Powertrain Management: Technical Service Bulletins

• Recalls
  • Emissions
    • Recall - Catalyst Replacement
      • Overview
      • Overview of Recall 93E45
      • Attachment I - Administrative Information
      • Attachment II - Labor and Parts Information
      • Attachment III - Technical Instructions
      • Owner Letter
  • Safety
    • Recall - Fuel Filter and Nylon Fuel Line Replacement
      • Overview
      • Attachment I - Administrative Information
      • Attachment II - Labor and Parts Information
      • Attachment III - Technical Information
        • Overview
        • Fuel System Pressure Relief
        • High Pressure Fuel Lines & Fuel Pump Filter Replacement
      • Dealer Letter (Except Midwestern,Western & Yukon Territory)
      • Dealer Letter (Midwestern, Western Regions & Yukon Territory)
      • Owner Letter
• Customer Interest
  • Engine - Rough Idling Condition
  • Engine - Stall On Deceleration Or At Idle
  • Engine - Hesitation/Lack Of Power/Rough Idle
  • Engine - No Start or Hard Start Condition
  • Engine - Stalling and/or A No Start Condition
  • Engine - Lack of Power/Low Turbo Boost
  • Engine - Rough Idle/Hesitation/Backfire/Stalling
• By Symptom
  • Abnormal wear/deterioration
    • Turbocharger - Failure or Seizure
  • Customer Interest
    • Engine - Rough Idling Condition
    • Engine - Stall On Deceleration Or At Idle
    • Engine - Hesitation/Lack Of Power/Rough Idle
    • Engine - No Start or Hard Start Condition
    • Engine - Stalling and/or A No Start Condition
    • Engine - Lack of Power/Low Turbo Boost
    • Engine - Rough Idle/Hesitation/Backfire/Stalling
  • Driveability
    • Engine - Rough Idling Condition
    • Engine - Stall On Deceleration Or At Idle
    • Engine - Hesitation/Lack Of Power/Rough Idle
    • Engine - Stalling and/or A No Start Condition
    • Engine - Rough Idle/Hesitation/Backfire/Stalling
  • Poor performance
    • Engine - Rough Idle/Hesitation/Backfire/Stalling
  • Recalls
    • Recall - Fuel Filter and Nylon Fuel Line Replacement
      • Overview
      • Attachment I - Administrative Information
      • Attachment II - Labor and Parts Information
      • Attachment III - Technical Information
        • Overview
        • Fuel System Pressure Relief
        • High Pressure Fuel Lines & Fuel Pump Filter Replacement
      • Dealer Letter (Except Midwestern,Western & Yukon Territory)
      • Dealer Letter (Midwestern, Western Regions & Yukon Territory)
      • Owner Letter
    • Recall - Catalyst Replacement
      • Overview
      • Overview of Recall 93E45
      • Attachment I - Administrative Information
      • Attachment II - Labor and Parts Information
      • Attachment III - Technical Instructions
      • Owner Letter
  • Starting problems
    • Engine - No Start or Hard Start Condition
• All Technical Service Bulletins
  • Driveability TSB's - Summary
    • Overview
    • 1.3L
    • 1.6L
    • 1.6L EFI Turbo
    • 1.9L CFI
    • 1.9L EFI
    • 2.0L
    • 2.2L
    • 2.3L
    • 2.3L EFI Turbo
    • 2.3L HSC
    • 2.5L CFI
    • 2.5L HSC
    • 2.8L EFI
    • 2.9L EFI
    • 3.0L
    • 3.8L
    • 4.9L
    • 5.0L
    • 5.8L
    • 6.9L Diesel
    • 7.3L Diesel
    • 7.5L
  • TPS Mounting Screws - Hard to Remove
  • Engine - Rough Idling Condition
  • Recall - Fuel Filter and Nylon Fuel Line Replacement
    • Overview
    • Attachment I - Administrative Information
    • Attachment II - Labor and Parts Information
    • Attachment III - Technical Information
      • Overview
      • Fuel System Pressure Relief
