Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall R1108 - L/H Front Strut Housing NON-SALT STATES
- Overview
- Table of Contents
- Repair Overview
- Service Procedure
- Note
- Inspect For Corrosion In the Driver Side and Passenger Side Front Wheel House Areas
- Determine If Vehicle Is Repairable (Driver Side and Passenger Side Inspection)
- Repair Chart
- Level 1 Repair (Driver Side and Passenger Side)
- Level 2 Repair ( Driver Side and Passenger Side)
- Steering Shaft Replacement
- Example Photos (Perforation and Scab Corrosion)
- Required Special Tools
- Parts Information
- Claims Information
- Owner Letter
- Non Repairable Report
- Recall R1107 - L/H Front Strut Housing SALT STATES
- Overview
- Repair Overview
- Required Special Tools
- Service Procedure
- Determine If Vehicle Is Repairable and the Repair Level (Driver Side and Passenger Side)
- Level 1 Repair (Driver Side and Passenger Side)
- Level 2 Repair (Driver and Passenger Side)
- Steering Shaft Replacement
- Example Photos (Perforation and Scab Corrosion)
- Parts Information
- Claims Information
- Owner Letter
- Non Repairable Report
- Recall R1101 - Front Strut Housing Corrosion Inspection
- Recall 11V244000: Front Strut Housing Corrosion
- Recall 01V282000: Rear Hatch Cylinder Mount Defect
- Recall - Rear Hatch Strut Bracket Replacement
- Recall 07V435000: Fuel Filler Tube Replacement
- Recall R0705 & R0706 - Fuel Filler Tube Replacement
- Recall 13V13600: Front Passenger Air Bag Defect
- Recall R1108 - L/H Front Strut Housing NON-SALT STATES
- Customer Interest
- Steering/Suspension - Pull Or Drift Diagnostic Info
- Interior - Driver's Seat Won't Move Forward/Backward
- Steering/Body - Vibration Between 60 & 70 Mph
- MIL ON - DTC P0505 (Electronic Idle Control)
- P/S Pump - Fluid Leaks at Fitting
- Brakes - Front Brake Vibration/Pulsation/Judder
- Shock Absorber (R/H Rear) - Squeak/Creak Noise
- Body - Tire Dressing Stains Vehicle Paint
- Steering Column - Squeaking/Rubbing Noise
- Transfer Case - Stuck in 4WD Low
- ECM - MIL ON DTC P1441 Set
- Emissions - MIL ON/O2 Sensor DTC's Set
- Engine Controls - MIL ON/DTC P0420/P0430
- EVAP Canister - Charcoal Leakage
- TCM - 1st to 2nd Gear Shift Flare
- A/T - 1st to 2nd or 2nd to 3rd Gear Shift Flare
- Navigation System - Multiple Malfunctions
- Interior - Seat Belt Latch Plate Button Missing
- Tachometer - Needle on Wrong Side of Stop Pin
- Headlamp (Plastic) - Cloudy/Hazy Appearance
- Emissions System - MIL ON/DTC P1491 (EVAP) Stored
- Hatch Latch (Rear) - Moves to Secondary Latch Position
- Hatch (Rear) - License Plate Rattles
- Cooling System - Leaks/Overheating
- Steering - Pull/Drift
- Seat (Drivers) - Side to Side Movement on Turns
- Interior - Dash Squeak/Rattle/Creak From Right Hand Side
- Instruments - Inaccurate Roof Console Temp. Display
- Suspension - Rear Suspension Bottoms Out
- Sunglass Holder Lid - Will Not Close Properly
- MIL ON - DTC P0138/P0139/P0140 or P0158/P0159/P0160
- A/C - Refrigerant Leaks From Connections
- Restraints - Seat Belt Retract Slowly
- Superceded Bulletins
- 11-074 - 08/01/11
- 04-054A - 06/01/06
- 04-054 - 06/01/04
- 08-033 - 06/01/08
- 99-048S - 07/01/08
- 08-055 - 07/01/08
- 03-074B - 06/01/08
- 99-048N - 02/01/06
- 99-048M - 01/01/06
- 99-048C - 07/28/00
- 99-048B - 07/28/00
- 99-022B - 08/05/03
- 99-020A - 03/27/02
- 99-048I - 05/20/03
- 99-048G - 05/20/03
- 99-048F - 05/20/03
- 99-048E - 05/20/03
- 02-011 - 03/11/02
- 01-087 - 12/05/01
- 01-070 - 10/15/01
- 01-062 - 09/21/01
- 01-055 - 09/04/01
- 01-041 - 04/04/03
- 00-084 - 09/24/01
- 00-078 - 12/05/00
- 00-074 - 11/16/00
- 00-059 - 08/30/00
- 00-056 - 11/08/00
- 00-052 - 08/30/00
- 00-037 - 11/30/00
- 00-006B - 10/06/03
- Lighting - Headlamp Fogging
- 03-074C - 07/21/08
- Lighting - Exterior Lamp Fogging Inspection
- Lighting - Exterior Lamps Fogging Information
- Lighting - Exterior Lamp Fogging Information
- Drivers Seat - Will Not Move Forward or Back
- Entertainment System - CD/DVD Player Concerns
- Entertainment System - CD/DVD Player Concerns
- Antitheft System - Key Registration Procedure
- Restraint System - Seatbelts Slow to Retract
- Seat Belt - Slow Retraction
- 08-055A - 07/21/08
- Air Bag System - Tampering Precautions
- Air Bag - Side SRS Tampering/Modification Precautions
- Steering/Suspension - Vehicle Pull Diagnosis
- Recall R1108 - L/H Front Strut Housing NON-SALT STATES
- Recall R1107 - L/H Front Strut Housing SALT STATES
- Recall - L/H Front Strut Housing Corrosion (Salt States)
- Recall - L/H Front Strut Housing Corrosion (Non-Salt)
- Recall R1107 - L/H Front Strut Housing (Salt States)
- Recall R1108 - L/H Front Strut Housing (Non-Salt States)
- Recall R1107 - L/H Front Strut Housing Corrosion
- 11-066 - 08/10/11
- Recall R1101 - Front Strut Housing Corrosion
- Battery/Starting/Charging System - Testing
- 99-048T - 07/22/08
- 99-048R - 02/13/08
- Battery - Testing Procedures & Equipment
- Battery - Testing Equipment/Procedures
- Battery - Testing Procedures/Replacement
- Battery - Testing/Replacement
- Battery - Testing/Equipment/Replacement Applications
- Battery - OE And Replacement Ratings
- Brakes - Judder/Noise/Pedal Feel Diagnosis/Repair
- Brakes - Judder/Vibration Diagnosis/Repair
- Brakes - Noise/Judder/Feel Diagnosis & Repair
- Brakes - Judder/Noise/Pedal Feel Diagnosis & Repair
- Brakes - ABS Self Check Noise Explanation
- Transfer Case - Rumbling Noise From Companion Flange
- A/T - Oil Cooler Cleaning Procedure
- Emissions - System Readiness Test (SRT) Drive Patterns
- Emissions - EVAP System Leak DTC Diagnosis
- Emissions - EVAP Canister Vent Control Valve Replacement
- Emissions - DTC P0440/P0442/P0455/P0456/P1440/P1456
- Engine Controls - ECM Reprogramming
- Engine Controls - MIL ON/DTC P0420/P0430 Set
- ECM - Reprogramming Procedures
- ECM - Replacement/Reprogramming Procedures
- Engine Controls - PCM Replacement Procedures
- Engine/Transmission - Replacement Precautions
- Engine - MIL ON/Variable Valve Timing DTC's Set
- Steering/Suspension - Vehicle Pull/Drift Information
- Steering/Suspension - Vehicle Pulls/Drifts Left/Right
- Tires - Tire Pressure Information
- Steering/Suspension - Vehicle Pulls Or Drifts
- Vehicle - VIN Plate/Certification Label Replacement
- Steering/Suspension - Wheel Alignment Information
- Steering/Suspension - Wheel Alignment Info.
