Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Steering/Suspension - Pull Or Drift Diagnostic Info
- Engine Harness - MIL ON/DTC Set/No Start
- Brakes - Rear Caliper Hum or Groan Noise
- Brake Caliper (Rear) - Clunk/Rattle/Knocking Noises
- Brakes - Vibration/Judder
- Engine - Rattle/Clatter Noise On Cold Start-Up
- Suspension (Rear) - Bottoms Out on Bumps
- Body - Tire Dressing Stains Vehicle Paint
- Sunroof Glass - Operates By Itself
- Engine Mount - Buzzing Noise After Engine Shutoff
- O2 Sensor/ECM - MIL ON & Multiple DTC's Set
- ECM/TPS - Engine Surge
- O2 Sensor - MIL ON/DTC's P0138 or P0158 - P0160 Set
- Engine Controls - MIL ON/DTC P0420 Set
- Air Flow Meter - MIL ON/DTC P0100/Driveability Concerns
- Ignition Coil - MIL ON/Spark Knock/DTC P1320 Set
- Engine - ON/OFF Throttle Sensitivity At Low Speeds
- Engine - Low/No Idle After Cold Start
- EVAP Canister - Charcoal Leakage
- TCM - MIL ON/DTC P1605/Transmission Stays in 3rd Gear
- Interior - Driver's Seat Won't Move Forward/Backward
- Cruise Control - Hunting/Surging
- Parcel Shelf - Rattle/Buzz Noise
- Interior - Seat Belt Latch Plate Button Missing
- Tachometer - Needle on Wrong Side of Stop Pin
- Body/Frame - Hood Visibly Vibrates/Seems Loose
- Headlamp (Plastic) - Cloudy/Hazy Appearance
- Alarm System - Sounds After 30 Min./Trunk Lamp Inop
- Emissions System - MIL ON/DTC P1491 (EVAP) Stored
- Power Door Locks - Intermittently Lock By Themselves
- Door Locks (Power) - Inadvertently Lock
- Door Mirror - Vibrates While Driving
- Trunk Finisher - Popped Out of Place
- Door Glass (Rear) - Hiss/Whistle/Flutter Noise
- Window Glass (Front Door) - Squeak/Squeal Noise
- Cooling System - Leaks/Overheating
- Steering - Pull/Drift
- Interior - Carpet Torn on Driver's Side Front
- A/T - Abnormal Shifting
- Seat (Drivers) - Side to Side Movement on Turns
- Engine - Oil Leaks From Oil Cooler Oil Seal
- A/T - Slipping On 1-2/2-3 Upshifts
- Engine Controls - MIL ON/O2 Sensor DTC's Set
- A/C - Refrigerant Leaks From Connections
- Restraints - Seat Belt Retract Slowly
- Superceded Bulletins
- 11-074 - 08/01/11
- 04-054A - 06/01/06
- 04-054 - 06/01/04
- 08-033 - 06/01/08
- 99-048S - 07/01/08
- 08-055 - 07/01/08
- 03-074B - 06/01/08
- 00-039C - 08/01/01
- 00-039B - 06/01/01
- 99-048N - 02/01/06
- 99-048M - 01/01/06
- 99-048C - 07/28/00
- 99-048B - 07/28/00
- 99-022B - 08/05/03
- 99-020A - 03/27/02
- 99-048I - 05/20/03
- 99-048G - 05/20/03
- 99-048F - 05/20/03
- 99-048E - 05/20/03
- 02-011 - 03/11/02
- 01-087 - 12/05/01
- 01-076A - 01/09/02
- 01-076 - 01/09/02
- 01-069 - 03/07/02
- 01-051 - 08/15/01
- 01-036 - 09/17/01
- 01-016A - 07/02/01
- 01-016 - 03/20/01
- 00-056 - 11/08/00
- 00-052 - 08/30/00
- 00-039 - 12/04/00
- 00-037 - 11/30/00
- 00-006B - 10/06/03
- Lighting - Headlamp Fogging
- 03-074C - 07/21/08
- Lighting - Exterior Lamp Fogging Inspection
- Lighting - Exterior Lamps Fogging Information
- Lighting - Exterior Lamp Fogging Information
- Driver Power Seat - No Fore/Aft Operation
- Power Seat (Driver Side) - No Fore or Aft Movement
- Interior - Driver's Seat Won't Move Forward or Backward
- Entertainment System - CD/DVD Player Concerns
- Entertainment System - CD/DVD Player Concerns
- Antitheft System - Key Registration Procedure
- Restraint System - Seatbelts Slow to Retract
- Seat Belt - Slow Retraction
- 08-055A - 07/21/08
- Air Bag System - Tampering Precautions
- Air Bag - Side SRS Tampering/Modification Precautions
- Steering/Suspension - Vehicle Pull Diagnosis