      • High Pressure Fuel Lines & Fuel Pump Filter Replacement
    • Dealer Letter (Except Midwestern,Western & Yukon Territory)
    • Dealer Letter (Midwestern, Western Regions & Yukon Territory)
    • Owner Letter
  • Engine - Stall On Deceleration Or At Idle
  • MAP and BAP Sensor - Application Chart
  • Fuel Injectors - Rotunda Injector Tester/Cleaner
  • Fuel Injectors - Mismarked Stock
  • Engine - Hesitation/Lack Of Power/Rough Idle
  • Fuel System - Injector Tester/Cleaner Service Tips
  • Body/Frame - Arc Welding Precautions
  • EGO Sensors - Silicone Contamination
  • EVP Sensor - Manual Revision
    • Overview
    • 1985 Pinpoint Tests - DM - EGR, EVP and EVR
    • 1985 Pinpoint Tests - Fa - Neutral Drive Switch -A/C Input
    • 1986 (EGR) Systems Functional Diagnosis
    • 1986 Quick Test: Continuous Self-Test 6.0
    • Pinpoint Test - DN - EGR - EVP & EVR
      • Overview
      • 1987 (EGR) Systems - Functional Diagnosis
      • 1987 Quick Test: Continuous Self-Test - 6.0
      • Pinpoint Test - DN - EGR - EVP & EVR
      • 1988 Functional Diagnosis
        • (EGR) Systems - Functional Diagnosis
        • Quick Test:Continuous Self-Test - 6.0
        • Pinpoint Test - DN - EGR - EVP & EVR
      • 1989 Functional Diagnosis
        • (EGR) Systems - Functional Diagnosis
        • Quick Test:Continuous Self-Test - 6.0
        • Quick Test:Diagnostic By Symptom - 7.0
        • Pinpoint Test - DN - EGR - EVP & EVR
  • Engine - No Start or Hard Start Condition
  • TFI Module/PIP Sensor - New Diagnostic Procedure
    • Overview
    • Part 2 TFI-IV Ignition System With TFI Ignition Tester
      • Preliminary Checkout, Equipment & Notes
      • Functional Schematic
      • Ignition Coil Secondary Voltage (Crank Mode)
      • Wiring Harness
      • Stator - TFI
      • TFI Module
      • Ignition Coils - Secondary & Primary Resistance
      • EEC-IV - TFI-IV
      • Ignition Coil Supply Voltage
      • Wiring Harness
    • Part 2 TFI-IV Closed Bowl Distributor (With TFI Ignition Tester)
      • Preliminary Checkout, Equipment & Notes
      • Functional Schematic
      • Ignition Coil Secondary Voltage - Crank Mode
      • Wiring Harness
      • Stator
      • TFI Module
      • Ignition Coil, Primary & Secondary
      • EEC IV - Wiring
      • Wiring Harness
      • Ignition Coil, TFI & Stator Voltage
      • Wiring Harness
  • Engine - Stalling and/or A No Start Condition
  • EEC Universal Distributor - Drive Gear Removal Tool
  • Engine - Lack of Power/Low Turbo Boost
  • Turbocharger Boost Pressure - Manual Revision
  • Turbocharger - Failure or Seizure
  • Recall - Catalyst Replacement
    • Overview
    • Overview of Recall 93E45
    • Attachment I - Administrative Information
    • Attachment II - Labor and Parts Information
    • Attachment III - Technical Instructions
    • Owner Letter
  • Fuel Sender - Revised Testing Procedure
  • EEC IV Emissions Diagnosis - Supplemental Information
    • Overview
    • EEC IV - Pinpoint Tests - All Vehicles 1986 19-253A
    • EEC-IV Quick Test-All Engines 1987 16-15
      • Passenger Car Service Code Chart
      • Light Truck Service Code Chart
    • EEC IV - Pinpoint Tests - All Vehicles 1987 19-3
      • EGR Valve Position Sensor (EVP) Control/Vent (EGRC/EGRV)
        • Pinpoint Test DD4 Thru DD6
        • Pinpoint Test DD7, DD11
        • Pinpoint Test DD12
        • Pinpoint Test DD15 Thru DD17
      • Vane Airflow Sensor (VAF)
        • Test DK Wiring Diagram
        • Pinpoint Test Fault Code 26, DK 1 & 2
      • Pressure Feedback EGR (PFE) EGR Valve Regulator (EVR)
