Repair and Diagnosis
- A L L Diagnostic Trouble Codes ( DTC )
- Relays and Modules
- Relays and Modules - Accessories and Optional Equipment
- Relays and Modules - Body and Frame
- Relays and Modules - Brakes and Traction Control
- Relays and Modules - Cruise Control
- Relays and Modules - HVAC
- Relays and Modules - Instrument Panel
- Relays and Modules - Lighting and Horns
- Relays and Modules - Power and Ground Distribution
- Relays and Modules - Powertrain Management
- Relays and Modules - Restraints and Safety Systems
- Relays and Modules - Steering and Suspension
- Sensors and Switches
- Sensors and Switches - Accessories and Optional Equipment
- Sensors and Switches - Body and Frame
- Sensors and Switches - Brakes and Traction Control
- Sensors and Switches - Cooling System
- Sensors and Switches - Cruise Control
- Sensors and Switches - Engine
- Sensors and Switches - HVAC
- Sensors and Switches - Instrument Panel
- Sensors and Switches - Lighting and Horns
- Sensors and Switches - Powertrain Management
- Sensors and Switches - Computers and Control Systems
- Camshaft Position Sensor
- Clutch Switch
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Engine Temperature Sensor
- Fuel Level Sensor
- Fuel Pressure Sensor
- Fuel Tank Pressure Sensor
- Fuel Tank Pressure Sensor (CNG)
- Fuel Tank Temperature Sensor (CNG)
- Air Temperature Sensor ( Ambient / Intake )
- Knock Sensor
- Manifold Pressure/Vacuum Sensor
- Oil Pressure Sensor
- Oxygen Sensor
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
- Sensors and Switches - Fuel Delivery and Air Induction
- Sensors and Switches - Ignition System
- Sensors and Switches - Computers and Control Systems
- Sensors and Switches - Restraints and Safety Systems
- Sensors and Switches - Starting and Charging
- Sensors and Switches - Steering and Suspension
- Sensors and Switches - Transmission and Drivetrain
- Sensors and Switches - Windows and Glass
- Sensors and Switches - Wiper and Washer Systems
- Maintenance
- Alignment
- Tune-up and Engine Performance Checks
- Timing Component Alignment Marks
- Drive Belt
- Filters
- Hoses
- Fluids
- Brake Bleeding
- Air Bag(s) Arming and Disarming
- Fuses and Circuit Breakers
- Service Reminder Indicators
- Wheels and Tires
- Jump Starting
- Towing Information
- Vehicle Lifting
- Service Intervals
- Using Maintenance Schedules
- Normal Service Defined
- Severe Service Defined
- Maintenance Indicator Reset
- Routine Service
- Periodic Maintenance
- Normal Service
- 7500 MI or 12000 KM
- 15000 MI or 24000 KM
- 22500 MI or 36000 KM
- 30000 MI or 48000 KM
- 37500 MI or 60000 KM
- 45000 MI or 72000 KM
- 52500 MI or 84000 KM
- 60000 MI or 96000 KM
- 67500 MI or 108000 KM
- 75000 MI or 120000 KM
- 82500 MI or 132000 KM
- 90000 MI or 144000 KM
- 97500 MI or 156000 KM
- 100000 MI or 160000 KM
- 150000 MI or 240000 KM
- Severe Service
- 3000 MI or 4800 KM
- 6000 MI or 9600 KM
- 9000 MI or 14400 KM
- 12000 MI or 19200 KM
- 15000 MI or 24000 KM
- 18000 MI or 28800 KM
- 21000 MI or 33600 KM
- 24000 MI or 38400 KM
- 27000 MI or 43200 KM
- 30000 MI or 48000 KM
- 33000 MI or 52800 KM
- 36000 MI or 57600 KM
- 39000 MI or 62400 KM
- 42000 MI or 67200 KM
- 45000 MI or 72000 KM
- 48000 MI or 76800 KM
- 50000 MI or 80000 KM
- 51000 MI or 81600 KM
- 54000 MI or 86400 KM
- 57000 MI or 91200 KM
- 60000 MI or 96000 KM
- 63000 MI or 100800 KM
- 66000 MI or 105600 KM
- 69000 MI or 110400 KM
- 72000 MI or 115200 KM
- 75000 MI or 120000 KM
- 78000 MI or 124800 KM
- 81000 MI or 129600 KM
- 84000 MI or 134400 KM
- 87000 MI or 139200 KM
- 90000 MI or 144000 KM
- 93000 MI or 148800 KM
- 96000 MI or 153600 KM
- 99000 MI or 158400 KM
- 100000 MI or 160000 KM
- 150000 MI or 240000 KM
Specifications- Capacity Specifications
- Fluid Type Specifications
- A Recommended Fluids and Lubricants
- Automatic/Manual Transmission/Transaxle Shift Linkage
- C/V or U-Joints, Propshaft or Yoke Splines and Clutch Fork
- Chassis Lubrication
- Hinges and Locks
- Linkage, Latches, Pivots and Spring Anchors
- Parking Brake Cable Guides
- Weatherstrip Conditioning
- Wheel Bearings
- Windshield Washer Solvent
Technical Service Bulletins
- Engine, Cooling and Exhaust
- Engine
- Compression Check
- Camshaft, Lifters and Push Rods
- Cylinder Block Assembly
- Cylinder Head Assembly
- Drive Belts, Mounts, Brackets and Accessories
- Engine Lubrication
- Intake Manifold
- Seals and Gaskets
- Sensors and Switches - Engine
- Timing Components
- Tune-up and Engine Performance Checks
- Water Pump
- Application and ID
Description and Operation
Testing and Inspection- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- Component Tests and General Diagnostics
- Base Engine Misfire With Abnormal Internal Lower Engine Noises
- Base Engine Misfire With Abnormal Valve Train Noise
- Base Engine Misfire With Coolant Consumption
- Base Engine Misfire With Excessive Oil Consumption
- Base Engine Misfire Without Internal Engine Noises
- Engine Compression Test
- Oil Consumption Diagnosis
- Oil Leak Diagnosis
Service and Repair- Removal and Replacement
- Overhaul
- Overhaul Procedure Steps
- Repair Instructions
- 1. Draining Fluids and Oil Filter Removal
- 2. Engine Flywheel Removal
- 3. Oil Level Indicator and Tube Removal
- 4. Exhaust Manifold Removal
- 5. Intake Manifold Removal
- 6. Crankshaft Balancer Removal
- 7. Engine Front Cover Removal
- 8. Timing Chain, Sprocket, and Tensioner Removal
- 9. Water Pump Removal
- 10. Timing Chain Housing Removal
- 11. Intake Camshaft, Housing and Lifter Removal
- 12. Exhaust Camshaft, Housing and Lifter Removal
- 13. Cylinder Head Removal
- 14. Oil Filter Adapter Removal
- 15. Oil Pan Removal
- 16. Oil Pump Removal
- 17. Balance Shaft Housing Removal
- 18. Piston, Connecting Rod, and Bearing Removal
- 19. Crankshaft Rear Oil Seal and Housing Removal
- 20. Crankshaft and Bearing Removal
- 21. Engine Block Plug Removal
- 22. Engine Block Clean and Inspect
- 23. Crankshaft Balancer Clean and Inspect
- 24. Engine Front Cover Clean and Inspect
- 25. Engine Flywheel Clean and Inspect
- 26. Cylinder Boring and Honing
- 27. Crankshaft and Bearing Clean and Inspect
- 28. Piston and Connecting Rod Disassemble
- 29. Piston, Connecting Rod, and Bearing Clean and Inspect
- 30. Piston and Connecting Rod Assemble
- 31. Camshaft and Housing Clean and Inspect
- 32. Timing Chain and Sprocket Clean and Inspect
- 33. Cylinder Head Disassemble
- 34. Cylinder Head Clean and Inspect
- 35. Valve Guide Reaming, and Valve and Seat Grinding
- 36. Cylinder Head Assemble
- 37. Oil Pump Disassemble
- 38. Oil Pump Clean and Inspect
- 39. Oil Pump Assemble
- 40. Intake Manifold Clean and Inspect
- 41. Exhaust Manifold Clean and Inspect
- 42. Oil Pan Clean and Inspect
- 43. Balance Shaft Clean and Inspect
- 44. Thread Repair
- 45. Service Prior to Assembly
- 46. Engine Block Plug Installation
- 47. Crankshaft and Bearing Installation
- 48. Crankshaft Rear Oil Seal and Housing Installation
- 49. Piston, Connecting Rod, and Bearing Installation
- 50. Balance Shaft Housing Installation
- 51. Oil Pump Installation
- 52. Balance Shaft to Engine Timing
- 53. Cylinder Head Installation
- 54. Intake Camshaft, Housing and Lifter Installation
- 55. Exhaust Camshaft, Housing and Lifter Installation
- 56. Timing Chain Housing Installation
- 57. Water Pump Installation
- 58. Timing Chain, Sprocket, and Tensioner Installation
- 59. Crankshaft Front Oil Seal Installation
- 60. Engine Front Cover Installation
- 61. Oil Pan Installation
- 62. Oil Filter Adapter Installation
- 63. Intake Manifold Installation
- 64. Crankshaft Balancer Installation
- 65. Exhaust Manifold Installation
- 66. Oil Level Indicator and Tube Installation
- 67. Engine Flywheel Installation
Diagrams- Specifications
- Technical Service Bulletins
Tools and Equipment
- Cooling System
- Cooling System Air Bleeder Pipe / Hose
- Coolant
- Coolant Level Sensor
- Coolant Line/Hose
- Coolant Reservoir
- Radiator Cooling Fan
- Engine - Coolant Temperature Sensor/Switch
- Heater Core
- Heater Hose
- Lamps and Indicators - Cooling System
- Radiator
- Radiator Hose
- Sensors and Switches - Cooling System
- Temperature Warning Lamp/Indicator
- Thermostat
- Thermostat Housing
- Water Pump
- Description and Operation
- Testing and Inspection
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Exhaust System
- Technical Service Bulletins
- Engine
- Powertrain Management
- Relays and Modules - Powertrain Management
- Sensors and Switches - Powertrain Management
- Sensors and Switches - Computers and Control Systems
- Camshaft Position Sensor
- Clutch Switch
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Engine Temperature Sensor
- Fuel Level Sensor
- Fuel Pressure Sensor
- Fuel Tank Pressure Sensor
- Fuel Tank Pressure Sensor (CNG)
- Fuel Tank Temperature Sensor (CNG)
- Air Temperature Sensor ( Ambient / Intake )
- Knock Sensor
- Manifold Pressure/Vacuum Sensor
- Oil Pressure Sensor
- Oxygen Sensor
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
- Sensors and Switches - Fuel Delivery and Air Induction
- Sensors and Switches - Ignition System
- Sensors and Switches - Computers and Control Systems
- Tune-up and Engine Performance Checks
- Computers and Control Systems
- Air Temperature Sensor ( Ambient / Intake )
- Alternative Fuel Control Module
- Body Control Module
- Camshaft Position Sensor
- Clutch Switch
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Data Link Connector
- Engine Control Module
- Engine Temperature Sensor
- Fuel Flow Meter
- Fuel Level Sensor
- Fuel Pressure Sensor
- Fuel Tank Pressure Sensor
- Fuel Tank Pressure Sensor (CNG)
- Fuel Tank Temperature Sensor (CNG)
- Idle Speed/Throttle Actuator - Electronic
- Information Bus
- Knock Sensor
- Malfunction Indicator Lamp
- Manifold Pressure/Vacuum Sensor
- Oil Pressure Sensor
- Oxygen Sensor
- Relays and Modules - Computers and Control Systems
- Sensors and Switches - Computers and Control Systems
- Camshaft Position Sensor
- Clutch Switch
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Engine Temperature Sensor
- Fuel Level Sensor
- Fuel Pressure Sensor
- Fuel Tank Pressure Sensor
- Fuel Tank Pressure Sensor (CNG)
- Fuel Tank Temperature Sensor (CNG)
- Air Temperature Sensor ( Ambient / Intake )
- Knock Sensor
- Manifold Pressure/Vacuum Sensor
- Oil Pressure Sensor
- Oxygen Sensor
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
Service Precautions- Description and Operation
- Electronic Ignition (EI) System
- Emission Control Systems
