Brakes - Premature Pad Wear
89pontiac03Bulletin Number: 88-5-16
Reference Number: 835018
Publish Date: 2/89
Subject: DISC BRAKE PAD WEAR, (DIAGNOSIS DESCRIBED)
Models
Affected:
1988 LEMANS
FIGURE 1:
Some of the subject vehicles may exhibit an early wear condition of the front disc brake pad linings.
Wear occurring to or beyond the wear sensor in less than 10,000 miles may be experienced in some service conditions.
This wear condition may be aggravated by mis-adjusted rear brake shoes. To eliminate this mis-adjustment as a cause of subsequent premature wear of the front brake pad linings, the following adjustment procedure should be followed upon completion of servicing the front brakes for this condition.
1. Release parking brake lever.
2. Raise vehicle on hoist.
3. Remove access plug from rear of brake backing plate.
4. Check clearance (D) between Stop, Parking Brake Lever and Brake Shoe Web, See Figure 1, for both rear brakes "D" should not exceed 3 mm (.12 in.).
5. If "D" is greater than 3 mm then adjustment is required per step 6-1D.
6. Loosen parking brake cable at equalizer until both lever stops are just touching the brake shoe web.
7. Apply foot brake several times until clicking of adjustment actuator can no longer be heard (adjuster makes multiple clicks for each application).
- Brake pedal must be operated at least 10 times.
- When clicking stops, recheck clearance "D" for proper adjustment.
8. Reinsert access plug in backing plate.
9. Check that parking brake lever when fully applied has been raised 5 to 8 notches (clicks) from the fully off (down) position.
10. Lower vehicle.
Labor Operation Number: T1422
Labor Time: .4 Hours