Wipers/Washers - Low or No Washer Fluid Flow
TECHNICALBulletin No.: 08-08-43-005A
Date: June 19, 2008
Subject:
Low, No Windshield Washer Flow (Replace Washer Pump Filter with Plain Grommet)
Models:
2007-2008 Chevrolet Equinox
2007-2008 Pontiac Torrent
Built Prior to October 1, 2007
Supercede:
This bulletin is being revised to emphasize not to replace the washer pump motor and to check the washer fuse. Please discard Corporate Bulletin Number 08-08-43-005 (Section 08 - Body and Accessories).
Condition
Some customers may comment on low or no windshield washer flow.
Cause
This condition may be caused by a clogged washer pump filter. Extended use with the filter clogged may have also caused the washer pump to burn out.
Correction
Technicians are to replace the pump filter with a new style plain grommet.
Important:
If further diagnosis leads to the washer pump motor being inoperative, replace the windshield washer pump motor.
1. Remove the windshield washer container. Refer to SI for Windshield Washer Solvent Container Replacement.
2. Remove the washer solvent filter grommet from the pump.
3. Replace the washer solvent pump filter grommet with a new part (see figure above).
4. Verify the washer fuse is not blown- refer to SI for the location of the fuse.
Important:
DO NOT replace the washer pump motor and kit unless further diagnosis leads you to an inoperative pump.
Parts Information
Warranty Information
For vehicles repaired under warranty, use the table.
Disclaimer