Repair and Diagnosis: Technical Service Bulletins

• How to Find Technical Service Bulletins by Category/Symptom
• Recalls
  • Campaign - T/S/Hazard Switch Warranty Extension
    • Overview
    • Service Procedure
    • Owner Letter
  • Campaign - Deactivation Of Analog OnStar(R)
    • Overview
    • Service Procedure
      • 2001 and Older Model Year Vehicles (Except Saab Vehicles)
      • 2002 Through 2006 Model Year Vehicles (Except Saab Vehicles)
      • 2000-2002 Saab 9-3 (9400) 4D/5D; 2000-2003 Saab 9-3 (9400) CV
      • 2003-2005 Saab 9-3 (9400) 4D/5D; 2004-2005 Saab 9-3 (9400) CV
      • 2000-2004 Saab 9-5
    • Owner Letter
• Customer Interest
  • Interior - Eliminating Unwanted Odors in Vehicles
  • Body - Broken Rear Window Defogger Grid Detection
  • Audio System - Noise When Using Portable Playback Unit
  • Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
  • Power Steering - Fluid Leaks Due to Extreme Low Temps
  • Restraints - Seat Belt Latching Issues/Warning Lights
  • A/C - Musty Odors Emitted From (HVAC) System
  • A/C - Window Defroster Contact/Tab Repair Information
  • Electrical - MIL ON/DTC's Set By Various Control Modules
  • OnStar(R) - Number Incorrect/Incorrectly Assigned
  • Brakes - Front Disc Brake Pulsation
  • Starting System - Engine No Start/No Crank Condition
  • Steering - Momentary P/S Reduction On Initial Start Up
  • Instrument Panel - Rattle/Itching Noise
  • Suspension - Front End Squeaking Noise When Turning
  • Suspension - Front Suspension Clunk/Rattle Noise
  • Tires/Wheels - Scraping/Scrunching Noise
  • Wheels - Plastic Wheel Nut Covers Loose/Missing
  • Body - Rear Compartment Air Rush/Moaning Noise
  • Brakes - Creaking Noise On Slow Speed Braking
  • A/T - Shift Flare/DTC's Set/SES Lamp ON
  • Engine Controls - OBD System Improvement
  • Body - Power Window(s) Inoperative
  • Fuel System - Inaccurate Fuel Gauge Readings
  • Engine - Oil Leaks From the Front Crank Seal When Cold
  • Suspension - Front/Rear Squawking Noise
  • Body - Wind Noise From Rear of Vehicle
  • Computers And Controls - DTC's Set Replacing Modules
  • A/T - MIL/SES Lamp ON/Multiple A/T DTC's Set
  • A/T - 4T65E Poor Performance/Harsh Shifts/DTC's Set
  • Electrical - Intermittent Stall/SES Lamp ON
  • Body - Creak/Groan When Opening/Closing Doors
  • Body/Frame - Outer Door Glass Surface Scratches
  • Body - Rear Compartment Molding Loose/Broken
  • Body - Sunroof Won't Open/Close Completely
  • Lighting - Stop/Tail Lamps Inoperative/Water Inside
  • A/T - Slipping/Won't Shift/No Reverse/2nd/3rd/OD
  • Instruments - GPS System Performance Degradation
  • Cigarette Lighter - Inoperative
  • A/T - 4T65-E Fluid Leaks From Reverse Servo Cover
  • Audio System - Poor Radio Reception
  • HomeLink(R) Transmitter - Programming Difficulties
  • Fuel System - No Start/Low Power/Hesitation
  • M/T - Grinding/Rattling Noise
  • Body - Water on Front Floor
  • Suspension - Popping/Rattling Noise When Turning
  • Body - Door Glass Won't Roll Up or Out of Channel
  • Engine, A/T - Shift/Driveability Concerns/MIL ON
  • A/T - DTC's P0741/P0751/P0752/P0756/P0757/P1811
  • OnStar(R) - Incorrect GPS Position Reported During Call
  • OnStar(R) - Loss of GPS Signal/Hands Free Issues
  • A/T - No Movement in Drive or 3rd Gear
  • A/T - 4L60/65E, No Reverse/2nd or 4th Gear
  • A/T - 4T65E Fluid Leaking From A/T Vent
  • Body - Door Glass Sash Comes Out Of Run Channel
  • Body - Marks/Stains on Windshield When Wet
  • Body - Bumps or Rust Colored Spots in Paint
  • Body - Stain/Film On Windshield Glass Perimeter
  • Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
  • A/T - 4T80-E (MH1) Left Front. Axle Seal Leak, Slipping
• Recommended Repairs
  • A/C - Musty Odors Emitted From (HVAC) System
• Superceded Bulletins
  • 10-00-89-010A - 10/19/12
  • 12-06-01-008 - 09/01/12
  • 04-06-01-029F - 09/01/12
  • 05-06-04-022H - 07/18/12
  • 04-06-04-047J - 07/18/12
  • 00-03-10-006G - 07/17/12
  • 03-03-10-007F - 07/12/12
  • 01-08-51-003A - 11/01/2010
  • 01-08-51-003 - 01/01/2010
  • 08-07-30-035A - 01/01/2010
  • 05-06-04-022F - 10/01/10
  • 00-07-30-009B - 11/01/09
  • 06-08-64-001 - 12/01/06
  • 06-08-64-001A - 10/01/09
  • 05-03-08-002 - 12/01/05
  • 05-03-08-002A - 10/19/08
  • 05-03-08-002B - 10/01/09
  • 06-00-89-051B - 12/01/08
  • 08-08-44-010C - 06/01/08
  • 08-08-44-010B - 03/01/08
  • 08-08-44-010A - 02/01/08
  • 08-08-44-010 - 01/01/08
  • 04-07-30-017 - 01/01/08
  • 04-06-04-036D - 04/01/08
  • 04-08-50-006 - 06/01/04
  • 04-08-50-006A - 12/01/07
  • 04-06-04-054 - 01/01/07
  • 03-07-30-043 - 05/01/06
  • 05-06-04-013 - 01/01/05
  • 43-17-01 - 09/0/05
  • 43-17-01A - 10/01/05
  • 43-17-01B - 10/19/05
  • 00-06-01-012A - 02/08/05
  • 02-01-39-004 - 01/12/02
  • 00-06-04-033 - 06/17/00
  • 02-07-30-001B - 05/01/05
  • 05-06-04-026 - 04/12/05
  • 02-06-03-011 - 06/01/02
  • 04-06-04-047B - 12/01/04
  • 00-07-30-022A - 11/01/04
  • 02-08-66-005 - 08/01/02
  • 02-08-48-001 - 12/02/03
  • 02-07-30-052A - 02/07/03
  • 00-00-89-008B - 11/01/03
  • Wipers/Washers - Windshield Wiper Maintenance/Cleaning
  • Wipers - Performance/Cleaning Instructions/Maintenance
  • Windshield Wipers - Performance/Cleaning and Maintenance
  • Body - Distortion in Outer Surface of Vehicle Glass
  • Windows/Glass - Urethane Adhesive Usage
  • Glass/Body - Windshield Wiper Performance
  • Body - Distortion On Outer Glass Surfaces
  • Body - Door Glass Sash Out of Run Channel
  • Body - Door Glass is Out of Channel
  • Door Glass - Comes Out Of Run Channel
  • Door Glass Sash - Out of Run Channel
  • Body - Windows Won't Roll Up/Out of Channel
  • Body - Front Door Window Glass Won't Roll Up
  • Front Door Window Glass - Won't Roll Up
  • Front Door Window Glass - Won't Roll Up, Out of Channel
  • Body - Door Glass Won't Roll Up/Out of Channel
  • Body - Door Glass Out of Run Channel
  • Door Glass - Out of Run Channel
  • Body - Power Windows Inoperative
  • A/C - Broken Rear Window Defogger Grid Detection
  • A/C - Rear Defogger Heating Grid Damage Detection
  • A/C - Rear Defogger Inoperative/Radio Interference
  • A/C - Window Defroster Contact/Tab Repair Information
  • A/C - Rear Window Defroster Grid Contact/Tab Repair
  • Electrical, A/C - Rear Defroster Grid Repair Information
  • A/C - Broken Defogger Grid Detection
  • Lighting - Exterior Lamp Condensation/Replacement
  • Lighting - Headlamp Replacement Guidelines
  • Lighting - Headlamp Polycarbonate Lens Damage Prevention
  • Lighting - Damage To Polycarbonate Headlamp Lenses
  • Lighting - Polycarbonate Headlamp Damage Prevention
  • Polycarbonate Headlamp - Chemical Damage
  • Lighting - Headlamp Polycarbonate Lens Damage Prevention
  • Lighting - Lamp Polycarbonate Lens Damage Prevention
  • Lighting - Replacement Guidelines for Condensation
  • Lighting - Stop/Tail Lamps Intermittently Inoperative
  • Lighting - Lamp Condensation/Replacement Guidelines
  • Stop/Tail Lamps - Inoperative/Water Inside Lamp
  • Lighting - Exterior Lamp Condensation Guidelines
  • Lighting - Exterior Lamp Condensation Guideline
  • Lighting - Replacement Guidelines for Lamp Condensation
  • Exterior Lamps - Condensation Replacement Guidelines
  • A/T - PRNDL Display Dim for One Minute
  • Body - Paint-Less Dent Repair Recommendations
  • Body - Application of Anti-Corrosion Materials
  • Body - Metal Body Panel Corrosion Protection
  • Body - Hem Flange Sealer For Corrosion Protection
  • Body - Metal Body Panel Corrosion Protection
  • Body - Metal Panel Corrosion Protection
  • Body - Non-Approval of 'Clipping' for Collision Repair
  • Body - Hem Flange Repair
  • Body - Paint-Less Dent Repair Recommendations
  • Body - Weatherstrip Maintenance
  • Interior - Seat Cover Wrinkle/Crease/Burn Info
  • Interior - Seat Cover Wrinkle/Crease/Crack/Burn Info.
  • Body - Water Leaks onto Front Floor
  • Body - Sunroof Won't Open or Close Completely
  • Body -Bumps or Rust Colored Spots in Paint
  • Body - Bumps/Rust Colored Spots in Paint
  • Body - Rust Colored Spots in Paint
  • Instruments - Door Mirror Diagnostic Information
  • Mirrors - Heated Mirror Defrosting Time
  • Locks - Key Code Security Rules And Information
  • Locks - Key Code Securtiy Rules And Information
  • Interior - Odor Elimination
  • Body - Squeeze Type Resistance Spot Welding/Equipment
  • Body - Corrosion Protection for Metal Panels
  • Body - Information ON Hem Flange Repair
  • Body - Information On Metal Bonding
  • Body - Exterior Emblem Discoloration/Blistering/Peeling
  • Body - Exterior Emblem Discoloration/Peeling/Blistering
  • Body - Vehicle Glass Distortion Information
  • Body - Side Window Chipping Information
  • Body - Use of Silicone for Weatherstrip Maintenance
  • Body - Doors Creak When Opening or Closing
  • Body - Creaking Noise When Opening/Closing Doors
  • Doors - Creaking Noise When Opening or Closing
  • Instruments - O/S Rearview Mirror Diagnostics
  • Body - TPO Fascia Cleaning Prior to Painting
  • OnStar(R) - Incorrect Phone Number Assigned to Vehicle
  • OnStar(R) - Incorrect Position Reported
  • OnStar(R) - Unable to Connect to OnStar (Alaska Only)
  • OnStar(R) - Phone Number Concerns
  • Audio System - Interference With Rear Defogger ON
  • Audio System - Noise When Using Portable Playback Unit
  • Audio System -Interference With Rear Defogger ON
  • Audio System -Noise When Using Portable Playback Unit
  • A/C - Rear Defogger Inop/Poor Radio Reception
  • Audio, A/C - Poor Radio Reception/Defogger Grid Inop.
  • Audio, A/C - Radio Interference With Rear Defogger ON
  • Audio System - Poor Reception/Static With Defogger ON
  • Audio System - Vinyl Roofs Affect Radio Performance
  • Audio System - Rear Headphone Ear Pads Worn/Damaged
  • Audio System - Poor Radio Reception/Static
  • Audio System (XM) - Negative Impact of Vinyl/Cloth Roofs
  • Audio - Poor Radio Reception/Static Interference
  • Audio - Inadvertent Steering Wheel Button Activation
  • Navigation - Report Missing/Inaccurate Nav. Map Info
  • Navigation System - Software/DVD Update Program
  • Navigation System - DVD/Software Update Program
  • Navigation Radio - Diagnostics Information
  • Navigation Radio - Adaptation After Radio/Battery R/R
  • XM Radio/OnStar - Problems W/Cloth or Vinyl Roofs
  • OnStar(R) - Unable To Renew Hands-Free Call Minutes
  • Navigation System - Performance Degradation
  • Navigation Radio - Diagnostic Information
  • Campaign - Deactivating Analog OnStar(R)
  • OnStar(R) - Aftermarket Device Interference Information
  • Campaign - Deactivation of Analog OnStar(R)
  • Campaign - Analog OnStar(R) Deactivation
  • OnStar(R) -Negative Impact of Cloth/Vinyl Roofs
  • OnStar(R) - Number Incorrect/Incorrectly Assigned
  • OnStar(R) - Incorrect GPS Location Reported During Call
  • OnStar(R) - Loses GPS/Can't Renew Hands-Free Minutes
  • OnStar(R) - Unable to Connect (Alaska Vehicles)
  • OnStar (R) - Caller Minutes Cannot Be Replenished
  • OnStar (R) - Incorrect GPS Location During OnStar Call
  • OnStar System (R) - Cellular Error Messages
  • Cellular Phones - Operating Characteristics
  • Audio System- RKE Radio Feature Enabling/Disabling
  • Keyless Entry System - Operational Characteristics
  • Keyless Entry - Operational Characteristics
  • OnStar(R) Antenna Coupling - Replacement Procedures
  • Restraints - Availability of Seat Belt Extenders
  • Restraints - Seat Belt Extender Availability
  • Restraint System - Seat Belt Extender Availability
  • Interior - Seat Belt Extenders
  • Restraints - Seat Belt Warning Lamp On/Buckling Issues
  • Restraints - Seat Belt Warning Lamp On/Buckling Issues
  • Restraints - Seat Belt Operating Characteristic
  • Seat Belts - Seat Belt Extender Availability
  • Restraints - Child Seat Top Teather Attachment Kits
  • Restraints - Driver/Passenger Seat Head Rest Information
  • Restraints - Driver/Passenger Seat Head Rest Information
  • Restraints - Passenger Presence System Information
  • Restraints - Passenger Presence Sensing System Info.
  • Restraints - Front Passenger Seat Accessory Precautions
  • SRS - Front Passenger Seat Alteration Precautions
  • Restraints - Passenger Presence System Information
  • Restraints - Passenger Presence System Information
  • SRS - Occupant Sensing System Precautions
  • Restraint System - Proper Air Bag System Diagnosis
  • A/C - Broken Rear Window Defogger Grid Detection
  • Interior - Elimination Of Unwanted Odors
  • A/C - Window Defroster Contact/Tab Repair Information
  • Interior - Elimination Of Unwanted Odors
  • Interior, A/C - Vehicle Odor Elimination
  • A/C - R-134A System Flushing Procedure
  • A/C - Proper Flushing Procedures
  • A/C - Musty Odors Emitted From (HVAC) System
  • A/C - Odors In Hot/Humid Conditions
  • A/C - Odor Emission in Hot Weather
  • A/C Compressor - Diagnostic Considerations
  • Interior - Eliminating Unwanted Odors
  • Interior - New Odor Elimination Product
  • Suspension - Shock Absorber/Strut Fluid Leak Information
  • Suspension - Shock Absorber/Strut Leakage Information
  • Suspension - Squeaking Noise When Turning
  • Steering/Suspension - Rattle/Creak/Pop on Turns
  • Suspension - Front End Rattle/Creak/Pop on Turns
  • Front/Rear Suspension - Squawk Noise
  • Suspension - Front Suspension Clunk/Rattle
  • Steering - Steering Gear Stub Shaft Bearing Kit Info.
  • Steering - Steering Gear Stub Shaft Bearing Kit
  • Steering Gear - Stub Shaft Bearing Kit Availability
  • Steering Power Steering Pump Replacement Tips
  • Steering - Momentary Lack of Power Assist When Cold
  • Power Steering - Diagnostic Tips
  • Steering - Momentary Loss of Power Assist
  • Charging System - Low Voltage Display/Low/Dead Battery
  • Electrical - Information For Electrical Ground Repair
  • Electrical - Information For Electrical Ground Repair
  • Electrical - Information For Electrical Ground Repair
  • Electrical - Information For Electrical Ground Repair
  • Audio System - Portable Audio Equipment Noise
  • Locks - KeyCode Security Rules and Information
  • Locks - Key Code Security Rules and Information
  • Locks - Key Code Security Rules and Information (CANADA)
  • Charging System - Lights Dim/Low Voltage Display
  • Charging System - Operational Characteristics
  • Charging System - Low Voltage Display ON/Dim Lights
  • Battery, Charging System - Electrical Diagnostics
  • Electrical - Battery Charging Tips
  • Battery/Charging System - Electrical Diagnosis
  • Battery/Charging System - Electrical Diagnostics
  • Electrical - Testing Prior to Alternator/Battery Service
  • Electrical - Testing Before Replacing Battery or Alt
  • Battery - Parasitic Drain Information
  • Battery - Charging/Information Tips
  • Battery - Charging Tips
  • Battery/Charging System - Diagnosis/Testing
  • Engine - Intermittent No Crank/No Start
  • Disc Brake System - Warranty Service and Procedures
  • Brakes - Brake Warranty Service and Procedures
  • Brakes - Warranty Guidelines and Service Procedures
  • Brake System - Service Procedures and Guidelines
  • Brakes - Service Guidelines and Procedures
  • Brakes - Service Guidelines/Procedures
  • Brakes - Service Procedures/Warranty Guidelines
  • Brakes - Service Procedures/Warranty Requirements
  • Disc Brakes - Warranty Service and Procedures
  • Brakes - Brake Rotor Lateral Runout Correction
  • Brakes - Rotor Service Guidelines
  • Brake Rotor - Warranty Service Procedure
  • Front Disc Brakes - Pedal/Steering Wheel Pulsation
  • Drivetrain - Clunk Noise Shifting From PARK Into Gear
  • A/T - DEXRON(R)-VI Fluid Information
  • Drivetrain - Clunk Noise Shifting From PARK Into Gear
  • Drivetrain - Driveline Clunk Information
  • Manual Transmission - M/T Operating Characteristics
  • M/T - Operating Characteristics
  • M/T - Operating Characteristics of Manual Transmissions
  • M/T - Normal Operating Characteristics
  • M/T - Characteristics of Operation
  • M/T - Operational Characteristics
  • M/T - Operating Characteristics
  • M/T - Improved Clutch Bleeding Procedure
  • M/T - Improved Hydraulic Clutch Bleeding Procedure
  • A/T - New/Reman A/T Identification
  • A/T - Goodwrench(R) Replacement Transmissions
  • A/T - Slight Vehicle Movement In Park At Start Up
  • A/T - DTC P0894/P1870 Diagnostic Information
  • A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
  • A/T - Fluid Leak Diagnostics
  • A/T - Fluid Leak Diagnosis
  • A/T - Harsh 1 to 2 Gear Upshift Diagnostic Information
  • A/T - Fluid Oil Cooler Flush
  • A/T - Fluid Oil Cooler Flush
  • A/T - Water Or Coolant Contamination Information
  • Automatic Transmission - Fluid Cooler Flushing
  • A/T - Oil Cooler Flushing Tool/Procedure
  • A/T - Revised Cooler Line Fitting/Converter Check Valve
  • A/T - Torque Converter Replacement
  • A/T - Torque Converter Replacement Guideline
  • A/T - 4L60/65E No Reverse/2nd or 4th Gear
  • A/T - 4L60E/4L65E No Reverse/2nd or 4th Gears
  • A/T - Grinding/Growling In PARK On An Incline
  • A/T - Growling/Grinding Noise on an Incline
  • A/T - Grinding/Growling Noise in PARK on an Incline
  • A/T - Grinding/Growling While in PARK on an Incline
  • A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
  • A/T - Fluid Pan Magnet Upgrade
  • A/T -Fluid Pan Magnet Upgrade
  • A/T - Oil Pan Magnet Upgrade
  • A/T - Slips/Won't Shift/Erratic Shifting
  • A/T - 4T80E, Slips in Gear/L/H Axle Seal Leaks
  • A/T - L/H Front Axle Seal Leak/A/T Slips in Gear
  • 08-07-30-009 - 02/27/08
  • A/T - Fluid Leaking From Vent
  • A/T - 4T65-E Oil Leak From Transmission Vent
  • A/T - 4T65E Oil Leaks From Vent
  • A/T - Reverse Servo Cover Seal Leak
  • A/T - 4L60-E/4L65-E Harsh 1-2 Upshift
  • Transmission Controls - SES Lamp ON/ DTC's Set
  • A/T - Shift Flare/SES Lamp ON/DTC's Set
  • A/T - Diagnostic Info on DTCs P0894/P1870
  • Fuel System 'TOP TIER' Detergent Gasoline Information
  • Fuel System - GM Fuel System Treatment PLUS(R) Info.
  • Fuel Gauge - Erratic or Inaccurate Readings
  • Fuel System - Poor Performance Due To Injector Clogging
    • Overview
    • Correction
  • Fuel System - Maintenance Cleaning of Fuel Injectors
  • Fuel System - 'TOP TIER' Detergent Gasoline Information
  • Fuel System - TOP TIER Detergent Gasoline (Canada)
  • Fuel System - TOP TIER Gasoline Usage (Canada)
  • Fuel System - TOP TIER Detergent Gasoline Usage
  • Fuel System - TOP TIER Detergent Gasoline
  • Fuel System - GM Fuel System Treatment Plus(R)
  • Fuel System - TOP TIER Gasoline Information (Canada)
  • Fuel System - TOP TIER Gasoline Information
  • Fuel System - E85 Fuel Usage Information
  • Fuel System - E85 Fuel Usage Recommendations
  • Fuel System - E85 Fuel Usage
  • Fuel System - Fuel System Treatment PLUS(R)
  • Fuel System - TOP TIER Gasoline Recommendations
  • Fuel System - E85 Fuel Usage Recommendations/Precautions
  • Fuel System - Top Tier Gasolines (Canada)
  • Fuel System - Top Tier Gasoline Recommendations
  • Fuel System - 'Top Tier' Gasoline Information
  • Fuel System - Top Tier Gasoline Information
  • Fuel System - New Top Tier Detergent Gasoline
  • Engine Controls - Reprogramming Warranty Info.
  • Engine Controls - Aftermarket Accessory Usage
  • A/T - DTC P0756 Diagnostic Hints
  • A/T - Diagnostic Information for DTC P0894 and P1870
  • Fuel System - MIL ON/Driveability Issues
  • Engine Controls - Warranty Info., Emissions Programming
  • Fuel System - Driveability Issues/MIL ON/DTC's Set
  • Fuel System - MIL ON/DTC's Set/Driveability Problems
  • Fuel System - Various Driveability Problem/MIL ON/DTC's
  • Engine Controls - Reprogramming Warranty Coverage
  • Engine Controls - Programming Warranty Coverage
  • A/T Controls - DTCs P0894/P1870 Diagnostics
  • Emissions - OBDII I/M Readiness Test
  • A/T - DTC's P0894 and P01870 Diagnostic Information
  • Transmission Controls - DTC P0756 Diagnostic Tips
  • A/T - DTC P0756 Diagnostic Tips
  • A/T - 4L60E and 4L65E DTC P0894/P1870 Diagnostics
  • A/T - 4L60-E/4L65-E MIL ON/DTC P0757/Slipping
  • Electrical - Wiring Harness Inspection Recommendations
  • A/T Controls - DTC P0756 Diagnostic Tips
  • Electrical System - Intermittent Stalling/SES Lamp ON
  • A/T - SES Lamp ON/Multiple DTC's Set/Harsh Shifts
  • Wiring - Micro Terminal Availability
  • A/T - Harsh Shifts/MIL ON/DTC's P0716/P0717 Set
  • Engine Controls - Aftermarket Accessory Usage
  • Engine Controls - Aftermarket Accessory Usage
  • Engine Controls - Aftermarket Accessory Usage
  • Emissions - Catalytic Converter Damage/Misfire Codes Set
  • Cooling System - Aluminum Radiator/Heater Core Info.
  • Vehicle - Engine Crankcase and Subsystems Flushing Info.
  • Vehicle - Engine Crankcase and Subsystems Flushing Info.
  • Vehicle - Engine/Subsystem Flushing Recommendations
  • Engine - Use of 'Surface Conditioning Disks'
  • Engine - Crankcase Flushing Information
  • Engine - Sealant Usage/procedures
  • Engine - Surface Conditioning Disc Usage Prohibition
  • Engine - Sealant Usage Recommendations
  • Engine - Intake Manifold Inspection/Replacement
  • Intake Manifold - Inspect/Replace After Engine Damage
  • Engine/Fuel - Additive Information
  • Manual Transmission - Operating Characteristics
  • Engine - Oil Consumption Guideline Info.
  • Engine/Fuel System - Oil/Fuel Additive Recommendations
  • Engine - Oil Consumption Guideline Information
  • Engine - Oil Consumption Information
  • Engine - New Long Block Installation Precaution
  • Engine - New Cylinder Bore Sleeve Replacement Procedure
  • Engine - Cylinder Bore Liner Replacement Procedure
  • Engine - New Cylinder Bore Liner Replacement Procedure
  • Engine - Overheating/Coolant Consumption/Smoke
  • Engine - Revised Cylinder Bore Liner Replacement
  • Fuel System - Fuel Injector Maintenance Cleaning
  • Fuel System - Injector Cleaning Recommendations
  • A/C System - Flushing Procedures
  • A/C - Screen Filter Kit
  • Aluminum Wheels - Refinishing
  • Wheels - Chrome Wheel Chemical Staining
  • Wheels - Chemical Staining of Chrome Wheels
  • Wheels - Chemical Stains on Chrome Wheels
  • Wheels - Chrome Wheel Pitting/Brake Dust Accumulation
  • Wheels - Aluminum Wheel Refinishing
  • Aluminum Wheels - Low Tire Pressure Condition
  • Wheels/Tires - Slow Leaks From Aluminum Wheels
  • Wheels - Aluminum Wheel Refinishing Recommendations
  • Tires - Puncture Repair Guidelines/Procedures
  • Tires - Puncture Repair Procedures
  • Tires - Radial Force Variation Information
  • Tires - Cold Tire Flat Spotting Explanation
  • Tires - Proper Air Pressure Information
  • Tires - Proper Inflation Pressures
  • Tires - Puncture Repair Procedure
  • Wheel Nut Covers - Loose/Missing
  • A/T - Fluid Cooler Flushing
  • Cooling System - Coolant Information
  • Cooling System - Coolant Dye Update Information
  • Cooling System - DEX-COOL(R) Coolant Usage Information
  • Cooling System - DEX-COOL(R) Coolant Information
  • A/T - Fluid Flushing Procedure/Tool
  • A/T - DEXRON III(R) (H-Revision) Specification Upgrade
  • A/T - DEXRON VI Release/Applications
  • A/T - DEXRON(R) VI Fluid Availability
  • Tires/Wheels - Low Tire Pressure With Aluminum Wheels
  • Tires/Wheels - Nitrogen Gas Usage for Filling Tires
  • A/C - R-134A System Flushing Guidelines and Procedures
  • Alignment - Recommendations and Requirements
  • A/C - PAG Oil Usage
  • Engine - Unnecessary Flushing Services
  • Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
  • Wheels - Changing Procedures/Precautions
  • Wheels - Pitting/Brake Dust On Chrome Wheels
  • Tires - Original Equipment Tire Characteristics
  • Tires - Inflation Pressure Information
  • Tires - Tread Puncture Repair Procedures
  • Tires - Radial Force Variation (RFV) Information
  • Engine - Engine Oil Consumption Guideline Information
  • Cooling System - DEXCOOL(R) Leak Detection Dye
  • Wheel Alignment - Recommendations/Requirements
  • Tires - Proper Tire Pressure Information
  • Tires - Proper Inflation Pressure Information
  • A/T - DEXRON-VI(R) Fluid Availability
  • Wheels/Tires - 'Upsized' Wheel And Tire Information
  • Tires - Proper Inflation Pressure Info.
  • Engine - Noise Damage Caused By The Oil Filter
  • Engine - Internal Noise/Damage After Oil Filter Change
  • Tires - Information on Proper Tire Pressure
  • A/C - Rear Window Defroster Contact or Tab Repair
  • Wheel/Tire - Upsized Wheel/Tire Performance Info.
  • Tires/Wheels - Vibration/Balance/Shake/Flat Spotting
  • Tires/Wheels - Tire Inflation Pressure Information
  • Tires - (RFV) Radial Force Variation Information
  • Tires - Tire Puncture Repair Procedures
  • Tires - Nitrogen Gas Usage
  • Wheels/Tires - Changing Tire and Wheel Assemblies
  • Wheels/Tires -Low Tire Pressure
  • Engine - Accessory Drive Belt Noise Diagnostics/Tool
  • Wheels/Tires - Accessory Wheel/Tire Mounting/Balancing
  • Wheels/Tires - Chrome or Chrome Plated Steel Valve Caps
  • Wheels/Tires - Tire Slowly Loses Air/Low Tire Message
  • Alignment - Specifications/Requirements/Recommendations
  • Tires - Radial Force Variation (RFV) Info.
