision
- Electric Cooling Fan - Usage Chart
- Aluminum Radiator - Repair Precautions
- Crankshaft Seal - Leaks, Air Pressure Test
- Muffler - Drain Hole Misdiagnosis
- Engine - Surging/Bucking During Acceleration
- Front/Rear Suspension - Spring Usage
- Wheels - Loss Of Balance Weights
- Aluminum Wheels - Wear/Corrosion Damage
- Alignment - Outside Edge Tire Wear
- Tires - Michelin TRX Availability
- Tires - Field Service Locations/Representatives
- Aluminum Wheel - New Improved Wrench Adapter
- Wheel Bolts - New, Shorter Front Wheel Bolts
- Lug Nuts - Proper Installation/Torqueing Procedure
- Wheel Stud - Removal Procedure
- Door Locks - Inoperative Due to Rustproofing
- Power Window Regulator - Counterbalance Spring
- Window Regulator Handle - Improved Attachment
- Rear Door Weatherstrip - Water Leaks To Interior
- Front Door Weatherstrips - Shredded/Worn
- Steering Wheel Damper - Steering Column Shake
- Torque Converter - Cleaning and Replacement Guidelines
- A/T - Fluid Leak At the Cooler Line Connections
- EEC IV MAP Sensor - New Part Numbers/Applications
- TFI/MAP Connectors - No Start Condition
- Engine - Rough Idling/Black Smoke/Poor Fuel Economy
- Engine - Eratic Idle/Hesitation/Poor Economy
- A/T Torque Converter - Leak Test Procedure
- A/T - ATX Harsh Shift Concern
- A/T - ATX Harsh Shifts or Shift Sags
- Fuel Injector - Internal Leakage/Exhaust Smoke
- Recall - Part III Fuel Injection/Emissions Modification
- Recall - Injector/Converter Inspection/Replacement
- Recall - Part IV Fuel Injection/Emissions Modifications
- Fuel Injectors - Rotunda Injector Tester/Cleaner
- Engine - No/Hard Start/Flooding/Driveability Concerns
- Fuel Injector - Service Availability
- Fuel System - Injector Tester/Cleaner Service Tips
- Body/Frame - Arc Welding Precautions
- Engine - Hard Start/No Start When Cold
- EEC IV Processor - Service Replacements
- EEC IV - New Diagnostic Procedure
- Engine - High or Erratic Engine Idle
- Engine - Stall on Drive Engagement and Deceleration
- Engine - Stalling During Deceleration
- Engine - Stalls On Cold Transmission Engagement
- EEC IV Processor - Erroneous Code 22 Found
- Engine - Cold Engagement/Deceleration Stall
- Engine - High Idle Speed/Stalling
- Engine - High/Erratic Idle
- Recall 85V134000: Electronic Engine Control Processor
- EGO Sensors - Silicone Contamination
- EVP Sensors - Non Interchangeable
- EVP Sensor - Manual Revision
- Engine - Engagement/Deceleration Stalls
- Fuel Injection - Shop Manual Revisions
- EGR Solenoids - Contamination
- Rear Brakes - Squealing Noise
- Battery - Test Procedure
- Battery - No Engine Crank/Low Battery Charge
- Battery - Low State of Charge
- Alternator - No or Low Output
- Alternator/Regulator - Integral Design Service Procedure
- Alternator - Discharge
- Engine - Surge/Stall/Poor Idle/AM Radio Noise
- Alternator Light - Comes ON at Idle
- Starter - Remains Energized With Engine Running
- Instrument Cluster Warning Lights - Dimly Lit
- Engine - Cranks/No Start/Stalls At Idle
- Ignition System Resistance - Manual Revision
- Duraspark II Ignition - Revised Applications
- TFI Module/PIP Sensor - New Diagnostic Procedure
- Ignition System - Weak/No Spark
- EEC Universal Distributor - Drive Gear Removal Tool
- Engine/Ignition - No Start Condition
- Ignition Coil - Possible Damage From Antitheft Devices
- Ignition System - Diagnostics Manual Correction
- Ignition Coil - Stumbles/Stalls/Noise In Radio
- Distributor - Spark Tracking/Arcing/Crossfire
- Ignition System - Octane Rod Replacement Deletion
- Engine/Carburetor - Poor Performance
- Engine - Surge While Accelerating
- Engine - Misses/Bucks/Air Induction Hoot Noise