- 08-097C - 05/05/11
- Steering/Suspension - Pull Or Drift Diagnostics
- Wheels/Tires - Wheel Balancing Info.
- Steering/Suspension - Pull Or Drift Diagnostic Info.
- Vehicle - Flat Towing Guidelines/Limitations
- Vehicle - Guidelines For Flat Towing
- Vehicle - Flat Towing Recommendations
- Vehicle - Flat Towing Guidelines
- M/T - Required Fluid
- M/T - Required Oil for Warranty Repairs
- 11-064 - 07/14/11
- All Technical Service Bulletins
- Emissions - System Readiness Test (SRT) Drive Patterns
- Computers/Controls - CONSULT III Plus(R) Saved Data List
- Body Controls - Configurable BCM Replacement Information
- Wheels/Tires - Wheel/Tire Balancing Information
- Recall R1108 - L/H Front Strut Housing NON-SALT STATES
- Overview
- Table of Contents
- Repair Overview
- Service Procedure
- Note
- Inspect For Corrosion In the Driver Side and Passenger Side Front Wheel House Areas
- Determine If Vehicle Is Repairable (Driver Side and Passenger Side Inspection)
- Repair Chart
- Level 1 Repair (Driver Side and Passenger Side)
- Level 2 Repair ( Driver Side and Passenger Side)
- Steering Shaft Replacement
- Example Photos (Perforation and Scab Corrosion)
- Required Special Tools
- Parts Information
- Claims Information
- Owner Letter
- Non Repairable Report
- Recall R1107 - L/H Front Strut Housing SALT STATES
- Overview
- Repair Overview
- Required Special Tools
- Service Procedure
- Determine If Vehicle Is Repairable and the Repair Level (Driver Side and Passenger Side)
- Level 1 Repair (Driver Side and Passenger Side)
- Level 2 Repair (Driver and Passenger Side)
- Steering Shaft Replacement
- Example Photos (Perforation and Scab Corrosion)
- Parts Information
- Claims Information
- Owner Letter
- Non Repairable Report
- Vehicle - Vehicle Vibration Customer Diagnostic Worksheet
- Lighting - Exterior Lamp Fogging
- Steering/Suspension - Pull Or Drift Diagnostic Info
- Steering/Suspension - Wheel Alignment Info
- Keyless Systems/TPMS - SIGNAL TECH II(R) Diag. Tool
- ABS/TCS - ABS Self-Check Noise Information
- Electrical - JIS & CCA Battery Testing Information
- Interior/Restraints - Seat Trim Material Information
- Engine Controls - ECM Programming Information
- Vehicle - Certification Label/VIN Plate Replacement
- Interior - Driver's Seat Won't Move Forward/Backward
- Engine Controls - ECM Programming Interruption Recovery
- Recall R1101 - Front Strut Housing Corrosion Inspection
- Wheels/Tires - Hunter GSP9700(R) Set Up Information
- Recall 11V244000: Front Strut Housing Corrosion
- Wheels/Tires - Tire Mounting Information
- Steering/Body - Vibration Between 60 & 70 Mph
- Engine/Transmission - Precautions During R&R Procedure
- MIL ON - DTC P0505 (Electronic Idle Control)
- P/S Pump - Fluid Leaks at Fitting
- Brakes - Front Brake Vibration/Pulsation/Judder
- Shock Absorber (R/H Rear) - Squeak/Creak Noise
- Body - Tire Dressing Stains Vehicle Paint
- Body - Window Regulator/Motor Service Update
- Steering Column - Squeaking/Rubbing Noise
- Transfer Case - Stuck in 4WD Low
- A/T - Mandatory Oil Cooler Cleaning
- ECM - MIL ON DTC P1441 Set
- Engine Controls - ECM Replacement Procedures
- Emissions - MIL ON/O2 Sensor DTC's Set
- Battery - Maintenance and Servicing
- Engine Controls - MIL ON/DTC P0420/P0430
- EVAP Canister - Charcoal Leakage
- TCM - 1st to 2nd Gear Shift Flare