- Fuel System Description
- Air Intake System Description
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer
- Fuel Filter
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly
- Fuel Metering Modes of Operation
- Short Term Fuel Trim
- Long Term Fuel Trim
- Powertrain Control Module (PCM)
- California Air Resources Board OBD II Comprehensive Component Monitoring List of Components Intended to Illuminate MIL
- Catalyst Monitor Diagnostic Operation
- Catalyst Monitor Heated Oxygen Sensors (HO2S)
- Comprehensive Component Monitor Diagnostic
- Connectors and Terminals
- Control Module Service Precautions
- EEPROM
- Fuel Control Oxygen Sensors (O2S)
- Fuel Tank Pressure Sensor
- Fuel Trim System Monitor Diagnostic Operation
- HO2S Heater
- Input Components
- Misfire Counters
- Misfire Monitor Diagnostic Operation
- Output Components
- Oxygen Sensor Diagnosis
- PCM Function
- Powertrain Control Module (PCM)
- Primary System Based Diagnostics
- SYS Status & Drive Cycle For Satisfying the Federal I/M 240 Regulations
- Three-Way Catalyst Oxygen Storage Capacity
- Typical OBD II Drive Cycle
- Use of Circuit Testing Tools
- Service Programming System (SPS)
- Additional Information
- Knock Sensor (Ks) System
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- - Standard Model (Non-Alternative Fuels)
- Scan Tool Diagnostics
- Scan Tool Data List
- Scan Tool Data Definitions
- General Information
- A/C High Side Pressure
- A/C Relay Command
- A/C Request Signal
- Air Flow Calculated
- Air Fuel Ratio
- BARO
- CKP Active Counter (7X Reference)
- CMP Active Counter
- CMP Resync Counter
- Cruise Control Active
- Cruise Release Clutch/TCC Pedal Switch
- Current Gear
- Cycles of Misfire Data
- Desired Idle Speed
- ECT
- Engine LOAD
- Engine Oil Life Remaining
- Engine Oil Pressure Switch
- Engine Run Time
- Engine Speed
- EVAP Purge Solenoid Command
- EVAP Test Results
- EVAP Test Abort Reason
- EVAP Test Status
- EVAP Vent Solenoid Command
- FC Relay 1 Command
- Fuel Level Sensor
- Fuel Pump Relay Command
- Fuel Tank Pressure Sensor
- Fuel Trim Cell
- Generator L Terminal Signal
- Generator F Terminal Signal
- HO2S 2
- IAC Position
- IAT Sensor
- Ignition 1 Signal
- Injector PWM
- Injector 1-4 Command
- Knock Retard
- Long Term FT
- Loop Status
- MAP Sensor
- MIL Command
- Misfire Current
- Misfire History
- Med. Resolution Resync Counter
- Number of DTCs
- O2S 1
- Power Enrichment
- Short Term FT
- Spark
- Start Up ECT
- TCC Enable Solenoid Command
- TP Sensor
- TR Switch
- TWC Temperature Calculated
- Vehicle Speed Sensor
- VTD Fuel Disable
- VID Auto. Learn Timer
- Export Application Components Table
- Inspection/Maintenance (I/M) System Set Procedures
- Diagnostic Starting Point
- Diagnostic System Check
- Scan Tool Diagnostics
- Basic Knowledge and Tool Requirements
- Diagnostic Strategies
- Visual/Physical Check
- - Standard Model (Non-Alternative Fuels)
- Symptom Related Diagnostic Procedures
- Scan Tool Does Not Communicate
- Scan Tool Does Not Power Up
- With Standard Model (Non-Alternative Fuels)
- Backfire
- Cuts Out, Misses
- Detonation/Spark Knock
- Dieseling, Run-on
- Hard Start
- Hesitation, Sag, Stumble
- Important Preliminary Checks
- Intermittent Conditions
- Lack of Power, Sluggishness, or Sponginess
- Malfunction Indicator Lamp (MIL) Always On
- Malfunction Indicator Lamp (MIL) Inoperative
- Poor Fuel Economy
- Rough, Unstable, Or Incorrect Idle and Stalling
- Surges/Chuggles
- Component Tests and General Diagnostics
- Alcohol Contaminants-in-Fuel Diagnosis (Without Special Tool)
- Alcohol/Contaminants-in-Fuel Diagnosis (With Special Tool)
- Electronic Ignition (EI) System Diagnosis
- Fuel Injector Balance Test With Special Tool
- Fuel Injector Balance Test With Tech 2
- Fuel Injector Circuit Diagnosis
- Fuel Injector Coil Test
- Fuel Pump Electrical Circuit Diagnosis
- Fuel System Diagnosis
- Fuel Tank Leak Test
- Idle Air Control (IAC) System Diagnosis
- Scan Tool Testing and Procedures
- Mode 6 Data
- Monitors, Trips, Drive Cycles and Readiness Codes
- Initial Inspection and Diagnostic Overview
Locations- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Emission Control Systems
- Catalytic Converter
- Evaporative Emissions System
- Positive Crankcase Ventilation
- Description and Operation
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Vacuum and Vapor Hose Diagrams
- Technical Service Bulletins
- Fuel Delivery and Air Induction
- Fuel Pressure
- Fuel Pressure Release
- Idle Speed
- Alternative Fuel Control Module
- Accelerator Pedal
- Air Cleaner Housing
- Fuel
- Fuel Filler Cap
- Fuel Filter
- Fuel Injector
- Fuel Line Coupler
- Fuel Pressure Regulator
- Fuel Pump
- Fuel Pressure
- Fuel Pump Relay
- Service Precautions
- Description and Operation
- Testing and Inspection
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Specifications
- Tools and Equipment
- Fuel Pump Pickup Filter
- Fuel Rail
- Fuel Return Line
- Fuel Supply Line
- Fuel Tank
- Fuel Tank Unit
- Fuel Temperature Sensor
- Idle Speed/Throttle Actuator - Electronic
- Relays and Modules - Fuel Delivery and Air Induction
- Resonator
- Sensors and Switches - Fuel Delivery and Air Induction
- Throttle Body
- Throttle Cable/Linkage
- Throttle Position Sensor
- Turbocharger
- Service Precautions
- Description and Operation
- Air Intake System Description
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer
- Fuel Filter
- Fuel Feed and Return Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pressure Regulator Assembly
- Fuel Metering Modes of Operation
- Short Term Fuel Trim
- Long Term Fuel Trim
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Component Tests and General Diagnostics
- Alcohol/Contaminants-In-Fuel Diagnosis (With Special Tool)
- Alcohol/Contaminants-In-Fuel Diagnosis (Without Special Tool)
- Fuel Injector Balance Test - With Special Tool
- Fuel Injector Balance Test - With Tech 2
- Fuel Injector Circuit Diagnosis
- Fuel Injector Coil Test - Non-Alternative Fuels
- Fuel Pump Electrical Circuit Diagnosis - Non-Alternative Fuels
- Fuel System Diagnosis
- Fuel Tank Leak Test
- Locations
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Ignition System
- Firing Order
- Ignition Timing
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Ignition Coil
- Ignition Control Module
- Ignition Relay
- Knock Sensor
- Relays and Modules - Ignition System
- Sensors and Switches - Ignition System
- Spark Plug
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Transmission Control Systems
- Actuators and Solenoids - Transmission and Drivetrain
- Lamps and Indicators - Transmission and Drivetrain
- Sensors and Switches - Transmission and Drivetrain
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Technical Service Bulletins
- PROM - Programmable Read Only Memory
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Emission Controls
- Engine Controls
- Class 2 Serial Data, MIL, DLC, UART
- Cruise Control and Vehicle Speed Signal
- Cruise Control Module (CCM) And Vehicle Speed Sensor VSS
- Engine Data Sensors
- Generator, IAC, PNP and EOP
- PCM References - Controlled/Monitored Subsystem
- Power, Ground, CMP, CKP, KS, and ICM
- Power, Ground, HO2S 1 And HO2S 2
- Standard Models (Non-Alternative Fuels)
- Fuel Controls
- Transmission Controls
- Technical Service Bulletins
- Transmission and Drivetrain
- Actuators and Solenoids - Transmission and Drivetrain
- Automatic Transmission/Transaxle
- Actuators and Solenoids - A/T
- Band Apply Servo
- Brake Switch - TCC
- Case
- Channel Plate
- Clutch
- Fluid - A/T
- Fluid Filter - A/T
- Fluid Line/Hose
- Fluid Pan
- Fluid Pressure Sensor/Switch
- Fluid Pump
- Fluid Transfer Tube
- Governor
- Lamps and Indicators - A/T
- Output Shaft
- Output Shaft Bearing/Bushing
- Parking Lock Cable
- Parking Pawl
- Pressure Regulating Solenoid
- Seals and Gaskets
- Sensors and Switches - A/T
- Shift Indicator - A/T
- Shift Interlock
- Shift Interlock Solenoid
- Description and Operation
- Locations
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Shift Solenoid
- Shifter A/T
- Sun Gear
- Throttle Valve Cable/Linkage
- Torque Converter
- Torque Converter Check Valve
- Torque Converter Clutch Solenoid
- Torque Converter Cover
- Transmission Cooler
- Transmission Mount
- Transmission Position Sensor/Switch
- Transmission Speed Sensor
- Transmission Temperature Sensor/Switch
- Valve Body
- Wiring Harness
- Application and ID
- Description and Operation
- 3T40 Automatic Transaxle
- 4T40-E/4T45-E Automatic Transaxle
- Automatic Transmission Electrical Connector Description
- Definitions and Abbreviations
- Electronic Component Description
- Fluid Power Flow Circuit Description
- Drive Range, Manual 1st (from Drive, Manual 2nd)
- Drive Range, Manual 2ND (From Drive, Manual 3RD)
- Drive Range, Manual 3RD (From Overdrive Range)
- Overdrive Range, First Gear
- Overdrive Range, Fourth Gear -TCC Applied
- Overdrive Range, Second Gear
- Overdrive Range, Third Gear -TCC Not Applied
- Overdrive Range, 4-3 Downshift - TCC Not Applied
- Park or Neutral - Engine Running (Neutral)
- Park or Neutral - Engine Running (Park)
- Reverse
- Transmission Component and System Description
- Transmission General Description
- Transmission General Information
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- 3T40 Automatic Transaxle
- - Symptoms - Automatic Transmission
- - Symptoms - Automatic Transmission Shift Lock Control
- Abnormal Noise In Park or Neutral Range
- Binds In Third Gear
- Buzz Noise or High Frequency Rattle Sound
- Chatters/Slips In First Gear
- Delay In Drive and Reverse
- Engine Coolant In Transmission
- Engine Stalls During Reverse or Drive Engagement
- Final Drive Noise or Hum Under Light Throttle
- Fluid Foaming
- High or Low Line Pressure
- Metallic Rattle Noise In Second or Third Gear
- No Drive In All Ranges
- No Drive In Drive or Intermediate Range
- No Drive In Drive Range
- No Drive In Forward Ranges
- No Full Throttle Downshift
- No Gear Selection
- No Intermediate Range
- No or Delayed Upshift or Full Throttle Upshift
- No Overrun Braking In Low
- No 2-3 Shift or 2-3 Shift Delay
- Noise and Vibration Analysis
- Noise In All Ranges
- Noise In First or Reverse
- Noise In Second
- Shift Indicator Indicates Wrong Gear Selection
- Shift Lever Can Be Moved Without Brake Pedal Depressed
- Shift Lever Does Not Move With Brake Pedal Depressed
- Shifts 1-3, Misses Second Gear
- Shirts 3-1 at High Speeds For Passing Gear
- Slipping or Harsh 1-2 Shift
- Slips In Reverse or No Reverse
- Whine Noise Varying With RPM or Fluid Pressure
- 2-3 Shift Rough or Delay
- 2-3 Shift Soft, Slips, or Early
- 2ND Speed Start
- 4T40-E/4T45-E Automatic Transaxle
- - Symptoms - Automatic Transmission
- - Symptoms - Automatic Transmission Shift Lock Control
- Automatic Transmission Fluid Leaks
- Buzz or High Frequency Rattle
- Drives In Neutral
- Engine Coolant In Transmission
- Engine Stall
- Final Drive Hum
- First And Fourth Gears Only
- First And Second Gears Only
- Fluid Foaming
- Forward Ranges Noise
- Harsh Shifts
- High or Low Line Pressure
- High Pitch Whine Noise
- Inaccurate/Inconsistent Shift Points
- Loss Of Drive
- Loss Of Power
- No Engine Braking Manual
- No Engine Braking; All Manual Ranges
- No Engine Braking; Manual First - First Gear
- No First Gear, Slips In First Gear
- No Fourth Gear, or Slips In Fourth Gear
- No Gear Selection
- No Park
- No Reverse Or Slips In Reverse
- No Second Gear, Slips In Second Gear
- No Third Gear, Slips In Third Gear
- No Torque Converter Clutch (TCC) Release
- Noise and Vibration Analysis
- Popping Noise
- Random Ranges Noise
- Ratcheting Noise
- RPM Sensitive Whine
- Shift Indicator Indicates Wrong Gear Selection
- Shift Lever Can Be Moved Without Brake Pedal Depressed
- Shift Lever Does Not Move With Brake Pedal Depressed
- Third and Fourth Gears Only
- Torque Converter Clutch (TCC) Apply With Cold Engine
- Vibration
- Whine or Growl
- 2nd and 3rd Gears Only
- 2nd Gear Only
- 3T40 Automatic Transaxle
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Locations
- 3T40 Automatic Transaxle
- Auxiliary Valve Body Assembly
- Bushings, Bearings and Thrust Washers
- Case and Associated Parts
- Case Cover Assembly
- Control Valve Body and Fluid Pump Assembly
- Direct Clutch Assembly
- Driven Sprocket Support Assembly
- Final Drive and Differential Carrier Assembly
- Forward Clutch Assembly
- Input Components
- Low and Reverse Clutch Assembly
- Parking Lock Assembly
- Seals
- Transmission Major Components
- 4T40-E/4T45-E Automatic Transaxle
- Automatic Transmission Electronic Component Views
- Bushings, Bearings and Washers
- Case and Associated Parts
- Control Valve Body
- Direct and Coast Clutch Assemblies
- Driven Sprocket Support Assembly and 2nd Clutch
- Final Drive and Differential Assembly
- Forward Clutch Assembly
- Forward Clutch Support Assembly
- Input Carrier Assembly
- Input Internal Gear and Forward Clutch Hub
- Manual Shaft Parking Pawl and Actuator Assembly
- Oil Pump Assembly
- Reaction Carrier Assembly
- Reverse Input Clutch Assembly
- Seals
- Transmission Major Components
- 3T40 Automatic Transaxle
- Service and Repair
- Removal and Replacement
- Overhaul
- 3T40-E Automatic Transaxle
- Overhaul Procedure Steps
- Repair Instructions
- 1. Torque Converter Disassemble
- 2. Transmission Support Fixture Assemble
- 3. Vehicle Speed Sensor and Governor Disassemble
- 4. Oil Pan and Filter Disassemble
- 5. Oil Filter Inspection
- 6. Intermediate Band Servo Disassemble
- 7. Low/Reverse Pipe, Weir and Retainers Disassemble
- 8. Output Shaft Disassemble
- 9. Case Side Cover and Gaskets Disassemble
- 10. Throttle Valve Lever and Bracket Disassemble
- 11. TCC Solenoid and Wiring Harness Disassemble
- 12. Control Valves and Oil Pump Disassemble
- 13. Spacer Plate and Oil Pump Drive Shaft Disassemble
- 14. Input Shaft to Case Cover End Play Check #1
- 15. Case Cover and Gaskets Disassemble
- 16. Drive Link Stretch Check #1
- 17. Drive and Driven Sprocket Components Disassemble
- 18. Park System Components Disassemble
- 19. Driven Sprocket Support Disassemble
- 20. Intermediate Band Disassemble
- 21. Direct and Forward Clutch Components Disassemble
- 22. Input Gear, Carrier, Sun Gear and Drum Disassemble
- 23. Reaction Sun Gear to Input Drum End Play Check #1
- 24. Low Roller Clutch Race End Play Check
- 25. Reaction Sun Gear Disassemble
- 26. Low and Reverse Clutch Housing Disassemble
- 27. Low Roller Clutch and Reaction Gearset Disassemble
- 28. Final Drive End Play Check #1
- 29. Differential Carrier Components Disassemble
- 30. Case Seals Disassemble
- 31. Case Assembly Inspection
- 32. Case Components Disassemble
- 33. Case Components Assemble
- 34. Right Drive Shaft Oil Seal Disassemble
- 35. Differential to Case Bushing Disassemble
- 36. Differential to Case Bushing Assemble
- 37. Right Drive Shaft Oil Seal Assemble
- 38. Torque Converter Oil Seal Disassemble
- 39. Drive Sprocket Support Disassemble
- 40. Drive Sprocket Support Assemble
- 41. Torque Converter Oil Seal Assemble
- 42. Third Oil and Case Cup Plugs Disassemble
- 43. Third Oil and Case Cup Plugs Assemble
- 44. Park Lock Pawl Disassemble
- 45. Park Lock Pawl Assemble
- 46. Manual Shaft and Filter Seals Assemble
- 47. Differential Carrier Complete Disassemble
- 48. Differential Carrier Inspection
- 49. Differential Carrier Disassemble
- 50. Differential Carrier Assemble
- 51. Governor Drive Gear Disassemble
- 52. Governor Drive Gear Assemble
- 53. Differential Carrier Components Assemble
- 54. Final Drive End Play Check #2
- 55. Low Roller Clutch and Reaction Carrier Disassemble
- 56. Low Roller Clutch and Reaction Carrier Inspection
- 57. Reaction Carrier Pinion End Play Check
- 58. Low Roller Clutch and Reaction Carrier Assemble
- 59. Low and Reverse Clutch Assemble
- 60. Low and Reverse Clutch Piston Disassemble
- 61. Low and Reverse Clutch Piston Assemble
- 62. Low, Reverse Clutch Piston to Case Seal Assemble
- 63. Low and Reverse Clutch Functional Air Check
- 64. Reaction Sun Gear Assemble
- 65. Reaction Sun Gear to Input Drum End Play Check #2
- 66. Input Internal Drum Assemble
- 67. Low Roller Clutch React End Play Check
- 68. Input Internal Gear, Carrier, Sun Gear Assemble
- 69. Forward Clutch Disassemble
- 70. Forward Clutch Assemble
- 71. Direct Clutch Disassemble
- 72. Direct Clutch Inspection
- 73. Direct Clutch Housing Retainer/Ball Disassemble
- 74. Direct Clutch Housing Retainer/Ball Assemble
- 75. Direct Clutch Assemble
- 76. Direct and Forward Clutch Housings Assemble
- 77. Direct and Forward Clutch Assemble
- 78. Intermediate Band Assemble
- 79. Driven Sprocket Support Components Disassemble
- 80. Driven Sprocket Support Components Inspection
- 81. Driven Sprocket Bearing Disassemble
- 82. Driven Sprocket Bearing Assemble
- 83. Driven Sprocket Support Components Assemble
- 84. Park System Components Assemble
- 85. Drive Sprocket and Turbine Shaft Disassemble
- 86. Drive Sprocket and Turbine Shaft Assemble
- 87. Drive and Driven Sprocket Components Assemble
- 88. Drive Link Stretch Check #2
- 89. Case Cover Components Disassemble
- 90. Case Cover Components Inspection
- 91. Vent and Line Pressure Plug Disassemble
- 92. Vent and Line Pressure Plug Assemble
- 93. Cooler Fitting Connectors Disassemble
- 94. Cooler Fitting Connectors Assemble
- 95. Manual Detent Spring and Roller Disassemble
- 96. Manual Detent Spring and Roller Assemble
- 97. Electrical Connector and Manual Valve Assemble
- 98. Thermo Element Adjustment
- 99. 1-2 Accumulator Assemble
- 100. Case Cover and Gaskets Assemble
- 101. Input Shaft to Case Cover End Play Check #2
- 102. Oil Pump Drive Shaft Assemble
- 103. Auxiliary Valve Body and Oil Pump Disassemble
- 104. Valve Body and Oil Pump Clean
- 105. Auxiliary Valve Body Inspection
- 106. Auxiliary Valve Body Disassemble
- 107. Auxiliary Valve Body Assemble
- 108. Control Valve Body and Oil Pump Inspection
- 109. Control Valve Body Disassemble
- 110. Oil Pump Shaft Bearing Disassemble
- 111. Oil Pump Shaft Bearing Assemble
- 112. Control Valve Body Assemble
- 113. Oil Pump Rotor Thickness Check
- 114. Auxiliary Valve Body and Oil Pump Assemble
- 115. Checkballs, Spacer Plate and Gaskets Assemble
- 116. Valve Body and Oil Pump Assemble
- 117. TCC Solenoid and Wiring Harness Assemble
- 118. Throttle Valve Lever and Bracket Assemble
- 119. Control Valve Body Cover and Gaskets Assemble
- 120. Output Shaft Assemble
- 121. Left Axle Seal Assemble
- 122. Low/Reverse Pipe, Weir and Retainers Assemble
- 123. Intermediate Servo Apply Pin Length Check
- 124. Intermediate Servo Assemble
- 125. Oil Pan and Filter Assemble
- 126. Governor Assemble Disassemble
- 127. Vehicle Speed Sensor and Governor Assemble
- 128. Transmission Holding Fixture Disassemble
- 129. Torque Converter Inspection
- 130. Torque Converter Assemble
- 4T40-E/4T45-E Automatic Transaxle
- Overhaul Procedure Steps
- Repair Instructions
- 1. Torque Converter Removal
- 2. Transmission Holding Fixture Assemble
- 3. Stub Shaft Removal
- 4. Automatic Transmission Output Speed Sensor Removal
- 5. Oil Pan and Gasket Removal
- 6. Oil Filter/Seal, Oil Level Control Valve Removal
- 7. Oil Feed Pipes Removal
- 8. Intermediate/4TH Servo Removal
- 9. Low and Reverse Servo Removal
- 10. Case Side Cover Removal
- 11. Output Shaft Sleeve Removal
- 12. Oil Pump and Oil Pump Shaft Removal
- 13. Wire Harness Disconnect
- 14. TFP Switch Removal
- 15. Control Valve Body Assembly and Gasket Removal
- 16. Spacer Plate and Gasket Removal
- 17. Checkball Removal
- 18. Manual Valve Clip Removal
- 19. Channel Plate and Gasket Removal
- 20. Accumulator Spring Removal
- 21. Drive, Driven Sprockets, Drive Link Removal
- 22. Input Speed Sensor Removal
- 23. Wiring Harness Removal
- 24. Driven Sprocket Support Assembly Removal
- 25. 2ND Clutch Plates Removal
- 26. Reverse Input Clutch Housing Removal
- 27. Intermediate 4TH Band Removal
- 28. Direct/Coast Clutch and Reaction Gear Set Removal
- 29. Input Carrier and Reaction Gear Assembly Removal
- 30. Input Internal Gear, Forward Clutch Hub Removal
- 31. Forward Clutch and Low/Reverse Band Removal
- 32. Forward Clutch Support, Low Roller Clutch Removal
- 33. Output Shaft and Final Drive Assembly Removal
- 34. Final Drive Internal Gear Removal
- 35. Manual Shaft, Detent Lever, Park Lock Removal
- 36. Transmission Cooler Line Seals Removal
- 37. Torque Converter Seal Removal
- 38. Drive Sprocket Support Removal
- 39. Right Hand Axle Seal Removal
- 40. Case Inspection
- 41. Actuator Guide Replacement
- 42. Drive Sprocket Support Installation
- 43. Torque Converter Seal Installation
- 44. Transmission Cooler Line Seals Installation
- 45. Manual Shaft, Detent Lever, Park Lock Installation
- 46. Final Drive Assembly Disassemble
- 47. Final Drive Assembly Assemble
- 48. Final Drive Pinion End Play Check
- 49. Fretting Ring, Final Drive Internal Gear Install
- 50. Final Drive and Differential Assembly Install
- 51. Output Shaft Inspect
- 52. Output Shaft Installation
- 53. Forward Clutch Support, Roller Clutch Disassemble
- 54. Forward Clutch Support, Low Roller Clutch Assemble
- 55. Forward Clutch Support, Low Roller Clutch Install
- 56. Forward Clutch Disassemble
- 57. Forward Clutch Assemble
- 58. Forward Clutch Functional Air Check
- 59. Low/Reverse Band Installation
- 60. Forward Clutch Installation
- 61. Input Internal Gear,Forward Clutch Hub Disassemble
- 62. Input Internal Gear, Forward Clutch Hub Assemble
- 63. Input Internal Gear, Forward Clutch Hub Install
- 64. Reaction Internal Gear, Input Carrier Disassemble
- 65. Input Carrier Pinion Gear Clearance Check
- 66. Reaction Internal Gear, Input Carrier Assemble
- 67. Reaction Internal Gear, Input Carrier Installation
- 68. Direct/Coast Clutch, Reaction Carrier Disassemble
- 69. Reaction Carrier Pinion Clearance Check
- 70. Direct/Coast Clutch, Reaction Carrier Assemble
- 71. Direct and Coast Clutch Functional Air Checks
- 72. Direct/Coast Clutch, Reaction Carrier Installation
- 73. Selective Washer Measurement and Installation
- 74. Reverse Input and 2ND Roller Clutch Disassemble
- 75. Reverse Input and 2ND Roller Clutch Assemble
- 76. Reverse Clutch Functional Air Check
- 77. Reverse Input and 2ND Roller Clutch Installation
- 78. Intermediate 4TH Band Assembly Installation
- 79. 2ND Clutch Plate Installation
- 80. Driven Sprocket Support Assembly Disassemble
- 81. Driven Sprocket Support Assemble
- 82. 2ND Clutch Functional Air Check
- 83. Driven Sprocket Support Assembly Installation
- 84. Wiring Harness Connection
- 85. Input Speed Sensor Installation
- 86. Drive, Driven Sprockets and Drive Link Disassemble
- 87. Drive, Driven Sprockets and Drive Link Assemble
- 88. Drive, Driven Sprockets and Drive Link Install
- 89. Channel Plate Assembly Disassemble
- 90. Channel Plate Assembly Assemble
- 91. Accumulator Springs Installation
- 92. Channel Plate Assembly Installation
- 93. Manual Valve Installation
- 94. Checkballs Installation
- 95. Spacer Plate and Gaskets Installation
- 96. Control Valve Body Disassemble
- 97. Control Valve Body Assemble
- 98. Control Valve Assembly and TFP Switch Installation
- 99. Wiring Harness Assembly Connect
- 100. Oil Pump Clean and Inspect
- 101. Oil Pump Assembly Installation
- 102. Side Cover/Gaskets, Disassemble, Assemble, Install
- 103. Side Cover Axle Seal Installation
- 104. Output Shaft Sleeve Assembly Installation
- 105. Stub Shaft Sleeve Assembly Installation
- 106. Right Hand Axle Seal Assemble
- 107. Vehicle Speed Sensor Installation
- 108. Intermediate/4TH Servo Disassemble
- 109. Intermediate/4TH Servo Assemble and Installation
- 110. Low and Reverse Servo Disassemble
- 111. Low and Reverse Servo Assemble and Installation
- 112. Oil Feed Pipes Assemble
- 113. Filter Assembly and Seal Installation
- 114. Oil Level Control Valve Installation
- 115. Oil Pan and Gasket Installation
- 116. Torque Converter Installation
- 3T40-E Automatic Transaxle
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Exploded Views
- 3T40 Automatic Transaxle
- Transaxle Major Component Locations
- Case and Associated Parts
- Auxiliary Valve Body Assembly
- Control Valve Body and Fluid Pump Assembly
- Case Cover Assembly
- Drive Sprocket Support Assembly
- Direct Clutch Assembly
- Forward Clutch Assembly
- Input Components
- Low and Reverse Clutch Assembly
- Final Drive and Differential Carrier Assembly
- Parking Lock Assembly
- Bushing, Bearing and Thrust Washer Locations
- Seal Locations
- Possible Fluid Lead Points
- Auxiliary Valve Body Cover Fluid Passages
- Auxiliary Valve Body Cover Gasket Fluid Passages
- Auxiliary Valve Body Fluid Passages
- Control Valve Body and Fluid Pump Assembly Fluid Passages
- Control Valve Body Fluid Passages
- Typical Control Valve Body Spacer Plate Fluid Passages
- Case Cover Fluid Passages
- Driven Sprocket Support Fluid Passages
- Oil Pump Drive Shaft and Drive Sprocket Support Fluid Passages
- Case Fluid Passages
- Forward Clutch Assembly Fluid Passages
- 4T40-E/4T45-E Automatic Transaxle
- 3T40 Automatic Transaxle
- Connector Views
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Clutch
- Clutch Disc
- Clutch Hydraulic System
- Clutch Pedal Assembly
- Pressure Plate
- Description and Operation
- Testing and Inspection
- Service and Repair
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Continuously Variable Transmission/Transaxle
- Drive Axles, Bearings and Joints
- Flex Plate
- Flywheel
- Lamps and Indicators - Transmission and Drivetrain
- Manual Transmission/Transaxle
- Bell Housing
- Drain Plug
- Fluid - M/T
- Seals and Gaskets
- Shifter M/T
- Shift Linkage
- Transmission Mount
- Application and ID
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- Bearing Failure
- Click Noise In Turns
- Clunk on Acceleration or Deceleration
- Fluid Leak Diagnosis and Repair
- Knock at Low Speeds
- Noise Most Pronounced on Turns
- Noisy In All Gears
- Noisy In Fifth Gear Only
- Noisy In First Gear Only
- Noisy In Fourth Gear Only
- Noisy In Neutral With Engine Running
- Noisy In Reverse Only
- Noisy In Second Gear Only
- Noisy In Third Gear Only
- Slips Out of Gear
- Slips Out of Gear While Accelerating
- Slips Out of Gear While Coasting
- Vibration Diagnosis
- Locations
- Service and Repair
- Overhaul (Unit Repair)
- Transaxle Case Disassemble
- Intermediate Shaft Disassemble
- Input Shaft Disassemble
- Output Shaft Disassemble
- Differential Case Disassemble
- Shifter Disassemble
- Clutch and Differential Housing Cleaning and Inspection
- Gears Cleaning and Inspection
- Thrust Washer and Bearing Cleaning and Inspect
- Synchronizers Cleaning and Inspection
- Shift Fork Cleaning and Inspection
- Shifter Assemble
- Intermediate Shaft Assemble
- Input Shaft Assemble
- Output Shaft Assemble
- Differential Case Assemble
- Transaxle Case Assembly
- Shimming Procedures
- Transmission Replacement
- Overhaul (Unit Repair)
- Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Sensors and Switches - Transmission and Drivetrain
- Transmission Control Systems
- Actuators and Solenoids - Transmission and Drivetrain
- Lamps and Indicators - Transmission and Drivetrain
- Sensors and Switches - Transmission and Drivetrain
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Technical Service Bulletins
- Specifications
- Technical Service Bulletins
- Brakes and Traction Control
- Antilock Brakes / Traction Control Systems
- ABS Light
- Brake Fluid Solenoid Valve Relay
- Electronic Brake Control Module
- Hydraulic Control Assembly - Antilock Brakes
- Traction Control Indicator Lamp
- Traction Control Switch
- Wheel Speed Sensor
- Description and Operation
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Tools and Equipment
- Brake Bleeding
- Brake Pedal Assy
- Brake Warning Indicator
- Disc Brake System
- Drum Brake System
- Hydraulic System
- Brake Bleeding
- Brake Caliper
- Brake Fluid
- Brake Fluid Level Sensor/Switch
- Brake Hose/Line
- Hydraulic Control Assembly - Antilock Brakes
- Brake Master Cylinder
- Wheel Cylinder
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- - Symptoms - Hydraulic Brakes
- Brake Pulsation
- Brake Pedal Excessive Effort
- Brake Pedal Excessive Travel
- Brake System Noise
- Brake System Slow Release
- Brake Warning Indicator Always On
- Brake Warning Indicator Inoperative
- Brakes Drag
- Braking Action Uneven - Front to Rear
- Braking Action Uneven - Pulls to One Side
- Component Tests and General Diagnostics
- Brake Assist System Diagnosis
- Brake Fluid Loss Diagnosis
- Brake Pedal Pushrod Inspection
- Brake Pedal Travel - Measurement & Inspection
- Brake Pipe and Hose Inspection
- Brake System External Leak Inspection
- Brake System Internal Leak Test
- Brake System Vacuum Source Test
- Brake System Vehicle Road Test
- Disc Brake System Diagnosis
- Drum Brake System Diagnosis
- Hydraulic Brake Component Operation
- Hydraulic Brake System Diagnosis
- Scan Tool Testing and Procedures
- Service and Repair
- Tools and Equipment
- Parking Brake System
- Power Brake Assist
- Relays and Modules - Brakes and Traction Control
- Sensors and Switches - Brakes and Traction Control
- Specifications
- Technical Service Bulletins
- Antilock Brakes / Traction Control Systems
- Starting and Charging
- Sensors and Switches - Starting and Charging
- Battery
- Charging System
- Alternator
- Description and Operation
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Starting System
- Ignition Switch
- Key
- Neutral Safety Switch
- Starter Motor
- Starter Solenoid
- Description and Operation
- Testing and Inspection
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Power and Ground Distribution
- Fuse
- Fuse Block
- Ground Strap
- Grounding Point
- Multiple Junction Connector
- Relays and Modules - Power and Ground Distribution
- Relay Box
- Wiring Harness
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Symptom Related Diagnostic Procedures
- Component Tests and General Diagnostics
- Battery Charging Procedure
- Battery Charging Time Required
- Battery Electrical Drain/Parasitic Load Test
- Battery General Information
- Battery Inspection/Test
- Battery Protection During Vehicle Storage
- Charging System Test
- Electrolyte Freezing
- Generator Noise Diagnosis
- Jump Starting Procedures
- Starter Motor Noise Diagnosis
- Scan Tool Testing and Procedures
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Power and Ground Distribution
- Fuse
- Fuse Block
- Ground Strap
- Grounding Point
- Multiple Junction Connector
- Relays and Modules - Power and Ground Distribution
- Relay Box
- Wiring Harness
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Steering and Suspension
- Alignment
- Relays and Modules - Steering and Suspension
- Sensors and Switches - Steering and Suspension
- Steering
- Front Steering Knuckle
- Power Steering
- Steering Column
- Air Bag(s) Arming and Disarming
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- - Symptoms - Tilt Column
- - Symptoms List
- A/T Shift Lock, High Lock Effort
- A/T Shift Lock, Lock System Does Not Lock
- High Lock Effort - Tilt Column
- Key Cannot Be Removed In the Off Lock Position
- Key Cannot Be Removed In the Off Lock Position - Tilt Column
- Lock System Does Not Lock - Tilt Column
- Lock System Does Not Unlock
- Lock System Does Not Unlock - Tilt Column
- Lock System Sticks In Start
- Lock System Sticks In Start - Tilt Column
- Looseness In Steering Column
- Looseness In Steering Column - Tilt Column
- Noise In Steering Column
- Noise In Steering Column - Tilt Column
