Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Engine - Valve Noise at Start-up
- Engine - Erratic Idle/Low Performance/MIL ON
- Spark Plug - Fouling
- Rear Suspension - Squeak/Rubbing Noise
- Door Glass - Creaking/Popping Noise
- Door - Rattle With Radio On High Volume
- Top Stack (Convertible Top) - Interior Water Leaks
- Headliner - Sags
- Convertible Top Headliner - Loose At Rear Glass
- A/T - Enters `Limp-In' Mode/DTC's Set
- Power Seat - Moves After Switch Is Released
- Audio System - Speaker Static/Buzzing/Inoperative
- Fuel/Emissions - Sulfur Odor From Exhaust
- Rear Speaker - Buzz or Rattle
- Door Window - Popping/Rattling/Squeaking
- Top Stack (Convertable Top) - Bent Control Link
- Convertible Top - Abnormal Wear At 1/4 Glass
- Convertible Top - Flipper Arm Bent
- Convertible Top - Separation From Frame
- Sunroof - Inoperative/Remains Open
- Windshield - Wind Noise
- Interior - Water Leaks
- Front Windshield Washer - Nozzle Leakage
- A/T - F4AC1 Limp-In Mode/DTC's Set
- Ignition Switch - Key Difficult to Remove
- Convertible Top - Creaking Noise
- Topstack (Convertible Top) Latch Receiver - Changes
- Radio - Poor Reception
- Window - Chemical Film Build-Up/Fogging
- Audio System - Static/Popping/Poor Sound/Distortion
- Suspension - Front Creaking/Poping/Squeaking Noises
- Sunroof - Difficult Sunshade Operation
- Interior - Door Trim Defroster Garnish Cracked
- Brakes - Judder (vibration) Diagnosis and Repair
- Quarter Panel - Body Creaks
- Recommended Repairs
- Superceded Bulletins
- 99-002 - 06/01/99
- 98-34-001 - 05/01/98
- 96-11-002 - 03/01/96
- 91-52B-002 - 02/01/97
- 05-54-002 - 02/01/04
- 03-55-005 - 06/01/03
- 01-00-011 - 07/01/01
- Lighting - Moisture In Headlamps
- Speedometer/Odometer - Replacement/Mileage Setting
- Audio System - Diagnosis
- Remote Keyless Entry - Service Information
- Recall - Lower Lateral Arm Ball Joint Boot
- Recall - Lower Ball Joint Replacement
- OBD II Monitor Readiness - Drive Cycle Procedures
- Cylinder Block - Heater Installation Procedure
- Engine Block Heater - Application and Installation
- All Technical Service Bulletins
- Interior - Avoiding Floor Mat/Pedal Entrapment/Interference
- Body/Frame - Double-Sided Tape Application Revision
- Interior - Floor Mat Selection/Installation Precautions
- Vehicle - Friction Modifier Covered Bolt/Nut Usage
- Vehicle - VIN Plate Installation After Dash Replacement
- Engine - Spark Knock/Ping Diagnostic's
- Fuel/Emissions - Loose Gas Cap/MIL ON
- Sealant/Adhesive/Chemical - Interchange Information
- Tools - Multi-Use Tester Warranty
- VIN - Decoding Information
- New Model - Service Manual Revision
- VIN - Decoder
- A/C Installation Manual Corrections
- A/C - Replacement of HVAC System
- A/C - Mist or Fog From Dash Vents
- A/C - Poor Performance/High Gauge Readings
- Engine - Valve Noise at Start-up
- Tool - Battery/Starting/Charging System Analyzer
- Engine - Erratic Idle/Low Performance/MIL ON
- Spark Plug - Fouling
- A/C Magnetic Clutch - Corrected Service Procedures
- Engine - Revised Nut & Bolt Tightening Specifications
- Valve Guide - Replacement Procedure Correction
- Engine - Valve Lash Adjuster Cleaning Procedure
- Valve Lash Adjuster Noise - Troubleshooting Procedures
- Piston Pin - Installation Tool Instructions
- Timing Belt Auto Tensioner - Testing
- Recall 00V421001: Lower Ball Joint Separation
- Recall 99V066001: Damaged Lower Ball Joint Boots
- Recall - Lower Ball Joint/Control Arm Inspection
- Rear Suspension - Squeak/Rubbing Noise
- Wheel - Balancing Accuracy Tips
- Tire Chain - Usage
- Tires - Goodyear(R) Product Service Locations
- Door Glass - Creaking/Popping Noise
- Door - Rattle With Radio On High Volume
- Interior - Wind Noise Diagnosis
- Top Stack (Convertible Top) - Interior Water Leaks
- Hard Top/Convertible Top - ASC Authorized Facilities
- Headliner - Sags
- Convertible Top Headliner - Loose At Rear Glass
- A/T Oil Cooler - Backflush Alternative
- A/T - Perform Cooler Flow Test When Replacing A/T
- Recall - ECM Replacement
- Engine Controls - PCM Reprogramming Procedure
- CV Joint Boot - Replacement Tool/Installation
- Rear Wheel ABS Speed Sensor - Revised Resistance Value
- Brake Booster - Push Rod Adjustment
- Battery - Application Guide/Cold Cranking Amp Specs.
