Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- Brakes, Rear - Squeaking Noise
- A/C - Musty/Moldy Odors In Passenger Compartment
- Drivetrain - Front Wheel Bearings Noisy
- Power Steering Pump - Whining Noise
- Engine - Diesel Noise at Idle
- Engine Misfire - DTCs P0301, P0303, P0305 Set
- Vehicle - Body Vibration
- Propeller Shaft - Vibration Between 40 to 50 mph
- Propeller Shaft - Shudder/Suspension Bottoming Out
- A/T - Overheat Indication, Expanded Oil Pan
- Engine Controls - MIL ON/DTC P0125 Set
- Engine Controls - Oxygen Sensor Failure/DTC P0154
- Power Windows/Seats/Radio/Sunroof - Inoperative
- A/T - 2nd To 3rd Gear Shift Flare
- Engine Controls - Hesitation/DTC P0154 (O2 Sensor)
- Radio - Noise During Seat Lumbar Adjustment
- Audio System - Speaker Static/Buzzing/Inoperative
- A/C - Pulsating/Rattle Noise
- Front Differential - Oil Leak at Freewheel Engage Switch
- Body - Squeak Noise on Bumps
- Fuel/Emissions - Sulfur Odor From Exhaust
- Liftgate Hatch - Noise From Rear of Vehicle
- Interior - Door Trim Panel/Air Vent Trim Scuffing
- Body - Sunroof Motor Malfunction
- Windshield - Wind Noise
- Instruments - Speedometer Inoperative/MIL ON/DTC 29 Set
- Audio System - Static/Popping/Poor Sound/Distortion
- Sunroof Deflector - Wind Noise/Rattling
- A/T - 2nd to 3rd Gear Upshift Slip/Flare
- Transfer Case Shift Lever - Stuck in 4H
- Superceded Bulletins
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-011 - 07/01/01
- 01-00-008 - 03/01/01
- 00-51-001 - 09/01/00
- 00-42A-003 - 04/01/00
- 00-23-004 - 05/01/00
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Body - Sunroof is Inoperative
- Recall - Brake Booster Replacement
- Recall - Brake Booster Accumulator Replacement
- A/T - 2nd to 3rd Gear Upshift Flare
- MEDIC System - ROM Pack Reprogramming
- A/T - 2nd to 3rd Gear Shift Flare
- Engine - Testing for Excessive Oil Consumption
- Engine - Oil Economy Test/Consumption Diagnosis
- A/C - Rattling/Pulsating Noise With A/C ON
- Wheels/Tires - Balancing Information
- Tires/wheels - Tire Chain Usage Information
- Engine Controls - Hesitation/O2 Sensor Failure/DTC P0154
- All Technical Service Bulletins
- Recall - Headlamp Inspection/Replacement
- Restraints - SRS Component Disposal Information
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Engine Performance - Revised A/C Idle Speed
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- A/C - Compressor Oil Correction
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- Drivetrain - RWD/4WD Light Blinks
- Tool - Battery/Starting/Charging System Analyzer
- Brakes, Rear - Squeaking Noise
- Brakes, Rear Pad Shims - Service Manual Revision
- RV-Meter Driving Range/Compass Display - Incorrect
- Instruments - RV Meter Readings Incorrect
- A/C - Musty/Moldy Odors In Passenger Compartment
- Drivetrain - Front Wheel Bearings Noisy
- Power Steering Pump - Whining Noise
- Engine - Valve Lash Adjuster Cleaning Procedure
- Valve Lash Adjuster - Bleeding Procedure Revision
- Engine - Replacement Piston Selection
- Engine - Diesel Noise at Idle
- Campaign - Radiator Replacement
- Engine Misfire - DTCs P0301, P0303, P0305 Set
- Engine Oil Cooler - Revised Service Manual Illustration
- Suspension - Ball Joint End Play Procedure Revision
- Ball Joint Dust Cover - Grease Application Revision
- Tire Chains - Usage Precautions
- Wheels - Balancing Procedure
- Tires - Goodyear(R) Product Service Locations
- Vehicle - Body Vibration
- Heated Seat/Power Seat - Diagram/Description Revision
- Vehicle - Aftermarket Accessories Precautions
- Propeller Shaft - Vibration Between 40 to 50 mph
- Propeller Shaft - Installation Procedure
- Propeller Shaft - Shudder/Suspension Bottoming Out
- A/T - Overheat Indication, Expanded Oil Pan
- A/T Oil Pan - Removal/Installation Revision
- A/T - Cooler Tube/Transfer Case Shift Lever Updates
- Engine Controls - PCM Reprogramming Procedure
- DTC P0134 & P0154 (O2S) - Diagnosis Corrections
- Engine Controls - MIL ON/DTC P0125 Set
- Engine Controls - Oxygen Sensor Failure/DTC P0154
- Vehicle Speed Sensor - Manual Correction
- Brake Booster Pressure Switch - Manual Correction
- Recall - Defective Hydraulic Brake Booster Accumulator
- Brakes - Hydraulic Booster Pressure Switch Checks Update
- Brakes - Brake Booster Accumulator Disposal Revision
- Recall - Brake Vacuum Hose Replacement
- Recall 01V027000: Brake Vacuum Hose Defect
- Battery - Application Guide/Cold Cranking Amp Specs.
