Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- A/C - Musty/Moldy Odors In Passenger Compartment
- Vehicle - Body Vibration
- Propeller Shaft - Shudder/Suspension Bottoming Out
- A/T - Overheat Indication, Expanded Oil Pan
- Engine Controls - Oxygen Sensor Failure/DTC P0154
- A/T - 2nd To 3rd Gear Shift Flare
- Engine Controls - Hesitation/DTC P0154 (O2 Sensor)
- Audio System - Speaker Static/Buzzing/Inoperative
- A/C - Pulsating/Rattle Noise
- Body - Squeak Noise on Bumps
- Antitheft - Procedure For No Start Problem
- Fuel/Emissions - Sulfur Odor From Exhaust
- Liftgate Hatch - Noise From Rear of Vehicle
- Audio Speaker - Abnormal Noise
- Rear Liftgate - Improved Gas Spring
- Windshield - Wind Noise
- Instruments - Speedometer Inoperative/MIL ON/DTC 29 Set
- Audio System - Static/Popping/Poor Sound/Distortion
- A/T - 2nd to 3rd Gear Upshift Slip/Flare
- Transfer Case Shift Lever - Stuck in 4H
- Brakes - Judder (vibration) Diagnosis and Repair
- Recommended Repairs
- Superceded Bulletins
- 99-54-003 - 1/01/99
- 99-00-003 - 06/01/99
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-011 - 07/01/01
- 01-00-008 - 03/01/01
- 00-42A-003 - 04/01/00
- 00-23-004 - 05/01/00
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Audio System - Diagnosis
- Antitheft - Engine Immobilizer System PDI & Service
- Remote Keyless Entry - Service Information
- SRS - Front Impact Sensor Resistance
- A/T - 2nd to 3rd Gear Upshift Flare
- Scan Tool - Warranty Coverage/Repair Return Procedures
- MEDIC System - ROM Pack Reprogramming
- A/T - 2nd to 3rd Gear Shift Flare
- Engine - Testing for Excessive Oil Consumption
- Engine - Oil Economy Test/Consumption Diagnosis
- Cylinder Block - Heater Installation Procedure
- A/C - Rattling/Pulsating Noise With A/C ON
- Tires/wheels - Tire Chain Usage Information
- Engine Controls - Hesitation/O2 Sensor Failure/DTC P0154
- All Technical Service Bulletins
- Restraints - SRS Component Disposal Information
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- VIN - Decoding Chart
- Tool - Battery/Starting/Charging System Analyzer
- A/C - Musty/Moldy Odors In Passenger Compartment
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Replacement Piston Selection
- Steering - Cautions for Steering Angle Adjustment
- Ball Joint Dust Cover - Grease Application Revision
- Tire Chains - Usage Precautions
- Tires - Updated Rotation Recommendations
- Tires - Goodyear(R) Product Service Locations
- Vehicle - Body Vibration
- Interior - Wind Noise Diagnosis
- Vehicle - Aftermarket Accessories Precautions
- Sunroof - Changed Sunroof Water Test
- Propeller Shaft - Installation Procedure
- Propeller Shaft - Shudder/Suspension Bottoming Out
- A/T - Overheat Indication, Expanded Oil Pan
- A/T Oil Pan - Removal/Installation Revision
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Engine Controls - PCM Reprogramming Procedure
- Engine Controls - Oxygen Sensor Failure/DTC P0154
- Recall - Brake Vacuum Hose Replacement
- Recall 01V027000: Brake Vacuum Hose Defect
- Battery - Application Guide/Cold Cranking Amp Specs.
- A/T - 2nd To 3rd Gear Shift Flare
- Engine Controls - Hesitation/DTC P0154 (O2 Sensor)
- Electronic Compass - Revised Calibration Procedure
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- SRS - Front Impact Sensor (Revised Specification)
- Engine - Block Heater Update
- A/C - Pulsating/Rattle Noise
- Payload/Gross Vehicle Weight Rating Information
- Body - Squeak Noise on Bumps
- Body - Noise Diagnosis
- SRS - Warning Label Change
- Antitheft - Starting Using Immobilizer Override Function
- Antitheft - Immobilizer Override Codes Missing
- Antitheft - Procedure For No Start Problem
- Antitheft - Immobilizer System Service Information
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Engine Controls - DTC P0441
- Tools - Enhanced Diagnostic Testing & Feature Software
- Medic System - ROM Pack Reprogramming
- Cruise Control - DTC 12 Troubleshooting Revision
- Scan Tool - Multi-Use Tester II Warranty Coverage
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Liftgate Hatch - Noise From Rear of Vehicle
- Audio Speaker - Abnormal Noise
- Rear Liftgate - Improved Gas Spring
- Windshield - Wind Noise
- Wipers/Washers - Wiper Nut Torque Revisions
- Recall - Door Mirror Glass Replacement
- Instruments - Rearview Mirror Reading 'OC' or 'SC'
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T - New End-Play and Preload Measurement
- Audio System - CD Player Functional Problems
- Ignition Cable - Removal Instructions Update
- A/T - No Overdrive/Shift Delay
- A/C - Service Manual Revisions
- Engine - Oil Consumption/Oil Economy Test
- Instruments - Speedometer Inoperative/MIL ON/DTC 29 Set
- Remote Keyless Entry - Update
- Remote Keyless Entry - Identification/Programming
- Keyless Entry System - Description Revisions
- Interior - Buzz, Squeak, and Rattle Kit
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Color Codes/Applications
- Recall 01V254000: Hydraulic Brake Booster Accumulator
- A/T - 2nd to 3rd Gear Upshift Slip/Flare
- A/C - Compressor Pressure Relief Valve Service
- ATF Temperature Lamp - Manual Revision
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- Transfer Case Shift Lever - Stuck in 4H
- A/T - Improved Dipstick Design
- Brakes - Judder (vibration) Diagnosis and Repair
- Fuel System - Tank Pressure Sensor Specification Update
- Entertainment Device - CD Changer Installation
- Engine - Pinging Condition
- Suspension - Alignment Toe In Specification Incorrect
- A/T - Corroded Harness Splice Connections
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Torque Converter Housing - Revised Sealant Application
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Engine - Connecting Rod Identification Revision
- Body/Frame - Corrosion Inhibitor Information
- Drivetrain - Rear Differential Backlash Spec. Revision
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation