Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Recall - Personal Safety (Restraint) System Defect
- Overview
- Dealer Letter
- Demonstration/Deliver Hold
- Demonstration/Deliver Hold - Dealer Letter
- Demonstration/Deliver Hold - Attachment I
- Demonstration/Deliver Hold - Attachment II
- Demonstration/Deliver Hold - Attachment III
- Demonstration/Deliver Hold - Attachment IV
- Demonstration/Deliver Hold - Attachment V
- Demonstration/Deliver Hold - Owner Letter
- Recall 00V412000: RCM Improperly Assembled
- Recall - Restraint Control Module Inspection
- Recall 00V270000: Restraint Module Defect
- Recall 01V227001: Seat Belt Buckle Defect
- Recall - Outboard Seats Belt May Not Fully Latch
- Recall - Personal Safety (Restraint) System Defect
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Brakes - Excessive Brake Dust on Wheels
- A/C Plenum - High Pitched Whistling Noise
- Engine - Ticking Noise When Idling
- Engine - Timing Chain Grinding Noise
- Engine - Oil Leak From R/H Cylinder Head Gasket
- Accessory Drive Belt - Slips Off Pulley When Wet
- Intake Manifold - Cross-Over Channel Coolant Seepage
- A/T - 4R70W Flare on 3-4 Shift, MIL ON, DTC P0782
- Engine Controls - MIL ON/DTC's P0420/P0430 Set
- Exhaust/Emissions - Sulfur/Rotten Egg Exhaust Smell
- Restraint System - SRS Lamp ON/DTC B1342 Set
- Lighting - Excessive Moisture in Headlamp Assembly
- Stoplamps/Shift Interlock - Inoperative
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Door Hinge - Squeak/Creak Noise
- Restraints - Seat Belts Slow to Retract
- A/T - 4R70W Ticking Noise In 1ST Gear
- Turn Signals - Intermittent Rapid Flashing
- Fuel Filler Door - Poor Fit/Pops Open
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Turn Signals - Intermittent Flashing
- A/T - Inadvertent Shift Interlock Disabling
- A/T - 4R70W Clunk Noise on 2nd to 1st Gear Downshift
- A/C - Heater Core Electrolysis/Leakage
- Starting System- No Crank Condition
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Superceded Bulletins
- 02M01S3 - 01/01/04
- 02M01S2 - 01/01/04
- 02M01 - 01/01/04
- 02M01 - 11/01/03
- 02M01S5 - 04/01/04
- Rear Window Defroster - Inoperative
- Body - Aluminum Corrosion Service Tip
- Rear Defroster/Integral Antenna - Diagnose and Repair
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- SRS - DTC B1342 (Restraints Control Module Fault)
- Restraint System - Seat Belts Slow to retract
- Restraints - DTC And Associated Fault PID Service Tips
- Air Bag System - Advanced Restraint Deployment Strategy
- A/C - Lack of Cooling/Low Air Flow From Vents
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Fuel Tank - Punctures During High Speed Rear Impacts
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Recall - EGR Pressure Sensor Replace/Warranty Extension
- Emissions - MIL ON, DTC's P0401, P1400 or P1401
- Emissions - MIL ON/Possible DTC's/Driveability Issues
- Emissions - MIL ON/DTC's Set/Driveability Concerns
- Emissions - MIL ON/EVAP System DTC's Set
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Engine Mounts - Revised
- Engine - Ticking Noise at Idle
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- Engine - Oil Recommendations/Applications
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- Emissions- DTC's Set/MIL ON/Driveability Concerns
- All Technical Service Bulletins
- A/C System - Diagnosis and Service Tips
- Suspension/Driveline - Vibration Diagnosis
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Brakes - Excessive Brake Dust on Wheels
- A/C Plenum - High Pitched Whistling Noise
- Engine - Ticking Noise When Idling
- Engine - Timing Chain Grinding Noise
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Engine - Oil Leak From R/H Cylinder Head Gasket
- Accessory Drive Belt - Slips Off Pulley When Wet
- Intake Manifold - Cross-Over Channel Coolant Seepage
- Campaign - Intake Manifold Extended Warranty Coverage
- Suspension - Repeated Tire Balancing Issues
- Wheels/Tires - Road Force Measurement Equipment
- Warranty - Guide Supplement
- Information
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor Information
- Attachment III - Technical Information
- Owner Letter
- Supplement # 1 - Information
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 1 - Owner Letter
- Supplement # 2 - Information
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Apology Letter
- Supplement # 2 - Owner Letter
- Emissions/Engine Controls - Driveability Diagnosis
- Emissions - MIL ON/Driveability Issues/DTC's Set
- Recall - Tube Mounted EGR Pressure Sensor Defect
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- A/T - 4R70W Flare on 3-4 Shift, MIL ON, DTC P0782
- Engine Controls - General PCM Programming Procedures
- Engine Controls - MIL ON/DTC's P0420/P0430 Set
- Exhaust/Emissions - Sulfur/Rotten Egg Exhaust Smell
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Recall - Personal Safety (Restraint) System Defect
- Overview
- Dealer Letter
- Demonstration/Deliver Hold
- Demonstration/Deliver Hold - Dealer Letter
- Demonstration/Deliver Hold - Attachment I
- Demonstration/Deliver Hold - Attachment II
- Demonstration/Deliver Hold - Attachment III
- Demonstration/Deliver Hold - Attachment IV
- Demonstration/Deliver Hold - Attachment V
- Demonstration/Deliver Hold - Owner Letter
- Recall 00V412000: RCM Improperly Assembled
- Recall - Restraint Control Module Inspection
- Restraint System - SRS Lamp ON/DTC B1342 Set
- Lighting - Excessive Moisture in Headlamp Assembly
- Lighting - Moisture In Headlamp Assembly
- Stoplamps/Shift Interlock - Inoperative
- Wipers/Washers - Wiper Motor Transfer Tips
- Engine Head Gasket - Approved Replacement Procedures
- PATS System - Diagnostic Service Tips
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Engine Controls - MIL ON/Lean DTC Service Tips
- Door Hinge - Squeak/Creak Noise
- Restraints - Seat Belts Slow to Retract
- Body - Exterior Mirror Glass/Motor Service Tips
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - 4R70W Ticking Noise In 1ST Gear
- A/T - In Line Fluid Filter Kit
- Turn Signals - Intermittent Rapid Flashing
- Recall 00V270000: Restraint Module Defect
- Fuel Filler Door - Poor Fit/Pops Open
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Climate Control - Blower Control Service Tips
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Turn Signals - Intermittent Flashing
- A/T - Inadvertent Shift Interlock Disabling
- Seat Belts - Warning System Operation
- A/T - 4R70W Clunk Noise on 2nd to 1st Gear Downshift
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Recall 01V227001: Seat Belt Buckle Defect
- Recall - Outboard Seats Belt May Not Fully Latch
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Starting System- No Crank Condition
- Body - Aluminum Body Panels - Corrosion
- Advanced Restraint System - Operational Characteristics
- Steering - Mercon V(R) Fluid Usage
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Restraints - Control Module DTCs, Associated Fault PIDs
- Engine - Spark Plug Hole Thread Repair Procedure