- Power Windows/Seats/Radio/Sunroof - Inoperative
- A/T - 2nd To 3rd Gear Shift Flare
- Engine Controls - Hesitation/DTC P0154 (O2 Sensor)
- Recall - Emissions Vacuum Hose Routing Label
- Power Window Motor - Installation Revision
- Radio - Noise During Seat Lumbar Adjustment
- Audio System - Speaker Static/Buzzing/Inoperative
- SRS ECU Connector - Pin Number Correction
- Interior Lighting - Corrected Circuit Diagrams
- Engine - Block Heater Update
- A/C - Pulsating/Rattle Noise
- Front Differential - Oil Leak at Freewheel Engage Switch
- Payload/Gross Vehicle Weight Rating Information
- Body - Squeak Noise on Bumps
- Body - Noise Diagnosis
- SRS - Page Number Reference Revision
- Model VIN Codes Revised
- Emissions - Corrected Vacuum Hose Routing Diagrams
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Fuel/Emissions - EVAP Canister Hose Removal Caution
- Engine Controls - DTC P0441
- Evaporative System - DTC P0441 Procedure Update
- DTC P0183 - Troubleshooting, Manual Revision
- Medic System - ROM Pack Reprogramming
- Cruise Control - DTC 12 Troubleshooting Revision
- Scan Tool - Multi-Use Tester II Warranty Coverage
- Scan Tool - Correct Connection Procedure
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Liftgate Hatch - Noise From Rear of Vehicle
- Interior - Door Trim Panel/Air Vent Trim Scuffing
- Sunroof - Motor Installation Revision
- Body - Sunroof Motor Malfunction
- Windshield - Wind Noise
- Campaign - Wiper Arm Nut Replacement
- Wipers/Washers - Wiper Nut Torque Revisions
- Instruments - Rearview Mirror Reading 'OC' or 'SC'
- Exterior Moldings - Removal/Installation Revision
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T - Hydraulic Pressure Tables Manual Revision
- A/T - New End-Play and Preload Measurement
- Audio System - CD Player Functional Problems
- A/T - No Overdrive/Shift Delay
- A/C - Service Manual Revisions
- A/C - Compressor Controller Voltage Table Revision
- Engine - Oil Consumption/Oil Economy Test
- Electrical - Repair Manual Incomplete Page Correction
- Circuit Diagrams - `How to Read Diagrams' Corrections
- Electrical Configuration Diagrams - Manual Revision
- Circuit Diagrams - Service Manual Revision
- Instruments - Speedometer Inoperative/MIL ON/DTC 29 Set
- Remote Keyless Entry - Systems Identification
- Window Glass - Adhesive Removal Revision
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Color Codes - Information and Cross Reference
- Fuel Tank Filler Valve Flap - Elimination
- Ignition System Capacitor - Manual Revision
- Sunroof Deflector - Wind Noise/Rattling
- Recall 01V254000: Hydraulic Brake Booster Accumulator
- A/T - 2nd to 3rd Gear Upshift Slip/Flare
- A/C - Compressor Pressure Relief Valve Service
- Brake Booster - Caution Label Update
- A/C - Refrigerant Capacity Revision
- Transfer Case Shift Lever - Stuck in 4H
- Instruments - RV Meter Temperature Display Update
- Body - Rear Seat Does Not Unlatch
- Fuel System - Tank Pressure Sensor Specification Update
- Engine - Pinging Condition
- Seat Belt Extension - Manual Revision
- A/T - Corroded Harness Splice Connections
- Recall - Child Seat Installation Instructions
- Side Step - Revised Mounting
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Engine - Connecting Rod Identification Revision
- Body/Frame - Corrosion Inhibitor Information
- Drivetrain - Rear Differential Backlash Spec. Revision
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Axle - Rear Axle Shaft Flange Loose
- Engine - Fouled Spark Plugs Causing Misfire
- Cooling - Coolant Leak Update
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation