Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- A/C - Musty/Moldy Odors In Passenger Compartment
- Drivetrain - Front Wheel Bearings Noisy
- Engine - Diesel Noise at Idle
- Vehicle - Body Vibration
- Propeller Shaft - Shudder/Suspension Bottoming Out
- Engine Controls - MIL ON/DTC P0125 Set
- Power Windows/Seats/Radio/Sunroof - Inoperative
- Engine Controls - Hesitation/DTC P0154 (O2 Sensor)
- Audio System - Speaker Static/Buzzing/Inoperative
- A/C - Pulsating/Rattle Noise
- Body - Squeak Noise on Bumps
- Fuel/Emissions - Sulfur Odor From Exhaust
- Liftgate Hatch - Noise From Rear of Vehicle
- Interior - Door Trim Panel/Air Vent Trim Scuffing
- Body - Sunroof Motor Malfunction
- Drivetrain - 4WD Lamp Flashing/DTC33 Set
- Instruments - Speedometer Inoperative/MIL ON/DTC 29 Set
- Audio System - Static/Popping/Poor Sound/Distortion
- A/T - 2nd to 3rd Gear Upshift Slip/Flare
- Superceded Bulletins
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-009R - 12/01/01
- 00-42A-003 - 04/01/00
- VIN - Decoding Chart
- Lighting - Moisture In Headlamps
- Body - Sunroof is Inoperative
- Immobilizer System - Information Update
- A/T - 2nd to 3rd Gear Upshift Flare
- Engine - Testing for Excessive Oil Consumption
- Engine - Oil Economy Test/Consumption Diagnosis
- Engine Controls - Hesitation/O2 Sensor Failure/DTC P0154
- All Technical Service Bulletins
- Recall - Headlamp Inspection/Replacement
- Restraints - SRS Component Disposal Information
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Load Capacity Reduction Label Information
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Vehicle Identification Number - New Model Revisions
- General Technical Specifications
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- A/C - Compressor Oil Correction
- A/T - Shudder/Surge/Vibration From 35 - 50 Mph
- Drivetrain - RWD/4WD Light Blinks
- Brakes, Rear Pad Shims - Service Manual Revision
- RV-Meter Driving Range/Compass Display - Incorrect
- Instruments - RV Meter Readings Incorrect
- A/C - Musty/Moldy Odors In Passenger Compartment
- Drivetrain - Front Wheel Bearings Noisy
- Engine - Valve Lash Adjuster Cleaning Procedure
- Engine - Replacement Piston Selection
- Engine - Diesel Noise at Idle
- Suspension - Ball Joint End Play Procedure Revision
- Wheels - Wheel Nut Torque Revision
- Tires - Goodyear(R) Product Service Locations
- Vehicle - Body Vibration
- Tire Chain - Usage Recommendations
- Heated Seat/Power Seat - Diagram/Description Revision
- Vehicle - Aftermarket Accessories Precautions
- Sunroof - Sunroof Mechanism Contacts Roof Panel
- Propeller Shaft - Installation Procedure
- Propeller Shaft - Shudder/Suspension Bottoming Out
- PCM Backup Power Supply - Manual Corrections
- Engine Controls - PCM Reprogramming Procedure
- Engine Controls - MIL ON/DTC P0125 Set
- Recall - Defective Hydraulic Brake Booster Accumulator
- Brakes - Hydraulic Booster Pressure Switch Checks Update
- Brakes - Brake Booster Accumulator Disposal Revision
- Battery - Application Guide/Cold Cranking Amp Specs.
- Power Windows/Seats/Radio/Sunroof - Inoperative
- Engine Controls - Hesitation/DTC P0154 (O2 Sensor)
- Engine - Poor High RPM Acceleration
- Recall - Emissions Vacuum Hose Routing Label
- Power Window Motor - Installation Revision
- Audio System - Speaker Static/Buzzing/Inoperative
- Engine Block Heaters - Usage
- A/C - Pulsating/Rattle Noise
- Body - Squeak Noise on Bumps
- Body - Noise Diagnosis
- Immobilizer Key Check - Manual Revision
- Antitheft - Immobilizer System Service Information
- Emissions - Corrected Vacuum Hose Routing Diagrams
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls/Emissions - OBDII Drive Cycle Revisions
- Fuel/Emissions - EVAP Canister Hose Removal Caution
- Engine Controls - DTC P0441
- ECU - Connector identification Correction
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Liftgate Hatch - Noise From Rear of Vehicle
- Interior - Door Trim Panel/Air Vent Trim Scuffing
- Body - Sunroof Motor Malfunction
- Wipers/Washers - Wiper Nut Torque Revisions
- Instruments - Rearview Mirror Reading 'OC' or 'SC'
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- A/T - Hydraulic Pressure Tables Manual Revision
- A/T - New End-Play and Preload Measurement
- Audio System - CD Player Functional Problems
- A/C - Inoperative/A/C Light Blinks
- Drivetrain - 4WD Lamp Flashing/DTC33 Set
- A/T - No Overdrive/Shift Delay
- Instruments - Speedometer is Inoperative
- A/C - Service Manual Revisions
- A/C - Compressor Controller Voltage Table Revision
- Engine - Oil Consumption/Oil Economy Test
- Instruments - Speedometer Inoperative/MIL ON/DTC 29 Set
- Remote Keyless Entry - Description/Operation
- Body - Wind Buffeting
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Exterior Color Codes and Applications
- Fuel Tank Filler Valve Flap - Elimination
- A/T - 2nd to 3rd Gear Upshift Slip/Flare
- Drivetrain - Transfer Case Oil Capacity Revision
- A/C - Compressor Pressure Relief Valve Service
- Antitheft - Registration Of Additional Immobilizer Keys
- A/C - Refrigerant Capacity Revision
- Instruments - RV Meter Temperature Display Update
- Body - Rear Seat Does Not Unlatch
- Fuel System - Tank Pressure Sensor Specification Update
- Engine - Pinging Condition
- A/T - Corroded Harness Splice Connections
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Engine - Connecting Rod Identification Revision
- Body/Frame - Corrosion Inhibitor Information
- Drivetrain - Rear Differential Backlash Spec. Revision
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Axle - Rear Axle Shaft Flange Loose
- Engine - Fouled Spark Plugs Causing Misfire
- Cooling - Coolant Leak Update
- Powertrain, Antitheft - ECU & PCM Replacement
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine Controls - Revised Misfire DTC Information
- Body - Revised Door Adjustment Procedure
- Restraints - Revised SRS ECU Removal and Installation