- Engine - Induction Noise During Acceleration
- EEC IV Power Relay - Shop Manual Revisions/Updates
- Speed Control - Inoperative or Delayed Response Time
- Radio - Improper Stereo Light Operation
- AM/FM Cassette Radio - Dial Lighting Dim
- Heated Backlite - Inoperative
- Electric Rear Window Defroster - Inoperative
- Seat/Shoulder Belts - General Service Information
- Brake Rotor - Machining Equipment/Warranty Information
- Engine - Oil Dipstick May Not Be Read Correctly
- Engine Vacuum System - Starting/Driveability Problems
- Fuel Pump/Sender - Erratic Operation Prevention
- Fuel Tank Sending Unit - Connector Replacement
- Temperature Gauge - Reads Low/Erratic
- Speedometer/Odometer - Inaccurate Readings
- Headlamp - Lens Moisture Diagnosis/Tips
- Cylinder Head/Block - Coolant/Oil Leaks
- Oil Pan Gasket - Oil Leaks
- Stabilizer Bar - Squeak/Grunt/Crunch Noise
- Front/Rear Stabilizer Bar Bushings - Squeak/Grunt Noise
- Chassis Components - Cosmetic Surface Rust
- Roof/`A' Pillar - Water Leaks To Interior
- Air Bag System - Rescuer's Guide
- Campaign - Air Bag System Wiring
- Antitheft Devices - Installation Precautions
- Emission Diagnosis - Manual Revisions
- EEC IV Emissions Diagnosis - Supplemental Information
- Emission Control System - Technician's Glossary
- Fuel System - Liquid/Vapor Leak Detection
- Exhaust - Squeaky Flex Joint Gasket
- EEC Electrical Connectors - Driveability Concerns
- EEC IV - Invalid/Erratic Service Codes
- EEC IV Pinpoint Test - Shop Manual Correction
- Fuel Control Pinpoint Test - Manual Revision
- EEC Harness - Engine Stalls/Stumble
- Engine - Hard to Start or Will Not Start on Cold Start
- Electronic Modules - Protection From Static Electricity
- Electrical/Electronic/Fuel Induction - Glossary
- Tailgate - Hinge/Latch Release Adjustment Revision
- Power Door Locks - Are Inoperative
- Door Speakers - Distorted Sound Quality
- Door Latches - Adjustment/Modification Prohibition
- Front Door Locks - Power Latch Inoperative
- Safety Belt - Tongue Cover Now Available
- Windshield - Water Leaks
- Windshield - Revised Installation Procedure
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Manual Vent Windows - Hard to Open
- Vent Windows - May Stick to Weatherstrip
- Glass - Iridescence or Mottling In Tempered Glass
- Window Crank Handle - Part Recommendation
- Outside Rear View Mirror - Vibrates
- Bumpers - Isolator and Bracket Assembly Replacement
- Engine Oil - Recommended Usage
- Engine Coolant - Recycled Coolant Not Authorized
- Recycled Engine Coolant - Service Tips
- Power Steering Hose - Removal and Installation Revision
- Brakes - Brake Tube Replacement
- A/T - Removal and Installation Procedure Revision
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - Transmission Flush and Fill Tool Available
- A/T - ATX Revised Piston Seals For Direct Clutch
- A/T - ATX Planetary Gear Design Changes
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - EEC Trouble Codes
- A/T - Diagnostic Trouble Codes for 1983-1992
- A/T - ATX Planetary Gear Interchange
- A/T - Delayed Forward Engagement/Servo Apply Lip Seals
- A/T - ATX Bind-Up In Reverse
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - ATX No Upshift Condition/Occurs Very Suddenly
- A/T - ATX No Upshift/Governor Drive Gear
- A/T - ATX New Right Hand Half Shaft
- A/T - ATX Shifting Problems After Rebuild
- A/T - ATX Problems and Solutions
- A/T - ATX Governor Driving Gear and Driven Gear Wipe Out
- A/T - Pressure Tap Locations
- A/T - ATX Erratic Upshifts Sometimes No Upshift
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - ATX Late or No Upshift
- A/T - ATX No Movement In Any Direction