        • Pinpoint Test Service Code 33, DL 30 Thru DL 33
        • Pinpoint Test DL34 Thru DL37
        • Pinpoint Test DL90
      • DC Motor Idle Speed Control/Idle Tracking Switch and Throttle Position Sensor - 1.9L CFI and 2.3L (HSC) CFI
        • Pinpoint Test KB26 and KB27
        • KB90 Continuous Memory Code 13
      • System Check
        • Pinpoint Test 5
        • Pinpoint Test S1, S2
      • Transmission - AXOD
    • Carburetors, Fuel Charging Assemblies, Throttle Bodies and Injectors 1988
      • CFI, EFI & Carburetor System Troubleshooting
      • Idle Speed Adjustment Procedures
    • EEC-IV -Quick Test -All Engines 1988 16-11
      • Quick Test:Engine Running Self-Test
        • B Code Output
        • C Passenger Car Service Code Chart
        • B Passenger Car Service Code Chart
        • B Light Truck Service Code Chart
      • Appendix:Self-Test With "Check Engine" Light (MIL)
        • Reading Codes - "Check Engine" Light (MIL)
        • How to Run Self-Test Using the Continental Message Center
      • Reference Voltage
        • Pinpoint Test C1 Thru C3
        • Pinpoint Test C4 Thru C6
      • EGR Valve Position Sensor (EVP) Control/Vent (EGRC/EGRV)
        • Pinpoint Test DD7 and 11
        • Pinpoint Test DD12 and 15
      • Vane Airflow Sensor (VAF)
        • Overview
        • Pinpoint Test Schematic
        • Pinpoint Test DK 1 and 2
      • Pressure Feedback EGR (PFE) EGR Valve Regulator (EVR)
        • Pinpoint Test DL 14, 20, 21 22
        • Pinpoint Test DL 23, 25, 30, 31
        • Pinpoint Test DL 32 Thru 35
        • Pinpoint Test DL 36, 37, 90
        • Pinpoint Test DL91, 92
      • EGR Valve Position Sensor (EVP) EGR Valve Regulator (EVR)
        • Pinpoint Test DN 20 Thru 22
        • Pinpoint DN 25, 26
        • Pinpoint Test DN 40 Thru 42
        • Pinpoint Test DN 43 and 44
        • Pinpoint Test DN 45, 50, 51
        • Pinpoint Test DN 90
      • Fuel Control
        • Pinpoint Test H1 Thru H3
        • Injector Bank Resistance
        • Pinpoint Test H4
        • Specifications Table 2 and Pinpoint Test H5
      • Fuel Pump Circuit
        • Pinpoint Test Schematic
        • Pinpoint Test J1 Thru J31
      • Idle Speed Control (Bypass Air)
        • Pinpoint Test KE6 Thru KE8
        • Pinpoint Test KE9 Thru KE11
      • WOT A/C Cutoff (WAC) A/C Demand
        • Pinpoint Test km 1 and 2
        • Pinpoint Test km 3 and 4
      • RE-Initialization Check
        • Pinpoint Test QE 1 Thru 2
        • Pinpoint Test QE4
      • System Check
        • Pinpoint Test Flow Chart
        • Pinpoint Test S1 and 2
      • Transmission - AXOD
      • Integrated Controller
        • Pinpoint Test X10 and 11
        • Pinpoint Test X12 Thru X14
        • Pinpoint Test X50 Thru X52
        • Pinpoint Test X53 Thru X55
  • Emission Control System - Technician's Glossary
    • 91FORD13 A
    • B
    • C
    • D
    • E
    • F
    • H
    • I
    • K
    • L
    • M
    • N
    • O
    • P
    • Q
    • R
    • S
    • T
    • U
    • V
    • W
    • Z
  • Key On Engine Off Self Test Procedure - Manual Revision
  • Electronic Modules - Protection From Static Electricity
  • Vehicle - Welding Precautions
  • Electrical/Electronic/Fuel Induction - Glossary
    • Overview
    • A
    • B
    • C
    • D
    • E
    • F
    • G
    • H
    • I
    • J
    • K
    • L
    • M
    • N
    • O
    • P
    • Q
    • R
    • S
    • T
    • U
    • V
    • W
    • X
    • Z
  • Engine - Rough Idle/Hesitation/Backfire/Stalling
  • Rotunda Gas Chek Kit - Requires Modification