- Steering Column Tilt Function Inoperative
- Locations
- Service and Repair
- - With Tilt Column
- Ignition Lock Cylinder - Revised
- Ignition Lock Cylinder - With Key
- Ignition Lock Cylinder - Without Key
- Ignition Switch
- Ignition Switch - Assemble
- Ignition Switch - Disassemble
- Intermediate Steering Shaft
- Intermediate Steering Shaft Seal
- Lock Housing - Assemble
- Lock Housing - Disassemble
- Multifunction, Turn Signal & Hazard Switch
- SIR Steering Wheel Module Coil - Assemble
- SIR Steering Wheel Module Coil - Centering
- SIR Steering Wheel Module Coil - Disassemble
- Steering Column
- Steering Column Jacket - Assemble
- Steering Column Jacket - Disassemble
- Steering Column Trim Covers
- Steering Shaft, Lower Bearing & Jacket - Assemble
- Steering Shaft, Lower Bearing & Jacket - Disassemble
- Tilt Head Housing - Assemble
- Tilt Head Housing - Disassemble
- Tilt Lever
- Tilt Spring
- Tilt Spring - Assemble
- Tilt Spring - Disassemble
- Windshield Wiper & Washer Switch
- Ignition Lock Cylinder - Revised
- Ignition Lock Cylinder - With Key
- Ignition Lock Cylinder - Without Key
- Ignition Switch
- Ignition Switch - Assemble
- Ignition Switch - Disassemble
- Intermediate Steering Shaft
- Intermediate Steering Shaft Seal
- Lock Housing - Assemble
- Lock Housing - Disassemble
- Multifunction Switch
- SIR Steering Wheel Module Coil
- SIR Steering Wheel Module Coil - Centering
- SIR Steering Wheel Module Coil - Disassemble
- Steering Column
- Steering Column Jacket - Assemble
- Steering Column Jacket - Disassemble
- Steering Column Trim Covers
- Steering Shaft, Lower Bearing & Jacket - Assemble
- Steering Shaft, Lower Bearing & Jacket - Disassemble
- Steering Wheel
- Windshield Wiper & Washer Switch
- - With Tilt Column
- Diagrams
- Specifications
- Tools and Equipment
- Steering Gear
- Steering Shaft
- Steering Wheel
- Tie Rod
- Description and Operation
- Testing and Inspection
- Service and Repair
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Suspension
- Axle Beam
- Ball Joint
- Control Arm
- Cross-Member
- Front Steering Knuckle
- Stabilizer Bar
- Suspension Strut / Shock Absorber
- Wheel Bearing
- Wheel Hub
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- - Symptoms List - Suspension
- Ball Joint Inspection
- Body Leans or Sways In Corners
- Memory Steer
- Noise Diagnosis - Front Suspension
- Noise Diagnosis - Rear Suspension
- Poor Directional Stability
- Ride Diagnosis - Too Hard
- Ride Diagnosis - Too Soft
- Strut or Shock Absorbers On-Vehicle Testing
- Suspension Bottoms
- Tire Hop or Poor Handling
- Torque Steer
- Trim Height Inspection Procedure
- Vehicle Leads/Pulls
- Wheel Bearings Diagnosis
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Wheels and Tires
- Service Precautions
- Technician Safety Information
- Vehicle Damage Warnings
- Air In the Power Steering System Notice
- Component Fastener Tightening Notice
- Fastener Notice
- Installing Hoses Without Twists or Bends Notice
- Power Steering Hose Disconnected Notice
- Steering Column In Lock Position Notice
- Steering Wheel In the Full Turn Position Notice
- Torque to Yield Bolts Notice
- Using Proper Power Steering Fluid Notice
- Technical Service Bulletins
- Heating and Air Conditioning
- Accumulator HVAC
- Air Door
- Air Duct
- Air Register
- Blower Motor
- Blower Motor Relay
- Blower Motor Resistor
- Blower Motor Switch
- Cabin Ventilation Duct
- Cabin Ventilation Grille
- Compressor HVAC
- Compressor Clutch
- Compressor Control Valve Assembly
- Compressor Shaft Seal
- Testing and Inspection
- Locations
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Compressor Clutch Relay
- Condenser HVAC
- Condenser Fan Motor Relay
- Control Assembly
- Coupler HVAC
- Evaporator Case
- Evaporator Core
- Expansion Block/Orifice Tube
- Heater Core
- Heater Hose
- High Pressure Safety Valve HVAC
- Hose/Line HVAC
- Housing Assembly HVAC
- Refrigerant
- Refrigerant Filter
- Refrigerant Oil
- Refrigerant Pressure Sensor / Switch
- Relays and Modules - HVAC
- Sensors and Switches - HVAC
- Service Port HVAC
- Vacuum Harness HVAC
- Vacuum Reservoir HVAC
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Symptom Related Diagnostic Procedures
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Locations
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Vacuum and Vapor Hose Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Restraints and Safety Systems
- Repairs and Inspections Required After a Collision
- Air Bag Systems
- Air Bag(s) Arming and Disarming
- Air Bag
- Air Bag Control Module
- Clockspring Assembly / Spiral Cable
- Impact Sensor
- Seat Occupant Sensor
- Malfunction Lamp / Indicator
- Service Precautions
- Description and Operation
- Testing and Inspection
- Locations
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Head Restraint System
- Knee Diverter
- Relays and Modules - Restraints and Safety Systems
- Seat Belt Systems
- Air Bag(s) Arming and Disarming
- Child Restraint
- Seat Belt
- Seat Belt Buckle
- Seat Belt Buckle Switch
- Seat Belt Extension
- Seat Belt Retractor
- Description and Operation
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Sensors and Switches - Restraints and Safety Systems
- Service Precautions
- Description and Operation
- Technical Service Bulletins
- Accessories and Optional Equipment
- Antenna
- Antitheft and Alarm Systems
- Keyless Entry
- Keyless Entry Transmitter
- Description and Operation
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Lock Cylinder Switch
- Description and Operation
- Testing and Inspection
- Locations
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Technical Service Bulletins
- Keyless Entry
- Cellular Phone
- Emergency Contact Module
- Entertainment Systems
- Garage Door Opener Transmitter
- Global Positioning System
- Memory Positioning Systems
- Navigation System
- Radio, Stereo, and Compact Disc
- Amplifier
- Compact Disc Player (CD)
- Radio/Stereo
- Remote Control
- Speaker
- Tape Player
- Description and Operation
- Testing and Inspection
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Relays and Modules - Accessories and Optional Equipment
- Relay Module
- Sensors and Switches - Accessories and Optional Equipment
- Towing / Trailer System
- Specifications
- Technical Service Bulletins
- Body and Frame
- Air Bag(s) Arming and Disarming
- Repairs and Inspections Required After a Collision
- Body Control Systems
- Bumper
- Cabin Ventilation Duct
- Cabin Ventilation Grille
- Cowl
- Doors, Hood and Trunk
- Doors
- Front Door
- Rear Door
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- - Symptoms
- Power Door Locks - Inoperative - Driver Door
- Power Door Locks - Inoperative - Lockout Feature
- Power Door Locks - Inoperative - Passenger Door (With Keyless Entry)
- Power Door Locks - Inoperative - Passenger DR (W/O Keyless Entry)
- Power Mirrors - Inoperative
- Power Windows - Inoperative - All
- Power Windows - Inoperative - Express Down Function
- Power Windows - Inoperative - Lockout Function
- Power Windows - Inoperative - Passenger Door
- Power Windows - Inoperative From Master Switch
- Scan Tool Testing and Procedures
- Specifications
- Technical Service Bulletins
- Fuel Door
- Hood
- Trunk / Liftgate
- Trunk / Liftgate Hinge
- Trunk / Liftgate Handle
- Trunk / Liftgate Interior Trim Panel
- Trunk / Liftgate Latch
- Trunk / Liftgate Latch Release Cable
- Trunk / Liftgate Lock Cylinder
- Trunk / Liftgate Motor
- Trunk / Liftgate Shock / Support
- Trunk / Liftgate Stop
- Trunk / Liftgate Striker
- Trunk / Liftgate Weatherstrip
- Description and Operation
- Testing and Inspection
Adjustments- Locations
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Doors
- Exterior Moulding / Trim
- Fender
- Frame
- Grille
- Interior Moulding / Trim
- Arm Rest
- Carpet
- Console
- Dashboard / Instrument Panel
- Air Bag(s) Arming and Disarming
- Service and Repair
- HVAC Control Lamp Replacement
- Instrument Panel (IP) - Accessory Trim Plate Replacement
- Instrument Panel (IP) - Air Deflector/Louver Replacement
- Instrument Panel (IP) - Carrier Replacement
- Instrument Panel (IP) - Defroster Grille Replacement
- Instrument Panel (IP) - Endcap Replacement
- Instrument Panel (IP) - Insulator Replacement
- Instrument Panel (IP) - Outer Trim Cover Replacement
- Instrument Panel (IP) - Tie Bar / Cross Vehicle Beam
- Instrument Panel (IP) - Trim Pad Replacement
- Instrument Panel (IP) - Trim Pad Replacement - Upper
- Instrument Panel (IP) - Trim Panel Replacement - Right
- Specifications
- Glove Compartment
- Headliner
- Passenger Assist Handle
- Rear Shelf
- Scuff Plate
- Sun Visor
- Trim Panel
- Service and Repair
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Locks
- Door Locks
- Key
- Keyless Entry
- Keyless Entry Transmitter
- Description and Operation
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Power Locks
- Power Door Lock Relay
- Power Door Lock Switch
- Description and Operation
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Tools and Equipment
- Trunk / Liftgate Lock Cylinder
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Mirrors
- Heated Element
- Memory Positioning Systems
- Power Mirror Motor
- Power Mirror Switch
- Description and Operation
- Testing and Inspection
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Paint, Striping and Decals
- Radiator Support
- Relays and Modules - Body and Frame
- Roof and Associated Components
- Sunroof / Moonroof
- Sunroof / Moonroof Cable
- Sunroof / Moonroof Motor
- Sunroof / Moonroof Switch
- Sunroof / Moonroof Drain
- Sunroof / Moonroof Module
- Sunroof / Moonroof Panel
- Sunroof / Moonroof Weatherstrip
- Testing and Inspection
- Locations
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Sunroof / Moonroof
- Seats
- Sensors and Switches - Body and Frame
- Splash Guard
- Spoilers, Flaps, and Air Dams
- Unibody
- Weatherstrip
- Service Precautions
- Description and Operation
- Testing and Inspection
- Symptom Related Diagnostic Procedures
- Air/Wind Noise
- Squeaks and Rattles
- Vibration Diagnosis and Correction
- Description and Operation
- Diagnostic Information and Procedures
- Brake Rotor/Drum Balance Inspection
- Component Rotational Speed Calculation
- Diagnostic Starting Point - Vibration Diagnosis and Correction
- Engine Order Classification
- Hub/Axle Flange and Wheel Stud Runout Inspection
- Symptoms - Vibration Diagnosis and Correction
- Tire and Wheel Assembly Isolation Test
- Tire and Wheel Assembly Runout Measurement - Off-Vehicle