  • Tire - Use Of Nitrogen Gas In Tires
  • Tires - Correct Inflation Pressure Information
  • Wheels/Tires - Original Equipment Characteristics
  • Wheels/Tires - Tire Puncture Repair Procedures
  • Wheels/Tires - Low Tire Pressure
  • Wheels/Tires - OE Tire/Wheel Characteristics
  • Wheels/Tires - Low Tire Pressure/Aluminum Wheels Leak
  • Wheels/Tires - Tire(s) Slowly Go Flat
  • Wheel - Refinishing Aluminum Wheels
  • Tires - Tire Radial Force Variation (RFV)
  • Wheels/Tires - Tire Slowly Goes Flat/Tire Air Loss
  • Wheels - Chrome Wheel Staining/Pitting/Corrosion
  • Wheels/Tires - Use of Nitrogen Gas in Tires
  • Wheels/Tires - Tire Radial Force Variation (RFV)
  • Engine - GM Dexos 1(R) and Dexos 2(R) Oil Specifications
  • Wheels - Chrome Wheel Staining/Pitting/Corrosion
  • Tires/Wheels - Tire Slowly Goes Flat/Warning Light ON
  • Tires/Wheels - Information on Tire Radial Force Variation (RFV)
  • Vehicle - RV Dinghy Towing Information
  • Vehicle - Recreational Dinghy Towing
  • Vehicle - 'Dinghy' Towing
  • Vehicle - Precautions When Towing
  • Fuel System - Possible MIL ON/Driveability Issues
  • Emissions - Catalytic Converter Damage/Misfire DTC's
  • Fuel System - Possible MIL ON/Driveability Symptoms
    • Overview
    • Correction
  • A/T - SES Lamp ON/Multiple Driveability Concerns
  • A/T - Shift/Driveability Concerns/SES Lamp ON
• All Technical Service Bulletins
  • Electrical - Aftermarket Devices May Interfere With OnStar(R)
  • Interior - Eliminating Unwanted Odors in Vehicles
  • Locks - Key Code Security Rules, Key Code Look Up
  • Vehicle - Engine And Sub Systems Flushing Info. (CANADA)
  • Vehicle - Engine And Sub-Systems Flushing Recommendations
  • Wheels/Tires - Use Of Nitrogen Gas In Tires
  • Tires - Information On Proper Tire Pressure
  • Engine - THIS BULLETIN HAS BEEN CANCELED
  • A/T - Normal Maintenance or Warranty on 4T40, 4T45, 4T65, 4L60
  • Fuel System - TOP TIER Detergent Gasoline Information (Canada)
  • Fuel System - TOP TIER Detergent Gasoline
  • Tires/Wheels - OE Tire Shake/Vibration Information
  • Suspension - Shock Absorber/Strut Fluid Leak Information
  • M/T - Operating Characteristics Information
  • Brakes - Resurfacing Park Brake Portion of Rear Brake Rotor
  • Body - Hem Flange Sealer For Corrosion Protection
  • Engine - Intake Manifold Inspection/Replacement
  • Body - Metal Body Panel Corrosion Protection
  • Fuel System - GM Fuel System Treatment PLUS(R) Info.
  • Body - Broken Rear Window Defogger Grid Detection
  • Fuel System - Fuel Injector Maintenance Cleaning
  • Audio - Inadvertent Steering Wheel Button Activation
  • Audio System - Noise When Using Portable Playback Unit
  • Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
  • A/T - Fluid Oil Cooler Flow Test
  • Restraints - Child Seat Top Tether Attachment Kits
  • Power Steering - Fluid Leaks Due to Extreme Low Temps
  • Restraints - Passenger Presence System Information
  • Lighting - Lamp Polycarbonate Lens Damage Prevention
  • Restraints - Seat Belt Latching Issues/Warning Lights
  • Body - Side Window Chipping Information
  • Restraints - Driver/Passenger Seat Head Rest Information
  • Engine - Use of 'Surface Conditioning Disks'
  • Body - Application of Anti-Corrosion Materials
  • A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
  • A/C - Musty Odors Emitted From (HVAC) System
  • Navigation Radio - Problems After Radio/Battery Service
  • A/T - Slight Vehicle Movement In Park At Start Up
  • A/C - Window Defroster Contact/Tab Repair Information
  • A/T - DEXRON(R)-VI Fluid Information
  • Wheels/Tires - Refinishing Aluminum Wheels
  • Lighting - Exterior Lamp Condensation and Replacement
  • Electrical - MIL ON/DTC's Set By Various Control Modules
  • OnStar(R) - Number Incorrect/Incorrectly Assigned
  • Steering/Suspension - Wheel Alignment Specifications
  • Warranty - Claims Submission
  • Warranty - Parts Return Program Explained
    • Overview
    • WPC Website
    • Requests, Reminders and Debits
    • Parts Prep. for Shipping/Parts Reten. & Requests
    • Hazardous Material/Tires
    • Exchange Program Parts/Special Parts Request/R.O. Only Requests
    • WPC Forms /Return & Method of Reimbursement/Dealer Feedback
    • Parts Ret. Req/R.O. Only Examples
  • Diagnostic Worksheet - Usage
  • Brakes - Revised Specifications
  • Brakes - Front Disc Brake Pulsation
  • Electrical - Micro 64 Terminals For Wiring repair
  • Electrical - Harness Connection Inspection
  • Electrical - Instrument Panel And General Wiring Repair
  • A/C - Automatic A/C Functional Description
  • A/C - System Sealers/Leak Detection Guidelines
  • A/C - Catastrophic Compressor Failure Debris Removal
  • A/C - R-134a System Flushing Procedures
  • Engine - Identification Information
  • Engine - Crankcase Flushing Recommendations
  • Starting System - Engine No Start/No Crank Condition
  • Steering - Momentary P/S Reduction On Initial Start Up
  • A/C - Unnecessary Compressor Replacement
  • Instrument Panel - Rattle/Itching Noise
  • Suspension - Front End Squeaking Noise When Turning
  • Engine - Cylinder Bore Liner Service Update
    • Overview
    • Cylinder Bore Liner Removal/Installation
    • Cylinder Liner Trimming
  • Engine - Cylinder Bore Liner Installation
  • Engine - Revised Cylinder Sleeve Replacement Procedure
    • Overview
    • Procedures
  • Cooling System - Revised Cooling Fan/Shroud Replacement
  • Suspension - Front Suspension Clunk/Rattle Noise
  • Tires/Wheels - Scraping/Scrunching Noise