- Recall - Transverse Link Replacement
- Battery/Starting/Charging System - Testing
- 99-048T - 07/22/08
- 99-048R - 02/13/08
- Battery - Testing Procedures & Equipment
- Battery - Testing Equipment/Procedures
- Battery - Testing Procedures/Replacement
- Battery - Testing/Replacement
- Battery - Testing/Equipment/Replacement Applications
- Battery - OE And Replacement Ratings
- Brakes - Judder/Noise/Pedal Feel Diagnosis/Repair
- Brakes - Judder/Vibration Diagnosis/Repair
- Brakes - Noise/Judder/Feel Diagnosis & Repair
- Brakes - Judder/Noise/Pedal Feel Diagnosis & Repair
- Brakes - ABS Self Check Noise Explanation
- A/T - Oil Cooler Cleaning Procedure
- A/T - 1st to 2nd & 2rd to 3rd Gear Slippage
- Emissions - System Readiness Test (SRT) Drive Patterns
- Emissions - EVAP System Leak DTC Diagnosis
- Emissions - EVAP Canister Vent Control Valve Replacement
- Emissions - DTC P0440/P0442/P0455/P0456/P1440/P1456
- Engine Controls - ECM Reprogramming
- ECM - MIL ON/DTC P0420 Stored
- ECM - Reprogramming Procedures
- ECM - Replacement/Reprogramming Procedures
- Engine Controls - PCM Replacement Procedures
- Engine Control Module - MIL ON, DTC P0420 Set
- Engine/Transmission - Replacement Precautions
- Steering/Suspension - Vehicle Pull/Drift Information
- Steering/Suspension - Vehicle Pulls/Drifts Left/Right
- Tires - Tire Pressure Information
- Steering/Suspension - Vehicle Pulls Or Drifts
- Vehicle - VIN Plate/Certification Label Replacement
- Steering/Suspension - Wheel Alignment Information
- Steering/Suspension - Wheel Alignment Info.
- 08-097C - 05/05/11
- Steering/Suspension - Pull Or Drift Diagnostics
- Wheels/Tires - Wheel Balancing Info.
- Steering/Suspension - Pull Or Drift Diagnostic Info.
- Vehicle - Flat Towing Guidelines/Limitations
- Vehicle - Guidelines For Flat Towing
- Vehicle - Flat Towing Recommendations
- Vehicle - Flat Towing Guidelines
- M/T - Required Fluid
- M/T - Required Oil for Warranty Repairs
- All Technical Service Bulletins
- Emissions - System Readiness Test (SRT) Drive Patterns
- Computers/Controls - CONSULT III Plus(R) Saved Data List
- Body Controls - Configurable BCM Replacement Information
- Wheels/Tires - Wheel/Tire Balancing Information
- Vehicle - Vehicle Vibration Customer Diagnostic Worksheet
- Lighting - Exterior Lamp Fogging
- Steering/Suspension - Pull Or Drift Diagnostic Info
- Steering/Suspension - Wheel Alignment Info
- Keyless Systems/TPMS - SIGNAL TECH II(R) Diag. Tool
- ABS/TCS - ABS Self-Check Noise Information
- Electrical - JIS & CCA Battery Testing Information
- Interior/Restraints - Seat Trim Material Information
- Engine Controls - ECM Programming Information
- Vehicle - Certification Label/VIN Plate Replacement
- Engine Controls - ECM Programming Interruption Recovery
- Wheels/Tires - Hunter GSP9700(R) Set Up Information
- Wheels/Tires - Tire Mounting Information
- Engine Harness - MIL ON/DTC Set/No Start
- Engine/Transmission - Precautions During R&R Procedure
- Brakes - Rear Caliper Hum or Groan Noise
- Brake Caliper (Rear) - Clunk/Rattle/Knocking Noises
- Brakes - Vibration/Judder
- Engine - Rattle/Clatter Noise On Cold Start-Up
- Suspension (Rear) - Bottoms Out on Bumps
- Wheels - Titanium Finish Wheel Cleaning Precautions
- Body - Tire Dressing Stains Vehicle Paint
- Body - Window Regulator/Motor Service Update
- Window - Window Regulator Pop/Tick Noise
- Sunroof Glass - Operates By Itself
- A/T - Mandatory Oil Cooler Cleaning
- Engine Mount - Buzzing Noise After Engine Shutoff