- Tire and Wheel Assembly Runout Measurement - On-Vehicle
- Tire and Wheel Inspection
- Vehicle-to-Vehicle Diagnostic Comparison
- Vibration Analysis - Engine
- Vibration Analysis - Engine Balance
- Vibration Analysis - Engine/Accessory Isolation
- Vibration Analysis - Hub and/or Axle Input
- Vibration Analysis - Road Testing
- Vibration Analysis - Tire and Wheel
- Vibration Diagnostic Aids
- Vibration Diagnostic Aids - Vibration Duplicated, Appears to Be Potential Operating Characteristic
- Vibration Diagnostic Aids - Vibration Duplicated, Component Not Identified
- Vibration Diagnostic Aids - Vibration Duplicated, Difficult to Isolate/Balance Component
- Vibration Diagnostic Aids - Vibration Intermittent or Not Duplicated
- Repair Instructions
- Special Tools and Equipment
- Specifications
- Waterleaks
- Component Tests and General Diagnostics
- Symptom Related Diagnostic Procedures
- Locations
- Service and Repair
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Cruise Control
- Brake Switch (Cruise Control)
- Clutch Switch
- Cruise Control Module
- Cruise Control Servo Cable
- Cruise Control Switch
- Relays and Modules - Cruise Control
- Sensors and Switches - Cruise Control
- Service Precautions
- Description and Operation
- Testing and Inspection
- Locations
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Instrument Panel, Gauges and Warning Indicators
- ABS Light
- Audible Warning Device
- Audible Warning Device Control Module
- Brake Warning Indicator
- Cigarette Lighter
- Dashboard / Instrument Panel
- Air Bag(s) Arming and Disarming
- Service and Repair
- HVAC Control Lamp Replacement
- Instrument Panel (IP) - Accessory Trim Plate Replacement
- Instrument Panel (IP) - Air Deflector/Louver Replacement
- Instrument Panel (IP) - Carrier Replacement
- Instrument Panel (IP) - Defroster Grille Replacement
- Instrument Panel (IP) - Endcap Replacement
- Instrument Panel (IP) - Insulator Replacement
- Instrument Panel (IP) - Outer Trim Cover Replacement
- Instrument Panel (IP) - Tie Bar / Cross Vehicle Beam
- Instrument Panel (IP) - Trim Pad Replacement
- Instrument Panel (IP) - Trim Pad Replacement - Upper
- Instrument Panel (IP) - Trim Panel Replacement - Right
- Specifications
- Dimmer Switch
- Door Switch
- Fuel Gauge
- Fuel Gauge Sender
- Instrument Cluster / Carrier
- Air Bag(s) Arming and Disarming
- Description and Operation
- Audible Warnings
- Indicators and Warning Messages
- ABS Indicator
- Air Bag Indicator
- Brake System Indicator
- Charging System Indicator
- Check Gauges Indicator
- Electrical System Indicator
- Engine Coolant Indicator(s)
- Engine Oil Pressure Indicator
- Fasten Safety Belt Indicator
- Fuel Gauge Selector Switch/Fuel Gauge Relay
- Fuel Indicator Lamp (FIL)
- General Description
- Indicator Symbols
- Lighting System Indicator(S)
- SERVICE ENGINE SOON Indicator (MIL)
- Shift Indicator
- Theft System Indicator
- Traction Control System Indicator(s)
- Instrument Cluster
- Locations
- Service and Repair
- Diagrams
- Low Fuel Lamp/Indicator
- Malfunction Indicator Lamp
- Odometer
- Oil Change Reminder Lamp
- Parking Brake Warning Switch
- Relays and Modules - Instrument Panel
- Sensors and Switches - Instrument Panel
- Shift Indicator - A/T
- Tachometer
- Temperature Warning Lamp/Indicator
- Tire Monitoring System
- Traction Control Indicator Lamp
- Transmission Shift Position Indicator Lamp
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Symptom Related Diagnostic Procedures
- A Preliminary Information
- Chime Always On
- Chime Inoperative
- Engine Coolant Temperature Gauge Inaccurate or Inoperative
- Engine Oil Pressure Indicator Always On
- Fuel Gage Inaccurate or Inoperative
- Fuel Gauge Inaccurate or Inoperative - Alternative Fuels
- Fuel Indicator Lamp Always On - Alternative Fuels
- Fuel Indicator Lamp Inoperative - Alternative Fuels
- Odometer Trip/Reset Switch Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Tachometer Inaccurate or Inoperative
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Lighting and Horns
- Backup Lamp
- Brake Lamp
- Brake Light Switch
- Cargo Lamp
- Center Mounted Brake Lamp
- Courtesy Lamp
- Daytime Running Lamp
- Daytime Running Lamp Relay
- Description and Operation
- Testing and Inspection
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Dimmer Switch
- Dome Lamp
- Door Switch
- Fog/Driving Lamp
- Hazard Warning Lamps
- Headlamp
- Headlamp Bulb
- Headlamp Switch
- Description and Operation
- Testing and Inspection
- Locations
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Technical Service Bulletins
- Horn
- Horn Relay
- Horn Switch
- Description and Operation
- Testing and Inspection
- Locations
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Connector Views
- Electrical Diagrams
- Specifications
- Tools and Equipment
- License Plate Lamp
- Map Light
- Marker Lamp
- Parking Lamp
- Relays and Modules - Lighting and Horns
- Sensors and Switches - Lighting and Horns
- Tail Lamp
- Trunk Lamp
- Turn Signals
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Symptom Related Diagnostic Procedures
- A Symptoms - Lighting Systems
- Backup Lamps Always On
- Backup Lamps Inoperative
- Courtesy Lamps Always On
- Courtesy Lamps Inoperative
- Courtesy Lamps Inoperative (From Door Jamb Switch)
- Daytime Running Lamps (DRL) - Indicator Inoperative
- Dome Lamps Inoperative
- Fog Lamps Always On
- Fog Lamps Inoperative
- Hazard Lamps Inoperative
- Headlamps Inoperative - Flash to Pass
- Headlamps Inoperative - High Beams
- Headlamps Inoperative - Low and High Beams
- Headlamps Inoperative - Low Beams
- High Beam Indicator Inoperative
- Illuminated Entry Lamps Inoperative
- Park Lamps Inoperative
- Reading Lamp Inoperative
- Rear Compartment Lamps Inoperative
- Stoplamps Inoperative
- Turn Signal Lamps and/or Indicator Inoperative
- Scan Tool Testing and Procedures
- Locations
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Windows and Glass
- Heated Glass Element
- Rear Defogger
- Sensors and Switches - Windows and Glass
- Windows
- Power Window Motor
- Power Window Switch
- Window Frame
- Window Glass
- Window Handle
- Window Regulator
- Description and Operation
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Windshield
- Technical Service Bulletins
- Wiper and Washer Systems
- Sensors and Switches - Wiper and Washer Systems
- Windshield Washer Pump
- Windshield Washer Switch
- Wiper Arm
- Wiper Blade
- Wiper Motor
- Wiper Switch
- Description and Operation
- Testing and Inspection
- Locations
- Service and Repair
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Electrical Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Application and ID
- Testing and Inspection
- Symptom Related Diagnostic Procedures
- Air/Wind Noise
- Squeaks and Rattles
- Vibration Diagnosis and Correction
- Description and Operation
- Specifications
- Diagnostic Information and Procedures
- Symptoms - Vibration Diagnosis and Correction
- Brake Rotor/Drum Balance Inspection
- Component Rotational Speed Calculation
- Diagnostic Starting Point - Vibration Diagnosis and Correction
- Engine Order Classification
- Hub/Axle Flange and Wheel Stud Runout Inspection
- Tire and Wheel Assembly Isolation Test
- Tire and Wheel Assembly Runout Measurement - Off Vehicle
- Tire and Wheel Assembly Runout Measurement - On-Vehicle
- Tire and Wheel Inspection
- Vehicle-to-Vehicle Diagnostic Comparison
- Vibration Analysis - Engine
- Vibration Analysis - Engine Balance
- Vibration Analysis - Engine/Accessory Isolation
- Vibration Analysis - Hub and/or Axle Input
- Vibration Analysis - Road Testing
- Vibration Analysis - Tire and Wheel
- Vibration Diagnostic Aids
- Vibration Diagnostic Aids - Vibration Duplicated, Appears to Be Potential Operating Characteristic
- Vibration Diagnostic Aids - Vibration Duplicated, Component Not Identified
- Vibration Diagnostic Aids - Vibration Duplicated, Difficult to Isolate/Balance Component
- Vibration Diagnostic Aids - Vibration Intermittent or Not Duplicated
- Repair Instructions
- Special Tools and Equipment
- Water leaks
- Programming and Relearning
- Before / After Programming A Control Module
- Control Module References
- Crankshaft Position (CKP) - Variation Learn Procedure
- Password Learn Procedure
- Powertrain Control Module (PCM) - Programming
- Remote Keyless Entry (RKE) - Automatic Synchronization
- Remote Keyless Entry (RKE) - Transmitter
- Service Programming System (SPS)
- Service Programming System (SPS) - How to Use
- Service Programming System (SPS) - Methods
- Service Programming System (SPS) - Types of Programmable Memory
- Theft Deterrent - Adding Keys
- Theft Deterrent - Programming Components
- Theft Deterrent - Replacing Keys
- Vehicle Personalization
- Symptom Related Diagnostic Procedures
- Locations
- Component Locations
- Diodes
- Lamps
- Center High Mounted Stoplamp Assembly (CHMSL)
- Center High Mounted Stoplamps
- Courtesy Lamp - Left
- Courtesy Lamp - Right
- Courtesy Lamp, Left
- Courtesy Lamp, Right
- Courtesy LP, Right Side (Folding Top Only)
- Dome Lamp
- Dome Lamp Assembly
- Fog Lamp - LF
- Fog Lamp - RF
- Headlamp - Left
- Headlamp - Right
- Headlamp Assembly
- Lamp Assembly - LR
- Lamp Assembly - RR
- License Lamp
- Marker Lamp - LF
- Marker Lamp - RF
- Park/Turn Lamp - LF
- Park/Turn Lamp - RF
- Rear Compartment Lamp
- Rear View Mirror Reading Lamps
- Rearview Mirror Courtesy Lamps
- Transaxle Shift Indicator Lamp
- Miscellaneous Components
- A/C Compressor
- A/C Compressor Clutch
- A/T Shift Lock Control Actuator
- AF Engine Control Unit
- Antenna Lead
- Automatic Transmission
- Battery
- Bleed Hose
- Boot - Spark Plug
- Brake Pedal
- Cigar Lighter (Console)
- Cigar Lighter (IP)
- Convenience Center
- Cooling Fan
- Dash Harness
- Dash Panel Extension
- Evaporative Emission Canister Purge Valve
- Flexible Hose
- Fuel Hose Pinch Point
- Fuel Injector
- Fuel Injectors Electrical Harness
- Fuel Pressure Gage Kit J 29658 D
- Fuse Block - IP
- Fuse Block - Underhood
- Generator
- Heater A/C and Rear Defogger Control Assembly
- High Pressure Regulator (HPR)
- High Pressure Regulator (HPR) Coolant Hose
- High Pressure Regulator Fuel Outlet Line
- Horn
- Housing Cover Retainer
- HPL Manual Shut-off Fitting
- HPL Pressure Relief Device (PRD) Line
- HPR Pressure Relief Device (PRD)
- Idle Air Control Valve
- Ignition Coil
- Ignition Coil Bolt/Screw
- Ignition Coil Housing Assembly
- Impact Bar, Front
- Instrument Cluster
- Instrument Panel Cluster (IPC)
- IP Fuse Block
- Lock Cylinder