- Generator Stator - Removal Procedure Revision
- A/T - Enters `Limp-In' Mode/DTC's Set
- Recall 96V158000: Fuel Pump/Fuel Gauge Unit Gasket Leak
- Throttle Body - Overhaul Procedure
- Rear Window Defogger Grid - Repair
- Power Seat - Moves After Switch Is Released
- Power Seat - Motor Replacement Procedure
- Audio System - Speaker Static/Buzzing/Inoperative
- Air Bag - Minimizing Deployment Risk
- SRS Air Bag Troubleshooting - Revision
- SRS Cautions and Warnings - Revision
- SRS - Diagnostic Trouble Code (DTC) Erasure
- Engine - Block Heater Update
- Crankshaft Bearing - Selection Chart & Procedure
- Fuel Guage Tank Unit - Installation Procedure
- Headlights - Aiming Procedures Revised
- Engine - Revised Cylinder Head Gasket Design
- Antilock Brake System - Diagnosis
- ABS - Data List Reference/Actuator Test Reference Table
- Payload/Gross Vehicle Weight Rating Information
- Synthetic Resin Parts - Heat Resistance Specifications
- Body - Noise Diagnosis
- Recall - Vacuum Hose Routing Diagram Label
- OBD II - MIL ON With No DTC's Set During I/M Check
- Emissions - OBDII Readiness Code Information
- Emissions - OBD-II I/M Program Summary
- Fuel/Emissions - Sulfur Odor From Exhaust
- Engine Controls - DTC P0441
- Fuel System - Service Manual Corrections
- Tools - Enhanced Diagnostic Testing & Feature Software
- Engine Controls - SCAN Tool Display Term Changes
- Fuel System - MIL ON with DTC P0171/174
- Fuel System - EVAP DTC's & Check Engine Light
- Rear Speaker - Buzz or Rattle
- Door Window - Popping/Rattling/Squeaking
- Top Stack (Convertable Top) - Bent Control Link
- Convertible Top - Abnormal Wear At 1/4 Glass
- Convertible Top - Flipper Arm Bent
- Convertible Top - Separation From Frame
- Sunroof Drive Motor Insert Clip - Precautions
- Sunroof - Inoperative/Remains Open
- Windshield - Wind Noise
- Interior - Water Leaks
- Front Windshield Washer - Nozzle Leakage
- Engine - Oil Recommendations/Obsolete Oils
- Engine - Using Low-Quality Engine Oil
- Automatic Transaxle - Improved Rear Clutch
- A/T - F4AC1 Limp-In Mode/DTC's Set
- A/T - Remanufacturing Program.
- A/T, Remanufactured - Program Update
- A/T - Recommended Maintenance
- A/T - New End-Play and Preload Measurement
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Recommended Maintainence
- Ignition Switch - Key Difficult to Remove
- Engine - Oil Economy Test
- Engine - Oil Consumption/Oil Economy Test
- Charging System Circuit - Missing Diagram
- MFI - Troubleshooting Charts Revision
- Fuel - Poor Driveability Using Premium
- Drive Axles - Axle Shaft Boot Kit Lubricant
- Convertible Top - Creaking Noise
- Convertible Top Cover - Replacement Instructions
- Electric Convertible Top - Supplement Revision
- Topstack (Convertible Top) Latch Receiver - Changes
- Remote Keyless Entry - Update
- Radio - Poor Reception
- Antenna - Inspection and Caution Revision
- Automatic Transaxle - Shift Characteristics of F4A
- Interior - Buzz, Squeak, and Rattle Kit
- Window - Chemical Film Build-Up/Fogging
- Body - Wind Buffeting
- Audio Systems - Technical Assistance & Error Codes
- Audio System - Diagnosis/Troubleshooting
- Audio System - Static/Popping/Poor Sound/Distortion
- Paint - Damage Identification and Repair
- Paint - Exterior Color Codes and Applications
- A/C Compressor Revolution Sensor - Resistance Revision
- Recall 96V158001: Fuel Tank Unit Gasket Leak
- A/C - Compressor Pressure Relief Valve Service
- Power Seat Limit Switch - Service Manual Revision
- Front Axle - Drive Shaft Removal Procedure
- Fluids, Refrigerants and Materials (Genuine Mitsubishi)
- A/C Refrigerant - Service Information
- Overview
- Refrigerants and Their Availability
- System Differences
- Refrigerant Differences
- Lubricant Differences
- Retrofitting Systems
- Recovery and Recycling of Refrigerants
- Storing Recycled Refrigerant
- Transferring Recycled Refrigerant
- System Flushing
- Typical Cause of A/C System Contamination
- Mixing Refrigerants
- Contaminated Service Equipment
- Disposing of Contaminated Refrigerant
- M/T Shift Lever - Operational Inspection Revision
- Homelink Universal Transmitter System - Features
- Garage Door Transmitter - Reprogramming Procedure
- Suspension - Front Creaking/Poping/Squeaking Noises
- Sunroof - Difficult Sunshade Operation
- Interior - Door Trim Defroster Garnish Cracked
- Service Manual - Missing Pages
- Brakes - Judder (vibration) Diagnosis and Repair
- Hardtop - Performance Characteristics
- Engine - Pinging Condition
- Quarter Panel - Body Creaks
- Interior - Child Safety Seat Upper Tether Anchor Kits
- Emissions - Additional EGR System Diagnostics
- Instruments - Odometer Reset After Replacing Speedometer
- M/T - Revised Clutch Interlock Switch Service Precaution
- Lighting/Brakes - Brake Light Switch Service Precautions
- Restraints - Revised Clockspring Alignment Procedure
- Body/Frame - Corrosion Inhibitor Information
- Cooling System - Water Pump Leak Inspection
- Suspension - Shock Absorber Leakage Inspection
- Engine - Fouled Spark Plugs Causing Misfire
- Lighting - Headlamp Moisture Information
- Powertrain - DTC P0172 & P0175
- Alignment - Two Wheel Vs. Four Wheel
- Engine - Lead Free Crankshaft Bearing Info. Revision
- Engine Controls - Revised Misfire DTC Information
- Restraints - Revised SRS ECU Removal and Installation