- A/T - 1st to 2nd or 2nd to 3rd Gear Shift Flare
- Navigation System - Multiple Malfunctions
- Interior - Seat Belt Latch Plate Button Missing
- Brakes - On-Car Rotor Refinishing
- Tachometer - Needle on Wrong Side of Stop Pin
- Headlamp (Plastic) - Cloudy/Hazy Appearance
- Headlight Connector - Replacement
- Entertainment System - Introduction & Diagnosis
- Antitheft System - Description/Key Registration
- Tools - CONSULT-II Software Update
- Tools - CONSULT-II NATS Software Update
- CONSULT-II - ECM Reprogramming Software
- Tools - CONSULT-II Repair Procedures
- Essential Tool - OBD II Connector Kit
- Emissions System - MIL ON/DTC P1491 (EVAP) Stored
- Hatch Latch (Rear) - Moves to Secondary Latch Position
- Recall 01V282000: Rear Hatch Cylinder Mount Defect
- Recall - Rear Hatch Strut Bracket Replacement
- Hatch (Rear) - License Plate Rattles
- Engine Coolant - Special Refilling Tool
- Cooling System - Leaks/Overheating
- Axle Bearing (Rear) - Removal Kit/Service Procedure
- CD Changer - CD Care and Usage Guidelines
- Steering - Pull/Drift
- Navigation System - Software Kit Installation
- Paint - Codes & Cross References
- Paint - Removal of Environmental Particles
- Seat (Drivers) - Side to Side Movement on Turns
- Interior - Dash Squeak/Rattle/Creak From Right Hand Side
- Accessories - Homelink(R) Transmitter Service
- Instruments - Inaccurate Roof Console Temp. Display
- Maintenance - Revised Procedures
- Suspension - Rear Suspension Bottoms Out
- Special Tools - Fuel Pressure Gauge Kit
- EVAP Vent Control Valve - DTC'S Stored in Memory
- Sunglass Holder Lid - Will Not Close Properly
- Entertainment System - Introduction/Diagnostics
- Overview
- Service Procedure
- Information
- DVD Mobile Entertainment System Function Test
- DVD Mobile Entertainment System Diagnostic Flow Charts
- Remove/Replace of DVD Unit/Check DVD to Interface Box CONN.
- DVD Mobile Entertainment System Fuse Check Procedure
- Interface Box Power Cable/Harness Connections Check Procedure
- OHM Harness Connection Check Procedure W/ Dome Light Lens
- Fuel System - Cold Weather Engine Starting Tips
- Wheels - Chrome Wheel Handling When Mounting Tires
- Recall 07V435000: Fuel Filler Tube Replacement
- Brakes - Judder/Pedal Feel/Noise Diagnosis/Repair
- MIL ON - DTC P0138/P0139/P0140 or P0158/P0159/P0160
- Recall R0705 & R0706 - Fuel Filler Tube Replacement
- Engine Controls - MIL ON/Multiple VVT DTC's Set
- Vehicle - Flat Towing Guideline
- Restraints - SRS Service Precaution
- Electrical - Electronic Component Damage Prevention
- Wheels/Tires - Accessory Wheel Lock Installation/Removal
- A/T, CVT - Terminology Update To SAE JJ1930 & J2012
- A/C - Refrigerant Leaks From Connections
- Engine Controls - CONSULTIII(R) ECM Programming
- Body - Windshield Cracking Information
- Engine - Reman Engine Start Up Lubrication Information
- Engine - Drive Belt Noise Diagnosis
- Engine Controls - Seized O2 Sensor Removal Procedure
- Restraints - Seat Belt Retract Slowly
- M/T - Warranty Repair Fluid Requirements
- Electrical - Starting/Charging/Battery Testing
- Steering/Suspension - Wheel Bearing Collision Damage
- Computers/Controls - CONSULT(R) Reprogramming Info.
- Suspension - Strut and Shock Absorber Replacement Guidelines
- Recall 13V13600: Front Passenger Air Bag Defect
- Entertainment Systems - CD And DVD Player Concerns