- Low Pressure Regulator (LPR)
- LPR Low Pressure Hose
- Luggage Compartment Lid Lock Assembly
- Mixture Control Valve (MCV)
- Oil Filter
- Outside Mirror - Left
- Outside Mirror - Right
- Pressure Line
- Quarter Panel
- Quick Connect Adapter
- Radio
- Radio Antenna Lead
- Rear Luggage Compartment Lid Lock Cylinder Cable Assembly
- Rear Package Shelf
- Retainer - Spark Plug Boot
- Return Line
- Shift Indicator Lamp
- SIR Coil Assembly
- SIR Lead
- Speaker - LF
- Speaker - RF
- Speaker Grille, Rear (Folding Top Only)
- Speaker, Left Front (Right front is similar)
- Speaker, Left Rear
- Speaker, Rear
- Speaker, Rear (Folding Top Only)
- Speaker, Right Rear
- Spring - Spark Plug Boot
- Starter
- Steering Column Assembly
- Sunroof Assembly
- Surge Tank
- Windshield Washer Fluid Pump
- Windshield Washer Pump
- Windshield Wiper Lead
- Modules
- Body Control Module (BCM)
- CNG Fill Line
- CNG Fill Line Vent Boot (shown disconnected)
- CNG Fill Valve
- CNG Fuel Outlet Line
- CNG Fuel Pressure Test Port
- Cruise Control Module (CCM)
- EBCM/BPMV Assembly
- Electronic Brake Control Module (EBCM)
- Ignition Control Module (ICM)
- Ignition Control Module (ICM) Bolt/Screw
- Ignition Control Module (ICM) Cover
- Ignition Control Module (ICM) Wiring Harness
- Powertrain Control Module (PCM)
- Motors
- Relays
- Sensors
- A/C Refrigerant Pressure Sensor
- Automatic Transmission Fluid Temperature Sensor
- Camshaft Position Sensor
- CMP Sensor
- Crankshaft Position (CKP) Sensor
- ECT Sensor
- Fuel Pressure Sensor (FPS)
- Gas Mass Sensor
- GMS/MCV Assembly
- High Pressure Lock-off (HPL) with Internal Fuel TEMP SEN (FTS)
- Intake air Temperature Sensor (IAT)
- Manifold Absolute Pressure (MAP) Sensor
- Map Sensor
- Oxygen Sensor (O2S) Sensor 1
- Passlock Sensor
- Throttle Position (TP) Sensor
- Wheel Speed Sensor, Front
- Wheel Speed Sensor, Rear
- Solenoids
- Canister Purge Solenoid Valve
- Evaporative Emissions Canister Vent Solenoid
- High Pressure Lock-off Solenoid
- Low Pressure Lock-Off (LPL) Solenoid
- Low Pressure Lock-off Solenoid Fuel Inlet Line
- Luggage Compartment Lid Release Solenoid
- Torque Converter Clutch (TCC) Solenoid Valve
- 1-2 Shift Solenoid Valve
- 2-3 Shift Solenoid Valve
- Switches
- Brake Fluid Level Switch
- Brake Switch
- Coolant Level Switch
- Courtesy Lamp Switch, Left
- Courtesy Lamp Switch, Right
- Cruise Control Brake Switch
- Cruise Control ON/OFF Switch
- Door Jamb Switch - Driver
- Door Jamb Switch - Front Passenger
- Door Jamb Switch - LR
- Door Jamb Switch - RR
- Door Jamb Switch, Left Front
- Door Jamb Switch, Left Rear (Right Rear Is Similar)
- Door Jamb Switch, Right Front
- Door Lock Switch - Driver
- Door Lock Switch - Front Passenger
- Engine Coolant Level Switch
- ETS off/Fog/Dimmer Switch Assembly
- Fog Lamp Switch
- Fuel Gauge Selector SW/Fuel Indicator LP & Panel Dimmer SW ASSY
- Hazard Switch
- Headlamp/Cruise Control Switch
- Ignition Switch
- IP Dimmer Switch
- Master Window Switch
- Oil Pressure Switch
- Outside Mirror Switch
- Outside Power Mirror Switch
- Park Brake Switch
- Power Window Switch Lead
- Rear Compartment Lamp Switch
- Seat Belt Switch
- Stoplamp Switch
- Sunroof Switch
- Traction Control Switch
- Turn/Hazard Headlamp Switch Assembly
- Turn/Headlamp Switch Assembly
- Widow Switch - RR
- Window Switch - LR
- Windshield Wiper Switch Assembly
- Wiper/Washer Switch
- Connector Locations
- Connectors By Component Name
- A/C Compressor Clutch Electrical Connector
- ABS Actuator Motor Assembly Connector
- ABS Solenoid Connector, Right Front and Left Front
- AF Engine Control Unit Connector C001 Blue
- AF Engine Control Unit Connector C002 White/Clear
- AF Fuel Pump Relay Connector C007
- BCM Connectors
- Cooling Fan Electrical Connector
- Cruise Control Connector
- Cruise Control Switch Connector
- Data Link Connector (DLC)
- Dimmer Switch Connector
- Door Jamb Connector Right Front
- Door Jamb Switch Connector, Left Front
- Door Jamb Switch Connector, Left Rear (Right Rear Is Similar)
- Door Jamb Switch Connector, Right Front
- Door Lock Motor Connector, Left Front (Right Front Is Similar)
- Door Lock Motor Connector, Left Rear (Right Rear Is Similar)
- Door Lock Switch Connector, Left Front (Right front is similar)
- ETS Off Switch Connector
- Fog Lamp Switch Connector
- Fuel Gauge Relay Connector C012
- Fuel Gauge Select Switch Connector C254
- Fuel Pressure Sensor Connector C452 Black
- Fuel Temperature Sensor Connector C451 Gray
- Gas Mass Sensor Connector C010
- Headlamp and Turn Signal Switch Connectors
- Headlamp Bulb Connector
- Headlamp Connector
- High Pressure Lock-off Connector C453 Black
- HVAC Connector
- ICM Electrical Connector
- Ignition Relay Connector C004
- Instrument Cluster Connector
- Lock-off Relay Connector C011
- Low Pressure Lock-off Connector C014
- Mixture Control Valve Connector C021
- Multifunction Alarm Module Connector
- Oxygen Sensor (O2S) Sensor 1 Connector
- Passlock(TM) Connector
- Passlock(TM) Sensor Connector
- Power Mirror Motor Connector
- Power Mirror Switch Connector
- Radio Connector
- Rear Compartment Lamp/Switch Connector
- Speaker Connector, Left Front (Right front is similar)
- Speaker Connector, Rear
- TP Sensor Electrical Connector
- Turn/Hazard Connector
- Window Motor Connector, Left Front (Right Front Is Similar)
- Window Motor Connector, Left Rear (Right rear Is Similar)
- Window Switch Connector, Left Rear (Right Rear Is Similar)
- Windshield Wiper Connector
- Wiper Switch Connector
- Connectors By Number
- Connectors By Component Name
- Ground Locations
- Splice Locations
- Grommet Locations
- Harness Locations
- Component Locations
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- General Electrical Diagnostic Procedures
- Basic Knowledge Required
- Checking Aftermarket Accessories
- Circuit Protection
- Circuit Testing
- Connector Test Adapters
- Digital Multimeter
- Fused Jumper Wires
- Inducing Intermittent Fault Conditions
- Measuring Frequency
- Measuring Voltage
- Measuring Voltage Drop
- Probing Electrical Connectors
- Scan Tool Snapshot Procedure
- Test Lamp
- Testing For a Short To Voltage
- Testing for Continuity
- Testing For Electrical Intermittents
- Testing For Intermittent and Poor Connections
- Testing For Proper Terminal Contact
- Testing For Short to Ground
- Wiring Repairs
- Flat Wire Repairs
- Heated Oxygen Sensor (HO2S) Wiring Repairs
- Repairing Damaged Wire Insulation
- SIR/SRS Connector (Plastic Body and Terminal Metal Pin) Repair
- SIR/SRS System Wire Splice Repair
- SIR/SRS Wire Pigtail Repair
- SIR/SRS Wire Repair
- SIR/SRS Wiring Repairs
- Splicing Copper Wire Using Splice Clips
- Splicing Copper Wire Using Splice Sleeves
- Splicing Twisted or Shielded Cable
- Splicing Inline Harness Diodes
- Connector Repairs
- Equivalents - Decimal And Metric
- Arrows and Symbols
- Conversion - English/Metric
- General Electrical Diagnostic Procedures
- Exploded Views
- Automatic Transmission/Transaxle
- 3T40 Automatic Transaxle
- Transaxle Major Component Locations
- Case and Associated Parts
- Auxiliary Valve Body Assembly
- Control Valve Body and Fluid Pump Assembly
- Case Cover Assembly
- Drive Sprocket Support Assembly
- Direct Clutch Assembly
- Forward Clutch Assembly
- Input Components
- Low and Reverse Clutch Assembly
- Final Drive and Differential Carrier Assembly
- Parking Lock Assembly
- Bushing, Bearing and Thrust Washer Locations
- Seal Locations
- Possible Fluid Lead Points
- Auxiliary Valve Body Cover Fluid Passages
- Auxiliary Valve Body Cover Gasket Fluid Passages
- Auxiliary Valve Body Fluid Passages
- Control Valve Body and Fluid Pump Assembly Fluid Passages
- Control Valve Body Fluid Passages
- Typical Control Valve Body Spacer Plate Fluid Passages
- Case Cover Fluid Passages
- Driven Sprocket Support Fluid Passages
- Oil Pump Drive Shaft and Drive Sprocket Support Fluid Passages
- Case Fluid Passages
- Forward Clutch Assembly Fluid Passages
- 4T40-E/4T45-E Automatic Transaxle
- 3T40 Automatic Transaxle
- Axle Shaft Assembly
- Engine
- Manual Transmission/Transaxle
- Power Steering Pump
- Automatic Transmission/Transaxle
- Connector Views
- Connectors By Number
- Air Bag
- Air Bag Control Module
- Air Temperature Sensor ( Ambient / Intake )
- Alternator
- Amplifier, Sound System
- Antitheft and Alarm Systems
- Automatic Transmission/Transaxle
- Backup Lamp
- Blower Motor
- Blower Motor Resistor
- Body Control Module
- Brake Lamp
- Camshaft Position Sensor
- Canister Purge Solenoid
- Canister Vent Valve
- Center Mounted Brake Lamp
- Cigarette Lighter
- Clockspring Assembly / Spiral Cable, Air Bag
- Clutch Switch, Cruise Control
- Compressor Clutch
- Control Assembly, HVAC
- Coolant Level Sensor
- Crankshaft Position Sensor
- Cruise Control Module
- Cruise Control Switch
- Data Link Connector
- Daytime Running Lamp
- Dimmer Switch
- Dome Lamp
- Door Locks
- Door Switch
- Electronic Brake Control Module
- Engine Control Module
- Fog/Driving Lamp
- Fuel Injector
- Fuel Pump
- Fuel Tank Pressure Sensor
- Fuel Tank Unit
- Hazard Warning Flasher
- Hazard Warning Switch
- Headlamp
- Horn
- Idle Speed/Throttle Actuator - Electronic
- Ignition Control Module
- Impact Sensor
- Instrument Cluster / Carrier
- Knock Sensor
- License Plate Lamp
- Manifold Pressure/Vacuum Sensor
- Map Light
- Marker Lamp
- Mirrors
- Multiple Junction Connector
- Oil Pressure Sensor
- Oxygen Sensor
- Parking Brake Release Switch
- Parking Lamp
- Power Door Lock Relay
- Power Door Lock Switch
- Power Window Motor
- Power Window Switch
- Radiator Cooling Fan Motor
- Radio/Stereo
- Refrigerant Pressure Sensor / Switch, HVAC
- Seat Belt Buckle Switch
- Speaker
- Speaker - LF (UQ3)
- Speaker - LF (UW6/UQ3)
- Speaker - LF (UX7)
- Speaker - LF (U79)
- Speaker - LF (U85)
- Speaker - LR (UX7/UW6)
- Speaker - LR (W/ U85)
- Speaker - RF (UW6/UQ3)
- Speaker - RF (UX7)
- Speaker - RF (U79)
- Speaker - RF (U85)
- Speaker - RR (UQ3)
- Speaker - RR (UX7/UW6)
- Speaker - RR (W/ U85)
- Tweeter - LF (UW6/UQ3)
- Tweeter - LF (U85)
- Tweeter - RF (UW6/UQ3)
- Tweeter - RF (U85)
- Steering Column
- Sunroof / Moonroof
- Throttle Position Sensor
- Traction Control Switch
- Transmission Control Systems
- Trunk / Liftgate Motor
- Trunk Lamp
- Turn Signal Flasher
- Turn Signal Lamp
- Turn Signal Switch
- Vehicle Speed Sensor
- Wheel Speed Sensor
- Windshield Washer Pump
- Wiper Motor
- Wiper Switch
- Electrical Diagrams
- Cell References
- Air Bag Systems
- Antilock Brakes / Traction Control Systems
- Antitheft and Alarm Systems
