Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Musty Odor Coming From Vents
- Engine - Idle Rough/Stall After Cold Start
- Engine Timing Belt - Chirping/Squeaking Noise
- Aluminum Wheel - Air Leaks
- Rear Tires - Vibration/Noise
- Engine - Stalls When Key Is Released to Run Position
- Axle Shafts - Fluid Leaks
- Battery - No Engine Crank/Low Battery Charge
- Alternator - Discharge
- Heated Backlite - Inoperative
- Electric Rear Window Defroster - Inoperative
- Liftgate - Rattles While Driving At Low Speeds
- Speed Control - Abnormal Operation When Hot
- Instrument Cluster - Squeak
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Superceded Bulletins
- 90137 - 06/20/90
- 90128 - 06/07/90
- 89311 - 02/08/89
- 89252 - 12/13/89
- 89135 - 06/28/89
- 891012 - 05/17/89
- 881710 - 08/17/88
- 861116 - 06/05/86
- A/C - Identification Of Non Approved Refrigerants
- A/C - R134A Retrofit Kit Availability
- A/C - R12 to R134a Retrofit Kit Availability
- A/C - Approved Flushing Procedures
- Air Conditioning - Musty or Mildew Type Odors
- Blower Motor - Chirping or Squeaking Noise
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Electrical - Wiring Harness Terminal Repair Kit
- Charging - Generator Discharge/Damaged Connector
- Brakes - Special Lubricant Requirements
- Brake Rotor - Machining With On-Vehicle Equipment
- A/T - New Transmission Cooler Flusher/Service Tip
- Exhaust Gas Oxygen Sensors - Silicone Contamination
- Exhaust System - Buzz or Rattle Noise
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Exhaust System - Buzz/Rattle Noise
- Cooling System - Diagnosis Procedure
- A/T - Fluid Application Charts
- A/C System - Refrigerant Filtering Service Tips
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- Propylene Glycol Coolant - Recommendations
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C Compressor Replacement - Refrigerant Filtering
- A/C System - Use of R12 Refrigerant Substitutes
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- All Technical Service Bulletins
- Ford RTV Sealer - Shelf Life
- A/C - Musty Odor Coming From Vents
- A/C System - Service TSB List
- Air Conditioning - R12 to R134A Retrofit Kit
- Adhesives and Sealants - Availability and Usage
- Engine Gasket Surface - Cleaning Procedures
- Engine - Repair Tips to Avoid Potential Damage
- Engine - Idle Rough/Stall After Cold Start
- Fuel Pump/Sender - Defective Parts Return
- Brakes - Intermittent Brake Squeal
- Air Conditioning - Approved Flushing Procedures
- Heater Core - Core Leak Test Procedure
- Power Steering Seal Kit - Installation Revision
- Engine Timing Belt - Chirping/Squeaking Noise
- Cooling System - New System Diagnostics
- Blade Fan Assembly - Part Return
- Aluminum Wheel - Air Leaks
- Lug Nuts - Proper Torqueing Procedure
- Rear Tires - Vibration/Noise
- Lug Nuts - Proper Installation/Torqueing Procedure
- Torque Converter - Cleaning and Replacement Guidelines
- Torque Converter - Pilot Bosses Increased In Diameter
- A/T Torque Converter - Leak Test Procedure
- Fuel Injectors - Rotunda Injector Tester/Cleaner
- Fuel Injector Cleaner - Parts and Service Tips
- Engine - Stalls When Key Is Released to Run Position
- EGO Sensors - Silicone Contamination
- EVP Sensor - Manual Revision
- Overview
- 1985 Pinpoint Tests - DM - EGR, EVP and EVR
- 1985 Pinpoint Tests - Fa - Neutral Drive Switch -A/C Input
- 1986 (EGR) Systems Functional Diagnosis
- 1986 Quick Test: Continuous Self-Test 6.0
- Pinpoint Test - DN - EGR - EVP & EVR
- Axle Shafts - Fluid Leaks
- Hub and Halfshaft Locknut - Service Tips
- Battery - Test Procedure
- Battery - No Engine Crank/Low Battery Charge
- Engine - No Start/No Crank/Low Battery Charge
- Alternator - Discharge
- `Star Tester' - Proper Hook Up Procedure
- Fuel Control Solenoid - Manual Correction
- Main Relay Connector - Updated Design
- Audio Systems - Authorized Service Centers
- Heated Backlite - Inoperative
- Electric Rear Window Defroster - Inoperative
- Brake Rotor - Machining Equipment/Warranty Information