  • Tires - Sidewall Damage
  • Wheels - Plastic Wheel Nut Covers Loose/Missing
  • Body - Information On Expandable Acoustic Foam
  • Body - Metal Panel Bonding Additional Material
  • Body - Rear Compartment Air Rush/Moaning Noise
  • A/T - 4L65E, 4L60E, 4L60, 200-4R Oil Pump Spring
  • A/T - 4L60-E/4L65-E New Pump/Seal/Case/Service
  • A/T - Oil Cooler Flushing/Flow Check Procedures
  • A/T - Oil Cooler Flushing Frequently Asked Questions
  • Steering - Revised Service Procedures
  • Brakes - Creaking Noise On Slow Speed Braking
  • Brakes - Wheel Cylinder Inspection Guidelines
  • Battery - Diagnosis and Charging
    • Overview
    • I.Battery Storage In Vehicle
    • II. Warranty Policy
    • III. Testing the Battery
    • IV. Diagnosing Discharged Batteries and Parasitic Battery Drains
    • V.Battery Charging
  • Battery - Parasitic Drain
  • Battery - Specification Label Clarification
  • PCM/BCM Replacement - DTC's B001/B1271/B1780 Set
  • A/T - Shift Flare/DTC's Set/SES Lamp ON
  • Engine Controls - OBD System Improvement
  • Body - Power Window(s) Inoperative
  • Keyless Entry - Radio Personalization Feature Disabling
  • OnStar(R)/Cell Phone - Integration
  • Cell Phone - Error Messages, Bulletin Cancellation
  • Campaign - T/S/Hazard Switch Warranty Extension
    • Overview
    • Service Procedure
    • Owner Letter
  • Fuel System - Inaccurate Fuel Gauge Readings
  • Engine - Oil Leaks From the Front Crank Seal When Cold
  • Suspension - Front/Rear Squawking Noise
  • Steering - New Outer Tie Rods/Replacement Procedure
  • Suspension (Front) - Revised Torque Specifications
  • Body - Wind Noise From Rear of Vehicle
  • OnStar(R) - Unable to Connect, Bulletin Cancellation
  • Restraints - Air Bag System Diagnostics
  • Accessories - DTC's P0300, P1380, P1381
  • EVAP System - Monitor Strategy
  • EVAP System - DTC P1441 Step 10 Revised
  • A/T - 4T40E Clearing Shift Adapts
  • Computers And Controls - DTC's Set Replacing Modules
  • Body Control - Update of Some Control Module DTC's
  • Engine Controls - Revised DTC P0327
  • A/T - MIL/SES Lamp ON/Multiple A/T DTC's Set
  • A/T - 4T65E Poor Performance/Harsh Shifts/DTC's Set
  • Electrical - Intermittent Stall/SES Lamp ON
  • Body - Creak/Groan When Opening/Closing Doors
  • Door Edge - New Protection
  • Body/Frame - Outer Door Glass Surface Scratches
  • Body - Rear Compartment Molding Loose/Broken
  • Body - Sunroof Won't Open/Close Completely
  • Lighting - Stop/Tail Lamps Inoperative/Water Inside
  • A/T - 4T40-E/4T45-T Engineering Changes
  • A/T - Core Return Product Feedback Form
  • A/T - 4T40E or 4T45E Changes for 2002
  • A/T - Serial Number/Site Code Locations/Identification
  • A/T - 4T45E Engineering Changes/Overhaul Revisions
  • A/T - Slipping/Won't Shift/No Reverse/2nd/3rd/OD
  • A/T - Diagnosing Fluid Leaks
  • OnStar(R) - Cellular Antenna Replacement Parts
  • Instruments - GPS System Performance Degradation
  • Engine - Serpentine Drive Belt Wear Information
  • A/C - Control Knob Replacement Availability
  • Cigarette Lighter - Inoperative
  • Engine - Oil Capacity Correction
  • Engine - New Prelube Tool
  • Tires/Wheels - Wheel Weight Usage Precautions
  • RKE Transmitter - Correct Use of Labor Operation R4490
  • Seat Belt System - Collision Replacement Guidelines
  • Body - Urethane Adhesives for Glass Applications
  • Key/Key Number/Security Chip - Replacement
  • A/T - Shift Lock Control Feature Function
  • A/T - Pressure Control Solenoid Replacement
  • A/T - 4T65-E Final Drive Assembly Precaution
  • Drive Axles - Improved Axle Nut Availability
  • A/C - Revised HVAC Module Replacement
  • A/T - 4T65-E Fluid Leaks From Reverse Servo Cover
  • Audio System - Poor Radio Reception
  • Ignition Lock Cylinder/Switch - Replacement Revision
  • HomeLink(R) Transmitter - Programming Difficulties
  • Fuel System - No Start/Low Power/Hesitation
  • M/T - Grinding/Rattling Noise
  • Brakes - Revised System Specifications
  • Fuel - Top Tier Detergent Gasoline Information
  • A/C - New PAG Oil
  • Onstar(R) - Antenna Coupling Revised Procedures
  • Body - Water on Front Floor
  • Drivetrain - Revised Wheel Drive Shaft Replacement
  • Vehicle - Recreational (Dinghy) Towing Information
  • Steering - Tilt Wheel/Column Fastener Troque Revision
  • Suspension - Popping/Rattling Noise When Turning
  • Body - Metal Panel Adhesive Bonding Information
  • Engine Controls - MIL Function During I/M Testing
  • Emissions - OBDII I/M Readiness Testing
  • Cooling System - Coolant Recycling Information
  • A/C - Contaminated R134A Refrigerant
  • Body - Door Glass Won't Roll Up or Out of Channel
  • M/T - Hydraulic Clutch Bleeding Procedure Improvement
  • Engine, A/T - Shift/Driveability Concerns/MIL ON
  • Navigation System - Replacement Navigation Discs
  • Instruments - Reduced PRNDL Display Visibility
  • Body - Polypropylene Energy Absorber Replacement
  • Entertainment System - Headphone Foam Pad Replacement
  • Engine - Sealant Usage/Procedures
  • A/T - DTC's P0741/P0751/P0752/P0756/P0757/P1811
  • Electrical - Aftermarket Fuse Warning
  • Fuel System - E85 Fuel Usage Precautions
  • OnStar(R) - Incorrect GPS Position Reported During Call
  • OnStar(R) - Re-establishing OnStar(R) Communications
  • Cooling System - DEX-COOL(R) Coolant Leak Detection Dye
  • OnStar(R) - Loss of GPS Signal/Hands Free Issues
  • Wheels - Chrome Wheel Brake Dust Accumulation/Pitting
  • Electrical - Battery Charging Tips/Recommendations
  • Battery/Charging System - Electrical Diagnostics Info.