- Automatic Transmission/Transaxle
- Cooling System
- Cruise Control
- Heated Glass Element
- Heating and Air Conditioning
- Instrument Panel, Gauges and Warning Indicators
- Lighting and Horns
- Locks
- Mirrors
- Oil Pressure Sensor
- Powertrain Management
- System Diagram
- Emission Controls
- Engine Controls
- Class 2 Serial Data, MIL, DLC, UART
- Cruise Control and Vehicle Speed Signal
- Cruise Control Module (CCM) And Vehicle Speed Sensor VSS
- Engine Data Sensors
- Generator, IAC, PNP and EOP
- PCM References - Controlled/Monitored Subsystem
- Power, Ground, CMP, CKP, KS, and ICM
- Power, Ground, HO2S 1 And HO2S 2
- Standard Models (Non-Alternative Fuels)
- Fuel Controls
- Transmission Controls
- Computers and Control Systems
- Emission Control Systems
- Fuel Delivery and Air Induction
- Ignition System
- System Diagram
- Radio, Stereo, and Compact Disc
- Rear Defogger
- Seat Belt Systems
- Starting and Charging
- Sunroof / Moonroof
- Transmission Control Systems
- Trunk / Liftgate
- Windows
- Wiper and Washer Systems
- Mechanical Diagrams
- Vacuum and Vapor Hose Diagrams
- Components
- Diodes
- Lamps
- Center High Mounted Stoplamp Assembly (CHMSL)
- Center High Mounted Stoplamps
- Courtesy Lamp - Left
- Courtesy Lamp - Right
- Courtesy Lamp, Left
- Courtesy Lamp, Right
- Courtesy LP, Right Side (Folding Top Only)
- Dome Lamp
- Dome Lamp Assembly
- Fog Lamp - LF
- Fog Lamp - RF
- Headlamp - Left
- Headlamp - Right
- Headlamp Assembly
- Lamp Assembly - LR
- Lamp Assembly - RR
- License Lamp
- Marker Lamp - LF
- Marker Lamp - RF
- Park/Turn Lamp - LF
- Park/Turn Lamp - RF
- Rear Compartment Lamp
- Rear View Mirror Reading Lamps
- Rearview Mirror Courtesy Lamps
- Transaxle Shift Indicator Lamp
- Miscellaneous Components
- A/C Compressor
- A/C Compressor Clutch
- A/T Shift Lock Control Actuator
- AF Engine Control Unit
- Antenna Lead
- Automatic Transmission
- Battery
- Bleed Hose
- Boot - Spark Plug
- Brake Pedal
- Cigar Lighter (Console)
- Cigar Lighter (IP)
- Convenience Center
- Cooling Fan
- Dash Harness
- Dash Panel Extension
- Evaporative Emission Canister Purge Valve
- Flexible Hose
- Fuel Hose Pinch Point
- Fuel Injector
- Fuel Injectors Electrical Harness
- Fuel Pressure Gage Kit J 29658 D
- Fuse Block - IP
- Fuse Block - Underhood
- Generator
- Heater A/C and Rear Defogger Control Assembly
- High Pressure Regulator (HPR)
- High Pressure Regulator (HPR) Coolant Hose
- High Pressure Regulator Fuel Outlet Line
- Horn
- Housing Cover Retainer
- HPL Manual Shut-off Fitting
- HPL Pressure Relief Device (PRD) Line
- HPR Pressure Relief Device (PRD)
- Idle Air Control Valve
- Ignition Coil
- Ignition Coil Bolt/Screw
- Ignition Coil Housing Assembly
- Impact Bar, Front
- Instrument Cluster
- Instrument Panel Cluster (IPC)
- IP Fuse Block
- Lock Cylinder
- Low Pressure Regulator (LPR)
- LPR Low Pressure Hose
- Luggage Compartment Lid Lock Assembly
- Mixture Control Valve (MCV)
- Oil Filter
- Outside Mirror - Left
- Outside Mirror - Right
- Pressure Line
- Quarter Panel
- Quick Connect Adapter
- Radio
- Radio Antenna Lead
- Rear Luggage Compartment Lid Lock Cylinder Cable Assembly
- Rear Package Shelf
- Retainer - Spark Plug Boot
- Return Line
- Shift Indicator Lamp
- SIR Coil Assembly
- SIR Lead
- Speaker - LF
- Speaker - RF
- Speaker Grille, Rear (Folding Top Only)
- Speaker, Left Front (Right front is similar)
- Speaker, Left Rear
- Speaker, Rear
- Speaker, Rear (Folding Top Only)
- Speaker, Right Rear
- Spring - Spark Plug Boot
- Starter
- Steering Column Assembly
- Sunroof Assembly
- Surge Tank
- Windshield Washer Fluid Pump
- Windshield Washer Pump
- Windshield Wiper Lead
- Modules
- Body Control Module (BCM)
- CNG Fill Line
- CNG Fill Line Vent Boot (shown disconnected)
- CNG Fill Valve
- CNG Fuel Outlet Line
- CNG Fuel Pressure Test Port
- Cruise Control Module (CCM)
- EBCM/BPMV Assembly
- Electronic Brake Control Module (EBCM)
- Ignition Control Module (ICM)
- Ignition Control Module (ICM) Bolt/Screw
- Ignition Control Module (ICM) Cover
- Ignition Control Module (ICM) Wiring Harness
- Powertrain Control Module (PCM)
- Motors
- Relays
- Sensors
- A/C Refrigerant Pressure Sensor
- Automatic Transmission Fluid Temperature Sensor
- Camshaft Position Sensor
- CMP Sensor
- Crankshaft Position (CKP) Sensor
- ECT Sensor
- Fuel Pressure Sensor (FPS)
- Gas Mass Sensor
- GMS/MCV Assembly
- High Pressure Lock-off (HPL) with Internal Fuel TEMP SEN (FTS)
- Intake air Temperature Sensor (IAT)
- Manifold Absolute Pressure (MAP) Sensor
- Map Sensor
- Oxygen Sensor (O2S) Sensor 1
- Passlock Sensor
- Throttle Position (TP) Sensor
- Wheel Speed Sensor, Front
- Wheel Speed Sensor, Rear
- Solenoids
- Canister Purge Solenoid Valve
- Evaporative Emissions Canister Vent Solenoid
- High Pressure Lock-off Solenoid
- Low Pressure Lock-Off (LPL) Solenoid
- Low Pressure Lock-off Solenoid Fuel Inlet Line
- Luggage Compartment Lid Release Solenoid
- Torque Converter Clutch (TCC) Solenoid Valve
- 1-2 Shift Solenoid Valve
- 2-3 Shift Solenoid Valve
- Switches
- Brake Fluid Level Switch
- Brake Switch
- Coolant Level Switch
- Courtesy Lamp Switch, Left
- Courtesy Lamp Switch, Right
- Cruise Control Brake Switch
- Cruise Control ON/OFF Switch
- Door Jamb Switch - Driver
- Door Jamb Switch - Front Passenger
- Door Jamb Switch - LR
- Door Jamb Switch - RR
- Door Jamb Switch, Left Front
- Door Jamb Switch, Left Rear (Right Rear Is Similar)
- Door Jamb Switch, Right Front
- Door Lock Switch - Driver
- Door Lock Switch - Front Passenger
- Engine Coolant Level Switch
- ETS off/Fog/Dimmer Switch Assembly
- Fog Lamp Switch
- Fuel Gauge Selector SW/Fuel Indicator LP & Panel Dimmer SW ASSY
- Hazard Switch
- Headlamp/Cruise Control Switch
- Ignition Switch
- IP Dimmer Switch
- Master Window Switch
- Oil Pressure Switch
- Outside Mirror Switch
- Outside Power Mirror Switch
- Park Brake Switch
- Power Window Switch Lead
- Rear Compartment Lamp Switch
- Seat Belt Switch
- Stoplamp Switch
- Sunroof Switch
- Traction Control Switch
- Turn/Hazard Headlamp Switch Assembly
- Turn/Headlamp Switch Assembly
- Widow Switch - RR
- Window Switch - LR
- Windshield Wiper Switch Assembly
- Wiper/Washer Switch
- Connectors
- Connectors By Component Name
- A/C Compressor Clutch Electrical Connector
- ABS Actuator Motor Assembly Connector
- ABS Solenoid Connector, Right Front and Left Front
- AF Engine Control Unit Connector C001 Blue
- AF Engine Control Unit Connector C002 White/Clear
- AF Fuel Pump Relay Connector C007
- BCM Connectors
- Cooling Fan Electrical Connector
- Cruise Control Connector
- Cruise Control Switch Connector
- Data Link Connector (DLC)
- Dimmer Switch Connector
- Door Jamb Connector Right Front
- Door Jamb Switch Connector, Left Front
- Door Jamb Switch Connector, Left Rear (Right Rear Is Similar)
- Door Jamb Switch Connector, Right Front
- Door Lock Motor Connector, Left Front (Right Front Is Similar)
- Door Lock Motor Connector, Left Rear (Right Rear Is Similar)
- Door Lock Switch Connector, Left Front (Right front is similar)
- ETS Off Switch Connector
- Fog Lamp Switch Connector
- Fuel Gauge Relay Connector C012
- Fuel Gauge Select Switch Connector C254
- Fuel Pressure Sensor Connector C452 Black
- Fuel Temperature Sensor Connector C451 Gray
- Gas Mass Sensor Connector C010
- Headlamp and Turn Signal Switch Connectors
- Headlamp Bulb Connector
- Headlamp Connector
- High Pressure Lock-off Connector C453 Black
- HVAC Connector
- ICM Electrical Connector
- Ignition Relay Connector C004
- Instrument Cluster Connector
- Lock-off Relay Connector C011
- Low Pressure Lock-off Connector C014
- Mixture Control Valve Connector C021
- Multifunction Alarm Module Connector
- Oxygen Sensor (O2S) Sensor 1 Connector
- Passlock(TM) Connector
- Passlock(TM) Sensor Connector
- Power Mirror Motor Connector
- Power Mirror Switch Connector
- Radio Connector
- Rear Compartment Lamp/Switch Connector
- Speaker Connector, Left Front (Right front is similar)
- Speaker Connector, Rear
- TP Sensor Electrical Connector
- Turn/Hazard Connector
- Window Motor Connector, Left Front (Right Front Is Similar)
- Window Motor Connector, Left Rear (Right rear Is Similar)
- Window Switch Connector, Left Rear (Right Rear Is Similar)
- Windshield Wiper Connector
- Wiper Switch Connector
- Connectors By Number
- Connectors By Component Name
- Grounds
- Splices
- Grommets
- Harness
- Specifications
- Electrical Specifications
- Mechanical Specifications
- Accessories and Optional Equipment
- Air Bag Systems
- Alignment
- Automatic Transmission/Transaxle
- System Specifications
- Band Apply Servo, A/T
- Case, A/T
- Fluid Line/Hose, A/T
- Fluid Pan, A/T
- Fluid Pressure Sensor/Switch, A/T
- Fluid Pump, A/T
- Shifter A/T
- Torque Converter
- Torque Converter Clutch Solenoid, A/T
- Torque Converter Cover
- Transmission Mount, A/T
- Transmission Position Sensor/Switch, A/T
- Transmission Speed Sensor, A/T
- Valve Body, A/T
- Axle Shaft Assembly
- Body and Frame
- Brakes and Traction Control
- System Specifications
- Antilock Brakes / Traction Control Systems
- Brake Hose/Line
- Brake Master Cylinder
- Brake Pedal Assy
- Disc Brake System
- Drum Brake System
- Parking Brake Lever
- Clutch, M/T
- Computers and Control Systems
- Cooling System
- Cruise Control Module
- Engine
- System Specifications
- Camshaft Bearing
- Camshaft Gear/Sprocket
- Cylinder Block Assembly
- Cylinder Head Assembly
- Engine Oil Drain Plug
- Intake Manifold
- Oil Filter, Engine
- Oil Pump, Engine
- Timing Components
- Exhaust System
- Flex Plate
- Flywheel
- Heating and Air Conditioning
- Idle Speed
- Ignition System
- Instrument Panel, Gauges and Warning Indicators
- Lighting and Horns
- Manual Transmission/Transaxle
- Seat Belt Systems
- Starting and Charging
- Steering
- Suspension
- Wheel Stud / Lug Nut
- Windows
- Wiper and Washer Systems
- Pressure, Vacuum and Temperature Specifications
- Capacity Specifications
- Fluid Type Specifications
- Brakes and Traction Control
- Coolant
- Engine Oil
- Maintenance
- A Recommended Fluids and Lubricants
- Automatic/Manual Transmission/Transaxle Shift Linkage
- C/V or U-Joints, Propshaft or Yoke Splines and Clutch Fork
- Chassis Lubrication
- Hinges and Locks
- Linkage, Latches, Pivots and Spring Anchors
- Parking Brake Cable Guides
- Weatherstrip Conditioning
- Wheel Bearings
- Windshield Washer Solvent
- Power Steering Fluid
- Refrigerant
- Refrigerant Oil
- Transmission and Drivetrain
- Wheel Bearing
- Technical Service Bulletins
Diagnostic Trouble Codes