- A/T - ATX FLC No Movement In Any Direction After Rebuild
- A/T - Installation Of In-Line Fluid Filter and Flow Test
- A/T - ATX Torque Converter Differences
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - ATX New Design Lip Seals
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - MTX Reverse Gear Shift Pattern Change
- M/T - MTX Filler Plug Revised Removal Procedure
- Accessory Drive Belt - `V' Ribbed Belt Cracking
- A/T - Synthetic Fluid Availability
- A/T, M/T - New `Mercon' Transmission Fluid
- A/T, M/T - Fluid Usage Chart
- Rear Suspension - New Service Parts
- A/C - New Push Button/Blower Switch
- Driveability TSB's - Summary
- Engine - New Gasket Sealer
- Oil Leak - Rotunda Black Light Diagnostic Procedures
- Wire Harness - Terminal Repair Kit
- Wiring - Diagram Symbol Explanantion
- Wiring - Circuit Color Code Elimination
- Wiring - Circuit Number/Color Code Charts
- Wiring - Continuity Testing of Connector Terminals
- Wiring - Electrical System Troubleshooting Tips
- Wire Harness Terminal and Connector - Service Kit
- Fuel System - Pressure Test Gauge Tool Update
- Engine - Stalls At Idle After Hot Soak
- Speed Control - New Rotunda Tester Information
- Speedometer/Speed Control - Inoperative
- Door/Vent Windows - Excessive Efforts to Open
- Safety Belts - Service Procedure, Manual Revision
- Paint - Cosmetic Damage From Airborn Materials
- Lower Body Stone Protection - Repair Procedure
- Paint - Preparation Procedure And MSDS Information
- Fleet Colors - Revised Paint Code Numbers
- Overview
- Service Refinish Codes
- Whites & Cream
- Grays, Metallic Gray, Browns, Metallic Brown & CONT'D, Reds, Metallic Reds & Orange
- Yellows, Greens, Metallic Green, Blues, Metallic Blue, Purple Pink, Metallic Purple Pink
- Paint - Revised Prices
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- Exterior Paint - Comprehensive Repair Procedures
- Paint - Iron Particle Removal
- A/C - Pressure Cycling Switch Diagnostic Procedure
- A/C System - Chemical/Refrigerator Type Odor
- Electrical Diode - Identification and Replacement
- A/T - ATX Shift Problems
- Engine - Buzzing Noise at Wide Open Throttle
- Engine - No Start/Idles Rough/Knock When Cold
- Engine - No Start/Idle Rough/Spark Knock
- Distributor Stator - Replacement Procedure
- Axle Shaft - New Right Hand Interconnecting Shaft
- A/C - R12 Refrigerant Service Tips
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- A/C - Identification of Non Approved Refrigerants
- A/T - Planet Gear Service Interchangeability
- M/T - MTX Fill Plug Removal Procedure Revision
- Right Hand Cowl Area - Noise/Squeak
- Body/Frame - Squeak From Cowl Area
- A/C Coupling - Cleaning Procedures
- A/C - Spring Lock Coupling Service
- Air Conditioning - O Ring Removal Service Tip
- A/C - New Refrigerant O-Rings
- Engine - Backfire On Deceleration
- Differential - Revised Removal Procedure
- Shift Lever - Cannot Be Pulled Out of Park Position
- Seat Belt - Service Kit For Front Outboard Tongue
- M/T - Jumps Out of 2nd or 4th Gear
- A/C - Revised Removal Procedures For Registers
- Brakes - New Silicone Compound/Grease
- Vehicle - Driveability/Transmission Concerns
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Engine Timing Mark - Diagnostic Symbol Revision
- Ignition Timing Procedure - Manual Update
- Flywheel Timing Mark - Identification
- Rotunda Gas Chek Kit - Requires Modification
- Fuel - California Reformulated Gasoline
- Front Seat Trim Cover - Loose and/or Baggy
- Seat Leather - Cleaning Procedure Tips
- Seat Back - (Passenger Front) Movement When Braking
- Child Safety Lock - Description
- A/T - ATX - Revised Converter Hub Seal/Service