- O2 Sensor/ECM - MIL ON & Multiple DTC's Set
- ECM/TPS - Engine Surge
- Engine Controls - ECM Replacement Procedures
- O2 Sensor - MIL ON/DTC's P0138 or P0158 - P0160 Set
- Engine Controls - MIL ON/DTC P0420 Set
- Air Flow Meter - MIL ON/DTC P0100/Driveability Concerns
- Battery - Maintenance and Servicing
- Ignition Coil - MIL ON/Spark Knock/DTC P1320 Set
- Engine - ON/OFF Throttle Sensitivity At Low Speeds
- Engine - Low/No Idle After Cold Start
- EVAP Canister - Charcoal Leakage
- TCM - MIL ON/DTC P1605/Transmission Stays in 3rd Gear
- Interior - Driver's Seat Won't Move Forward/Backward
- Cruise Control - Hunting/Surging
- Parcel Shelf - Rattle/Buzz Noise
- Interior - Seat Belt Latch Plate Button Missing
- Brakes - On-Car Rotor Refinishing
- Tachometer - Needle on Wrong Side of Stop Pin
- Body/Frame - Hood Visibly Vibrates/Seems Loose
- Headlamp (Plastic) - Cloudy/Hazy Appearance
- Headlight Connector - Replacement
- Alarm System - Sounds After 30 Min./Trunk Lamp Inop
- Antitheft System - Description/Key Registration
- Tools - CONSULT-II Software Update
- Tools - CONSULT-II NATS Software Update
- CONSULT-II - ECM Reprogramming Software
- Tools - CONSULT-II Repair Procedures
- Essential Tool - OBD II Connector Kit
- Emissions System - MIL ON/DTC P1491 (EVAP) Stored
- Power Door Locks - Intermittently Lock By Themselves
- Door Locks (Power) - Inadvertently Lock
- Door Mirror - Vibrates While Driving
- Trunk Finisher - Popped Out of Place
- Door Glass (Rear) - Hiss/Whistle/Flutter Noise
- Window Glass (Front Door) - Squeak/Squeal Noise
- Instruments - Electrochromic Mirror Diagnostics
- Engine Coolant - Special Refilling Tool
- Cooling System - Leaks/Overheating
- CD Changer - CD Care and Usage Guidelines
- Recall 02V146000: Lower Control Arm Defect
- Recall - Transverse Link Fracture/Replacement
- Steering - Pull/Drift
- Paint - Codes & Cross References
- Paint - Removal of Environmental Particles
- Interior - Carpet Torn on Driver's Side Front
- A/T - Abnormal Shifting
- Seat (Drivers) - Side to Side Movement on Turns
- Accessories - Homelink(R) Transmitter Service
- Maintenance - Revised Procedures
- Special Tools - Fuel Pressure Gauge Kit
- EVAP Vent Control Valve - DTC'S Stored in Memory
- Engine - Oil Leaks From Oil Cooler Oil Seal
- Fuel System - Cold Weather Engine Starting Tips
- Wheels - Chrome Wheel Handling When Mounting Tires
- A/T - Slipping On 1-2/2-3 Upshifts
- Engine Controls - MIL ON/O2 Sensor DTC's Set
- Electrical - Battery Testing Procedures/Equipment
- Brakes - Judder/Pedal Feel/Noise Diagnosis/Repair
- Vehicle - Flat Towing Guideline
- Restraints - SRS Service Precaution
- Electrical - Electronic Component Damage Prevention
- Wheels/Tires - Accessory Wheel Lock Installation/Removal
- A/T, CVT - Terminology Update To SAE JJ1930 & J2012
- A/C - Refrigerant Leaks From Connections
- Engine Controls - CONSULTIII(R) ECM Programming
- Body - Windshield Cracking Information
- Engine - Reman Engine Start Up Lubrication Information
- Engine - Drive Belt Noise Diagnosis
- Engine Controls - Seized O2 Sensor Removal Procedure
- Restraints - Seat Belt Retract Slowly
- M/T - Warranty Repair Fluid Requirements
- Electrical - Starting/Charging/Battery Testing
- Steering/Suspension - Wheel Bearing Collision Damage
- Computers/Controls - CONSULT(R) Reprogramming Info.
- Suspension - Strut and Shock Absorber Replacement Guidelines
- Recall 13V13600: Front Passenger Air Bag Defect
- Entertainment Systems - CD And DVD Player Concerns