Technician Safety Information

CAUTION: Before removing or installing any electrical component, disconnect the negative battery cable to prevent possible short circuits which could lead to personal injury and/or property damage.

NOTICE: Some of the solid state components found in the instrument panel are Electrostatic Discharge Sensitive. Proper handling guidelines should be followed when servicing solid state components.


CAUTION: This vehicle is equipped with Supplemental Inflatable Restraint (SIR). Refer to Service Precautions / Air Bags (Supplemental Restraint Systems) before performing service on or around SIR components or wiring. Failure to follow CAUTIONS could result in possible air bag deployment, personal injury, or otherwise unneeded SIR system repairs.


The DERM in 1993 and previous Driver only SIR systems can maintain sufficient voltage to cause a deployment for up to 10 minutes after the ignition switch is turned "OFF", the battery is disconnected or the fuse powering the DERM is removed.

The DERM in 1994 and later Driver Only and the DERM in all Driver/Passenger SIR systems can maintain sufficient voltage to cause a deployment for up to 2 minutes after the ignition switch is turned OFF", the battery is disconnected or the fuse powering the DERM is removed.

Many of the service procedures require removal of the AIR BAG fuse and the disconnection of the inflator module from the deployment loop to avoid accidental deployment. If the inflator module is disconnected from the deployment loop as noted in the "Disabling the SIR System" procedure that follows, service can begin immediately without waiting for the 10 minute or 2 minute time period to expire.