  • Brakes - Rotor Lateral Runout Correction Information
  • Restraints - Usage of Used/Salvaged/Imitation Components
  • Fuel System - E85 Fuel Usage Precaution
  • Keyless Entry System - Characteristics of Operation
  • A/C - Refrigerant Recovery/Recycling/Equipment
  • A/T - Torque Converter Replacement Information
  • Emission - Emissions Programming Warranty Coverage
  • A/T - No Movement in Drive or 3rd Gear
  • A/T - Grinding/Growling Noise in Park on Incline
  • A/T - 4L60/65E, No Reverse/2nd or 4th Gear
  • Engine/Fuel System - Oil/Fuel Additive Information
  • Tire Monitor System - TPM Sensor Information
  • Charging System - Low Voltage Display/Battery Discharged
  • Cooling System, A/C - Aluminum Heater Cores/Radiators
  • Wheels/Tires - Upsized Wheel/Tire Characteristics
  • Audio System - Refurbishing Radio Faceplates/Knobs
  • Audio System - XM(R) Terrestrial Repeater Changes
  • A/T - 4T65E Fluid Leaking From A/T Vent
  • Body - Door Glass Sash Comes Out Of Run Channel
  • Gasoline Engine - Oil Consumption Guidelines
  • A/T - Revised Converter Check Valve/Cooler Line Fitting
  • Body - Non-Approval of Clipping For Collision Repair
  • A/T Control - DTC P0756 Diagnostic Tips
  • Instruments - Unnecessary Park Assist Mirror Replacement
  • Campaign - Deactivation Of Analog OnStar(R)
    • Overview
    • Service Procedure
      • 2001 and Older Model Year Vehicles (Except Saab Vehicles)
      • 2002 Through 2006 Model Year Vehicles (Except Saab Vehicles)
      • 2000-2002 Saab 9-3 (9400) 4D/5D; 2000-2003 Saab 9-3 (9400) CV
      • 2003-2005 Saab 9-3 (9400) 4D/5D; 2004-2005 Saab 9-3 (9400) CV
      • 2000-2004 Saab 9-5
    • Owner Letter
  • Body - Hem Flange Rust Repair Information
  • Body - Marks/Stains on Windshield When Wet
  • Wheels/Tires - Chrome/Steel Valve Stem Cap Precautions
  • Navigation Radio - Diagnostic Tips
  • Brakes- Disc Brake Warranty Service And Procedures
    • Overview
    • Procedures
      • GM Brake Service Procedure
      • Brake Lathe Calibration Procedure
      • Brake Pulsation
      • Brake Rotor Clean-Up Procedure
      • Brake Noise
      • Key Points - Frequently Asked Questions
      • Brake Warranty
  • OnStar(R) - Negative Impact of Cloth/Vinyl Roofs
  • Body - Bumps or Rust Colored Spots in Paint
  • Engine - Noise/Damage Oil Filter Application Importance
  • Engine - Drive Belt Misalignment Diagnostics
  • Body - Maintaining Exterior Weatherstrip Appearance
  • 06-08-111-004B - BULLETIN CANCELLATION NOTIFICATION
  • Body - Stain/Film On Windshield Glass Perimeter
  • Wheels/Tires - Accessory Wheel And Tire Information
  • Steering - Power Steering Pump Replacement Tips
  • Steering - Steering Gear Stub Shaft Bearing Kit
  • Wheels/Tires - Replacement Wheel Weight Information
  • Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
  • Tires/Wheels - Tire Puncture Repair Procedures
  • Lighting - Headlamp Warranty Replacement Guideline
  • Mirrors - Heated Mirrors, Defrosting Time
  • A/T - Goodwrench Transmission Replacement
  • Interior - Proper Use of Floor Mats
  • Wheels - Changing Procedures/Precautions
  • Body - Squeeze Type Resistance Spot Welding/Equipment
  • Restraints - Extender Availability For Seat Belt
  • Interior - Seat Cover Wrinkle/Crease/Burn Info
  • A/T - Water Or Coolant Contamination Information
  • Body - Drilling High Strength Steel Using CryoCobalt(R)
  • Body - Vehicle Glass Distortion Information
  • Fuel System - TOP TIER Detergent Gasoline (Canada)
  • Tires/Wheels - Information on Tire Radial Force Variation (RFV)
  • Engine - GM Dexos 1(R) And 2(R) Oil Specifications
  • Engine - GM dexos 1(R) and dexos 2(R) Oil Specifications/Info.
  • Body - Pre-Painting/Cleaning Process For TPO Plastic Fascias
  • Drivetrain - Information on Driveline Clunk Noise
  • Wheels - Chromed Aluminum Wheel Staining/Pitting/Corrosion
  • Navigation System - DVD Navigation Update Program
  • Body - Paint-less Dent Repair Process
  • Wipers/Washers - Windshield Wiper Performance Information
  • A/T - 4T80-E (MH1) Left Front. Axle Seal Leak, Slipping
  • Electrical - Ground Repair Information