- Temperature Gauge - Reads Low/Erratic
- Speedometer/Odometer - Inaccurate Readings
- Cooling Fan Relay Circuit - Manual Revision
- VECI Decal - Initial Replacement Index
- Emission Control System - Technician's Glossary
- EEC IV - Quick Tests/Pinpoint Tests/Schematics
- Overview
- Electronic Fuel Injected Engines
- Quick Test:Test Description
- Quick Test:Visual Check Vehicle Preparation 1.0
- Quick Test:Equipment Hookup 2.0
- Quick Test:Key On Engine Off Self-Test 3.0
- Quick Test:Engine Running Self-Test 4.0
- Quick Test:Continuous Self-Test 5.0
- Quick Test:Switch Monitor Test 6.0
- Appendix:Self-Test Description
- Appendix:Code Output Format
- Appendix:Diagnostic Aids
- Appendix:Test Equipment
- No Start (Ignition Pulse) Pinpoint Test A
- Vehicle Battery Pinpoint Test B
- No Codes and STO Always LO Pinpoint Test B
- No Codes/Codes Not Listed Pinpoint Test Q
- Engine Control Operating Strategy Electrical Schematic
- Vacuum Schematic
- Key On Engine Off Self Test Procedure - Manual Revision
- EVTM - Electronic Engine Control Schematic
- Electronic Modules - Protection From Static Electricity
- Electronics - Diagnostic Tools and Adapter Application
- Electrical/Electronic/Fuel Induction - Glossary
- Door Latches - Adjustment/Modification Prohibition
- Liftgate - Rattles While Driving At Low Speeds
- Windshield/Interior Glass - Fog/Film
- Glass - Iridescence or Mottling In Tempered Glass
- Campaign - M65 Supplemental Instructions
- Motor Oil - Viscosity Grade Recommendation
- Cooling System - Proper Fluid Concentrations
- Engine Coolant - Recycled Coolant Not Authorized
- Recycled Engine Coolant - Service Tips
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - ATX Planetary Gear Design Changes
- A/T - ATX Governor Filter
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - EEC Trouble Codes
- A/T - Diagnostic Trouble Codes for 1983-1992
- A/T - ATX Planetary Gear Interchange
- A/T - Delayed Forward Engagement/Servo Apply Lip Seals
- A/T - ATX Bind-Up In Reverse
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - ATX Erratic Upshifts Sometimes No Upshift
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - ATX Late or No Upshift
- A/T - ATX No Movement In Any Direction
- A/T - Installation Of In-Line Fluid Filter and Flow Test
- A/T - ATX Torque Converter Differences
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - ATX New Design Lip Seals
- A/T - Math Part II
- A/T - Choosing the Right ATF
- A/T - Mercon V ATF Usage
- Speed Control - Abnormal Operation When Hot
- Instrument Cluster - Squeak
- Driveability TSB's - Summary
- Engine - New Gasket Sealer
- Engine - Normal Oil Consumption
- Wire Harness Terminal and Connector - Service Kit
- Paint - Cosmetic Damage From Airborn Materials
- Lower Body Stone Protection - Repair Procedure
- Paint - Preparation Procedure And MSDS Information
- Exterior Clearcoat - Cracking/Eroding/Peeling Off
- Exterior Paint - Comprehensive Repair Procedures
- Overview
- Section A Has Been Superseded By TSB # 9264, Dated 3/92.
- (B) Paint Exterior Color Peeling From Ultra Violet Light
- (C) Lower Body Stone Protection Repair Tips
- (D) Procedure For PVC Body Side Moldings
- (E) Lower Body-Side Stone Chip Protection Program
- (F) Surface Defect Removal Without Repainting
- (G) Color Compatible Spray Primer Chart
- (H) Paint Repair For Tinted Clear Coat
- (I) Paintable Plastics
- (J) 1992 Paint Color Codes
- Paint - Iron Particle Removal
- Electrical Diode - Identification and Replacement
- A/C - R12 Refrigerant Service Tips
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- A/C - Identification of Non Approved Refrigerants
- A/T Torque Specifcation - Manual Revisions
- Recall 95V103011: Seat Belt Buckle Breakage
- Vehicle Storage - Maintenance Tips
- Brakes - New Silicone Compound/Grease
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Fuel - Volatility Related Driveability Concerns
- Seat Leather - Cleaning Procedure Tips
- M/T - Mercon(R) V ATF Usage Information